2006 DODGE POWER WAGON power steering

Refrigerant Recovery and Recycling
R-134a Air Conditioning Refrigerant is a hydrofluorocar-
bon (HFC) that is endorsed by the Environmental Pro-
tection Agency and is an ozone-saving product. How-
ever, the manufacturer recommends that air conditioning
service be performed by dealers or other service facilities
using recovery and recycling equipment.
NOTE:Use only manufacturer approved A/C System
Sealers, Stop Leak Products, Seal Conditioners, Compres-
sor Oil, or Refrigerants.
Power Steering — Fluid Check
Checking the power steering fluid level at a defined
service interval is not required. The fluid should only be
checked if a leak is suspected, abnormal noises are
apparent, and/or the system is not functioning as antici-
pated. Coordinate inspection efforts through a certified
DaimlerChrysler Dealership.
WARNING!
Fluid level should be checked on a level surface and
with the engine off to prevent injury from moving
parts and to insure accurate fluid level reading. Do
not overfill. Use only manufacturers recommended
power steering fluid.
If necessary, add fluid to restore to the proper indicated
level. With a clean cloth, wipe any spilled fluid from all
surfaces. Refer to Fluids, Lubricants, and Genuine Parts
for correct fluid type.
Front Suspension Ball Joints
NOTE:When anticipating any severe offroad or hill
climbing maneuvers, the power steering fluid level may
be increased to the FULL HOT level (with a cold system).
In this way, the power steering system will continue to
380 MAINTAINING YOUR VEHICLE

Chassis
Component Fluids, Lubricants and Genuine Parts.
Automatic Transmission MoparATF+4, Automatic Transmission Fluid
Transfer Case MoparATF+4, Automatic Transmission Fluid
Manual Transmission Fluid (G-56) MoparATF+4, Automatic Transmission Fluid
Front Driveshaft Grease Fitting. Use Mopartype MS-6560 (lithium based grease), or equivalent.
Clutch Linkage Multipurpose Grease, NLGI Grade 2 E.P.
Front and Rear Axle Synthetic, GL-5 SAE, 75W-90. Limited-Slip 10.5 inch Rear AxleDOES NOT
REQUIREa limited slip additive.
Brake Master Cylinder MoparDOT 3 and SAE J1703 should be used. If DOT 3 brake fluid is not
available, then DOT 4 is acceptable. Use only recommended brake fluids.
Power Steering Reservoir MoparATF+4, Automatic Transmission Fluid
MAINTAINING YOUR VEHICLE 419
7

B-Pillar Location........................ 301
Brake Fluid............................ 419
Brake System........................293,389
Anti-Lock........................... 294
Disc Brakes.......................... 389
Hoses.............................. 391
Master Cylinder....................... 389
Parking............................. 292
Warning Light........................ 173
Break-In Recommendations, New Vehicle........ 69
Bulb Replacement....................... 407
Bulbs,Light ............................ 406
Cab Top Clearance Lights.................. 414
Calibration, Compass..................... 139
Camper............................... 160
Capacities, Fluid........................ 417
Caps, Filler
Oil (Engine).......................... 373Power Steering........................ 380
Car Washes............................ 401
Carbon Monoxide Warning............ 71,162,322
CargoLight ............................ 125
Cassette Tape and Player Maintenance......... 211
Catalytic Converter....................323,376
CD Player.......................177,182,195
Cellular Phone.......................... 90
Center High Mounted Stop Light............ 412
Center Lap Belts......................... 42
Center Seat Storage Compartment............ 154
Certification Label....................... 324
Chart, Tire Sizing........................ 298
Check Engine Light (Malfunction Indicator Light) . 172
Child Restraint........................ 57,58
Child Restraint Tether Anchors............. 62,65
Child Seat............................ 58,64
Cigar Lighter........................... 152
Climate Control......................... 213
INDEX 453
10

Clock .............................176,196
Clutch............................... 391
Clutch Linkage Maintenance................ 391
Compact Disc Maintenance................. 212
Compact Spare Tire...................... 309
Compass...........................138,139
Compass Calibration..................... 139
Compass Variance....................... 140
Computer, Trip/Travel.................... 135
Console, Overhead....................... 134
Contract, Service........................ 446
Converter, Catalytic...................... 323
Cooling System......................... 385
Coolant Capacity...................... 417
Coolant Level......................... 385
Disposal of Used Coolant................ 388
Drain, Flush, and Refill.................. 386
Inspection........................... 385
Radiator Cap......................385,388Selection of Coolant (Antifreeze)......387,417,418
Temperature Gauge..................... 170
Cruise Control (Speed Control).............. 130
CupHolder ............................ 153
Customer Assistance..................... 444
Data Recorder, Event...................... 56
Daytime Running Lights................... 124
Dealer Service.......................... 369
Defroster, Rear Window.............. 88,219,223
Defroster, Windshield..................215,217
Delay (Intermittent) Wipers................. 128
Differential............................. 80
Differential, Limited-Slip.................. 291
Digital Video Disc Player................... 80
Dipsticks
Automatic Transmission................. 393
Power Steering........................ 380
Disc Brakes............................ 389
454 INDEX

Event Data Recorder...................... 56
Exhaust Gas Caution.............. 71,162,322,384
Exhaust System....................... 71,384
Exterior Lighting........................ 123
Filters
Air Cleaner........................375,398
Engine Fuel.......................... 375
Engine Oil........................374,418
Engine Oil Disposal.................... 374
Flashers
Turn Signal.......................... 125
Flat Tire Stowage.....................349,355
Flooded Engine Starting................... 278
Fluid, Brake........................... 419
Fluid Capacities......................... 417
Fluid Level Checks
Automatic Transmission................. 393
Power Steering........................ 380Fluids, Lubricants and Genuine Parts.......... 418
Fog Lights.......................124,174,415
Fold Flat Load Floor..................... 156
Four Wheel Drive....................... 287
Four-Way Hazard Flasher.................. 346
Freeing A Stuck Vehicle................... 359
FrontAxle ............................. 391
Front Wheel Bearings..................... 396
Fuel................................. 317
Adding............................. 319
Filter ............................... 375
Gauge.............................. 175
Octane Rating......................317,418
Requirements......................317,417
Tank Capacity........................ 417
Fueling ............................... 319
Fuses................................ 405
Garage Door Opener..................... 142
456 INDEX

Cruise .............................. 176
Daytime Running...................... 124
Fog ..........................124,174,415
Four-Wheel Drive Indicator............... 290
Hazard Warning Flasher................. 346
Headlights........................... 123
High Beam........................127,169
High Beam Indicator.................... 169
High Beam/Low Beam Select............. 127
Instrument Cluster..................... 168
Intensity Control....................... 122
Interior..........................121,134
Lights On Reminder.................... 124
Passing............................. 126
Seat Belt Reminder..................... 169
Service...........................406,407
Transfer Case......................... 290
Transmission Warning................... 175
Turn Signal..................125,168,407,410Warning (Instrument Cluster Description)..... 168
Limited-Slip Differential................291,392
Loading Vehicle......................... 324
Tires ............................... 301
Locks................................. 17
Child Protection........................ 21
Door................................ 17
Ignition.............................. 15
Keys................................ 12
Power Door........................... 18
Steering Wheel......................... 15
Lower Anchors and Tether for CHildren (LATCH) . 62
Lubricants............................. 396
Lubrication, Body....................... 382
LugNuts ............................. 353
Lumbar Support........................ 116
Maintenance........................... 370
Maintenance Free Battery.................. 378
INDEX 459
10

Materials Added to..................... 373
Pressure Gauge....................... 169
Recommendation...................372,417
Synthetic............................ 373
Viscosity..........................373,417
Onboard Diagnostic System................ 367
Opener, Garage Door..................... 142
Operating Precautions.................... 367
Outside Rearview Mirrors.................. 86
Overdrive............................. 282
Overdrive OFF Switch.................... 282
Overhead Console....................134,135
Overhead Travel Information Center.......... 135
Owner’s Manual........................ 448
Parking Brake.......................... 292
Passenger Airbag On/Off Switch............. 51
Passing Light........................... 126
Phone, Cellular.......................... 90Phone, Hands-Free....................... 90
Pickup Box............................ 159
Placard, Tire and Loading Information......... 302
Positive Crankcase Valve.................. 378
Power
Distribution Center..................... 405
Door Locks........................... 18
Mirrors .............................. 87
Outlet.............................. 151
Seats............................... 117
Steering..........................296,380
Sunroof............................. 148
Windows............................. 30
Power Steering Fluid..................... 419
Power Wagon Features..................... 80
Pregnant Women and Seat Belts.............. 45
Pretensioners
Seat Belts............................. 43
Programmable Electronic Features.........143,147
INDEX 461
10

Snow Plow............................ 340
Snow Tires............................ 315
Spare Tire..........................309,310
Spark Plugs............................ 375
Speed Control.......................... 130
Speedometer........................... 169
Springs................................ 82
Stabilizer Bars, Electronic Disconnecting........ 81
Starting............................... 277
Automatic Transmission................. 278
Engine Fails to Start.................... 278
Manual Transmission................... 277
Steering
Column Controls...................... 125
Column Lock.......................... 15
Linkage............................. 381
Power...........................296,380
Wheel, Tilt........................... 129
Storage, Behind the Seat................... 154Storage Compartment, Center Seat........... 154
Storage, Vehicle......................... 405
StoringYourVehicle ...................... 405
Sun Roof.............................. 148
Supplemental Tire Pressure Information........ 314
Synthetic Engine Oil...................... 373
Tachometer............................ 168
Tailgate............................... 161
Tether Anchor, Child Restraint............. 62,65
Tilt Steering Column..................... 129
Tire and Loading Information Placard....301,302,314
Tire Identification Number (TIN)............. 300
Tire Markings.......................... 296
Tire Safety Information.................... 296
Tires ............................. 72,82,305
Air Pressure.......................... 305
Alignment........................... 313
Chains.............................. 314
464 INDEX