2006 DODGE MAGNUM radiator

•If frequent coolant additions are required, or if the
level in the coolant recovery bottle does not drop when
the engine cools, the cooling system should be pres-
sure tested for leaks.
•Maintain coolant concentration at 50% HOAT engine
coolant (minimum) and distilled water for proper
corrosion protection of your engine which contains
aluminum components.
•Make sure that the radiator and coolant recovery
bottle overflow hoses are not kinked or obstructed.
•Keep the front of the radiator clean. If your vehicle is
equipped with air conditioning, keep the front of the
condenser clean, also.
•Do not change the thermostat for summer or winter
operation. If replacement is ever necessary, install
ONLY the correct type thermostat. Other designs may
result in unsatisfactory coolant performance, poor gas
mileage, and increased emissions.
Hoses And Vacuum/Vapor Harnesses
Inspect surfaces of hoses and nylon tubing for evidence
of heat and mechanical damage. Hard or soft spots,
brittle rubber, cracking, tears, cuts, abrasions, and exces-
sive swelling indicate deterioration of the rubber.
Pay particular attention to those hoses nearest to high
heat sources such as the exhaust manifold. Inspect hose
routing to be sure hoses do not come in contact with any
heat source or moving component which may cause heat
damage or mechanical wear.
Insure nylon tubing in these areas has not melted or
collapsed.
Inspect all hose connections such as clamps and cou-
plings to make sure they are secure and no leaks are
present.
Components should be replaced immediately if there is
any evidence of wear or damage that could cause failure.
MAINTAINING YOUR VEHICLE 309
7

Cavity Fuse Circuits
13——
14 25 Amp
ClearPowertrain Control Module (PCM)
15 25 Amp
ClearInjectors, Ignition Coils
16——
17 30 Amp
PinkAntilock Brakes System (ABS)
Valves/Powertrain Control Module
(PCM)
18 30 Amp
PinkWindshield Wiper/Washer
19 50 Amp
RedRadiator Fan
20 20 Amp
BlueStarter
21 50 Amp
RedAntilock Brakes System (ABS)
Pump Motor
22 40 Amp
GreenAC Clutch/Radiator Fan High—
Low
23——Cavity Fuse Circuits
24 60 Amp
YellowRadiator Fan - AWD
25 30 Amp
PinkFront Control Module (FCM)
26 20 Amp
BlueTransmission - RLE
27 30 Amp
PinkFront Control Module (FCM)
320 MAINTAINING YOUR VEHICLE

At Each Stop for Fuel
•
Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required.
Once a Month
•
Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir and brake
master cylinder, and add as needed.
•Check all lights and all other electrical items for correct
operation.
•Check rubber seals on each side of the radiator for
proper fit.
At Each Oil Change
•
Change the engine oil filter.
•Inspect the exhaust system.
•Inspect the brake hoses.
•Inspect the CV joints and front and rear suspension
components.
•Check the coolant level, hoses, and clamps.
338 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Ball Joints............................ 302
Battery............................... 299
Jump Starting........................ 277
Keyless Transmitter Replacement (RKE)..... 24
Location.........................278,299
Bearings.............................. 314
Belts, Drive........................... 296
Body Mechanism Lubrication.............. 302
B-Pillar Location....................... 227
Brake Assist System..................... 106
Brake, Parking......................... 217
Brake System.......................219,310
Anti-Lock (ABS)...................... 219
Fluid Check...................... 311,333
Hoses.............................. 310
Warning Light....................... 145
Brake/Transmission Interlock.............. 216
Break-In Recommendations, New Vehicle...... 58
Bulb Replacement...................... 326
Bulbs, Light........................... 325
Calibration, Compass.................... 152
Capacities, Fluid....................... 331Caps, Filler
Fuel............................... 250
Radiator (Coolant Pressure).............. 307
Car Washes........................... 315
Carbon Monoxide Warning.............59,249
Cargo Compartment
Luggage Carrier...................... 131
Cargo Management System............... 125
Cargo Organizer...................... 129
Rollaway Tonneau Cover............... 127
Tri-Fold Load Floor.................... 126
Waterproof Liner..................... 129
Cargo Tie-Downs....................... 130
Cassette Tape and Player Maintenance....... 185
Catalytic Converter..................... 297
CD (Compact Disc) Player.............160,166
Cellular Phone.......................... 68
Chains, Tire........................... 244
Changing A Flat Tire.................... 269
Chart, Tire Sizing....................... 224
Child Restraint...................51,53,55,56
Child Restraint Tether Anchors............. 55
Child Safety Locks....................... 19
INDEX 361
10

Clean Air Gasoline...................... 247
Climate Control........................ 187
Clock..........................161,167,183
Compact Disc (CD) Maintenance........... 186
Compact Spare Tire..................... 234
Compass............................. 152
Compass Calibration.................... 152
Compass Variance...................... 152
Computer, Trip/Travel................... 150
Console.............................. 125
Console, Floor......................... 125
Console, Overhead...................... 112
Contract, Service....................... 354
Coolant Pressure Cap.................... 307
Cooling System........................ 305
Adding Coolant (Antifreeze)............. 306
Coolant Capacity..................... 331
Coolant Level.....................305,308
Disposal of Used Coolant............... 308
Drain, Flush, and Refill................. 306
Inspection........................... 308
Points to Remember................... 308
Pressure Cap........................ 307Radiator Cap........................ 307
Selection of Coolant (Antifreeze)....306,331,332
Cruise Control (Speed Control)............. 109
Cup Holder........................124,317
Customer Assistance.................... 352
Data Recorder, Event..................... 49
Dealer Service......................... 290
Defroster, Rear Window.................. 188
Defroster, Windshield...............60,189,194
Delay (Intermittent) Wipers............... 101
Diagnostic System, Onboard............... 288
Dimmer Switch, Headlight................ 100
Disposal
Antifreeze (Engine Coolant)............. 308
Door Locks............................ 15
Door Locks, Automatic................... 17
Door Opener, Garage.................... 113
Drive Belts............................ 296
Driving
On Slippery Surfaces.................. 279
DVD Player (Video Entertainment System).... 181
362 INDEX

Identification Logo.................... 294
Materials Added to.................... 295
Recommendation..................293,331
Synthetic........................... 295
Viscosity.........................294,331
Onboard Diagnostic System............288,289
Opener, Garage Door (HomeLink) ......... 113
Operator Manual (Owner’s Manual).......... 4
Overhead Console...................... 112
Overheating, Engine..................142,268
Owner’s Manual (Operator Manual).......4,355
Panic Alarm........................... 22
Parking Brake......................... 217
Parking On Hill........................ 218
Passing Light.......................... 100
Pedals, Adjustable....................... 93
Personal Settings....................... 155
Pets.................................. 58
Phone, Cellular......................... 68
Phone, Hands-Free (UConnect™) ............ 68
Placard, Tire and Loading Information....... 227Power
Brakes............................. 219
Distribution Center.................... 318
Door Locks.......................... 16
Mirrors............................. 67
Outlet (Auxiliary Electrical Outlet)........ 121
Seats............................... 88
Steering............................ 222
Steering, Checking.................... 302
Sunroof............................ 118
Windows............................ 27
Pregnant Women and Seat Belts............. 37
Preparation for Jacking................... 270
Programmable Electronic Features..... 114,117,155
Programming Transmitters
(Remote Keyless Entry)................ 114,117
Radial Ply Tires........................ 234
Radiator Cap (Coolant Pressure Cap)........ 307
Radio Broadcast Signals.................. 158
Radio Operation..................160,166,187
Radio Remote Controls.................. 183
Radio, Satellite......................... 178
368 INDEX