2006 DODGE CARAVAN maintenance schedule

MAINTENANCE SCHEDULES
CONTENTS

Emission Control System Maintenance........448

Maintenance Schedules...................448▫Schedule“B”........................451
▫Schedule“A”........................463
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

EMISSION CONTROL SYSTEM MAINTENANCE
The“Scheduled”maintenance services, listed inbold
typemust be done at the times or mileages specified to
assure the continued proper functioning of the emission
control system. These, and all other maintenance services
included in this manual, should be done to provide best
vehicle performance and reliability. More frequent main-
tenance may be needed for vehicles in severe operating
conditions such as dusty areas and very short trip
driving.
Inspection and service also should be done any time a
malfunction is suspected.
NOTE:Maintenance, replacement, or repair of the emis-
sion control devices and systems on your vehicle may be
performed by any automotive repair establishment or
individual using any automotive part which has been
certified pursuant to U.S. EPA or, in the State of Califor-
nia, California Air Resources Board regulations.
MAINTENANCE SCHEDULES
There are two maintenance schedules that show the
requiredservice for your vehicle.
First is Schedule“B”. It is for vehicles that are operated
under the conditions that are listed below and at the
beginning of the schedule.
•Day or night temperatures are below 32°F(0°C).
•Stop and go driving.
•Extensive engine idling.
•Driving in dusty conditions.
•Short trips of less than 10 miles (16 km).
•More than 50% of your driving is at sustained high
speeds during hot weather, above 90°F (32°C).
•Trailer towing.
448 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

•Taxi, police, or delivery service (commercial ser-
vice).
•Off-road or desert operation.
NOTE:Most vehicles are operated under the conditions
listed for ScheduleB.
Second is Schedule“A”. It is for vehicles that are not
operated under any of the conditions listed under Sched-
uleB.
Use the schedule that best describes your driving condi-
tions. Where time and mileage are listed, follow the
interval that occurs first.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
At Each Stop for Fuel
•Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required.
Once a Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder and transmission; add as needed.
MAINTENANCE SCHEDULES 449
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

•Check all lights and all other electrical items for correct
operation.
At Each Oil Change
•Change the engine oil filter.
•Inspect the exhaust system.
•Inspect the brake hoses.
•Inspect the CV joints and front suspension compo-
nents.
•Check the automatic transmission fluid level.
•Check the coolant level, hoses, and clamps.
450 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 138, 000 141, 000 144, 000 147, 000 150, 000
(Kilometers) (230 000) (235 000) (240 000) (245 000) (250 000)
Inspect the tie rod ends and boot seals. X
Inspect thePCV valveand replace as necessary.* X
Replace the air conditioning filter. X
* This maintenance is recommended by the manufacture
to the owner but is not required to maintain the emis-
sions warranty.
‡This maintenance is not required if previously replaced.
This maintenance is required only for police, taxi,
limousine type operation, or trailer towing.Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
462 SCHEDULE“B”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 126, 000 132, 000 138, 000 144, 000 150, 000
(Kilometers) (210 000) (220 000) (230 000) (240 000) (250 000)
[Months] [126] [132] [138] [144] [150]
Inspect the serpentine drive belt on 3.3 liter and
3.8 liter engines, replace if necessary.‡XX
Replace the air conditioning filter. X X
* This maintenance is recommended by the manufacture
to the owner but is not required to maintain the emis-
sions warranty.
‡This maintenance is not required if previously replaced.
Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
WARNING!
You can be badly injured working on or around a
motor vehicle. Do only that service work for which
you have the knowledge and the right equipment. If
you have any doubt about your ability to perform a
service job, take your vehicle to a competent me-
chanic.
SCHEDULE“A”471
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Reading............................. 158
Rear Servicing........................ 441
Rear Tail............................ 441
Seat Belt Reminder..................... 207
Security Alarm (Theft Alarm).............. 208
Service...........................437,438
Service Engine Soon (Malfunction Indicator) . . . 210
Side Marker.......................... 441
Theft Alarm (Security Alarm).............. 208
Turn Signal.....................147,439,441
Voltage............................. 207
Warning (Instrument Cluster Description)..... 204
Washer Fluid......................... 209
Load Leveling System.................... 193
Loading Vehicle...................189,348,349
Capacities........................... 349
Tires ............................... 324
Locks
Door................................ 17Lower Anchors and Tether for CHildren (LATCH) . 74
Lubrication, Body....................... 413
Luggage Rack (Roof Rack)................. 190
Lumbar Support........................ 122
Maintenance, Airbag...................... 68
Maintenance Free Battery.................. 409
Maintenance Procedures................... 401
Maintenance Schedule.................... 448
Schedule“A”......................... 463
Schedule“B”......................... 451
Maintenance, Sunroof..................... 175
Malfunction Indicator Light (Check Engine) . . 210,399
Manual, Service......................... 478
Map/Reading Lights..................... 158
Mini-Trip Computer...................... 162
Mirrors................................ 90
Automatic Dimming..................... 90
Electric Remote........................ 92
INDEX 491
10

Rear Air Conditioning.................282,291
Rear Cup Holder........................ 179
Rear Heater............................ 282
Rear Seat Removal....................133,135
Rear Seating Flexibility.................138,139
Rear Window Defroster................... 300
Rear Window Features.................... 296
Rear Wiper/Washer...................297,298
Rearview Mirrors........................ 90
Reclining Front Seats..................... 120
Recreational Towing...................363,392
Reminder, Seat Belt....................... 52
Remote Control......................... 258
Remote Keyless Entry (RKE)................. 20
Remote Sound System (Radio) Controls........ 270
Removable Floor Console...............184,185
Replacement Keys........................ 15
Replacement Parts....................... 400
Replacement Tires....................... 335Reporting Safety Defects................... 477
Restraint, Head......................... 119
Restraints, Child.......................69,76
Restraints, Infant......................... 70
Rocking Vehicle When Stuck................ 390
Roof Rack (Luggage Rack)................. 190
Rotation, Tires.......................... 341
Safety Checks Inside Vehicle................. 83
Safety Checks Outside Vehicle............... 84
Safety Defects, Reporting.................. 477
Safety, Exhaust Gas....................... 37
Safety Information, Tire................... 320
Safety Tips............................. 83
Satellite Radio.......................... 266
Satellite Radio Antenna................... 269
Schedule, Maintenance.................... 448
Seat Belt Maintenance.................... 432
Seat Belt Reminder....................... 52
494 INDEX