2006 CHRYSLER TOWN AND COUNTRY service interval

MAINTENANCE Scheduled maintenance must be completed to provide the best vehicle
performance and reliability. The limited warranties in the warranty booklet DO NOT COVER repairs
required due to improper maintenance. We strongly suggest you keep track of scheduled maintenance and
keep receipts or other documents. Use only recommended Mopar Lubricants and genuine Mopar
®Parts. In
the event that a condition arises between maintenance intervals, please contact your retailer. AV O I D
PROLONGED PERIODS OF IDLING.
NOTE: WHERE TIME (MONTHS) AND METRAGE ARE INDICATED, FOLLOW THE INTERVAL
THAT OCCURS FIRST.
AT EACH STOP FOR FUEL
• Check the engine oil level about 5 minutes after
a fully warmed engine is shut off. Checking the
oil level while the vehicle is on level ground will
improve the accuracy of the oil-level reading.
Add oil only when the level is at or below the
ADD or MIN mark.
• Check the windshield-washer solvent and add
if required.
ONCE A MONTH
• Check the tire pressure and look for unusual
wear or damage.
• Inspect the battery and clean and tighten the
terminals as required.
• Check the fluid levels of coolant reservoir, brake
master cylinder, power steering and transmission
and add as needed.
• Check all the lights and all other electrical items
for correct operation.
• Check rubber seals on each side of the radiator
for proper fit.
• Check and clean wiper blades. Replace if required.
VISUAL INSPECTIONS –
INSPECT FOR SIGNS OF COMPONENT
DETERIORATION AND PHYSICAL DAMAGE.
There are two maintenance schedules
contained in your Owner’s Manual. Schedule
“B” best describes operating conditions in
Canada and is the recommended service
schedule. For your convenience, the scheduled
maintenance intervals outlined in this booklet
follow the Severe Service Schedule as described
in your Owner’s Manual. Schedule “B” is for
vehicles that are operated under one or more of
the following conditions: day or night tempera-
tures are below 0°C (90°F); stop-and-go driving;
extensive engine idling; driving in dusty
conditions; short trips of less than 16.2 km (10mi.); more than 50% of your driving is at
sustained high speeds during hot weather,
above 32°C (90°F); trailer towing; taxi, police, or
delivery service (commercial service); off-road
or desert driving; if equipped for and operating
with E-85 (ethanol) fuel. Schedule “A” is for
vehicles that are not operated under any of the
conditions listed under Schedule “B.”
The performance of all scheduled service
work is required to maintain your vehicle in
good operating condition. DaimlerChrysler
Canada Inc. reserves the right to deny
warranty coverage if the vehicle has not been
properly maintained. While we do not insist
that such work be performed by factory-
authorized retailers, we strongly recommend
that an authorized Chrysler, Jeep
®or Dodge
Retailer perform this work. INTRODUCTION

Retailer Copy
Remove and attach to Repair Order
26-92-02-01 3N.
Maintenance Service
Schedule “B”
2006 Passenger Car • Minivan • Pacifica
Odometer Reading
Date
25,000 km Maintenance Service Schedule “B”
25,000 km

Change engine oil and engine oil filter (or every 3 months).

Inspect and lubricate, as required, all steering and suspension components.

Inspect the engine air cleaner filter and replace if necessary
(Sebring, and PT Cruiser only).

Replace the engine air cleaner filter if required (Pacifica and Minivan only).

Inspect the make-up air filter, replace as necessary (PT Cruiser only).

Change the all-wheel-drive power transfer unit fluid (Pacifica only).*
INSPECT THE FOLLOWING:

Inspect the brake linings, hoses and calipers (Sebring only).

Inspect the brake hoses (PT Cruiser, Pacifica and Minivan only).

Check the brake master cylinder fluid level (Sebring only).

Check the automatic transmission fluid level.

Check the manual transaxle fluid level and fill-plug condition (if equipped)
(PT Cruiser only).

Check the coolant level, hoses and clamps.

Inspect the exhaust system.
*The all-wheel-drive power transfer unit fluid and overrunning clutch/rear carrier
fluid must be changed at more frequent intervals than shown in schedule B if the
vehicle is used for trailer tow, taxi, police or other type of commercial service.

DAIMLERCHRYSLER
RETAILERSTA M P
Signature of authorized DaimlerChrysler Canada Retailer
2006 Passenger Car • Minivan • Pacifica
Odometer Reading
Date
Repair Order No.

Change engine oil and engine oil filter (or every 3 months).

Inspect and lubricate, as required, all steering and
suspension components.

Inspect the engine air cleaner filter and replace if necessary
(Sebring, and PT Cruiser, only).

Replace the engine air cleaner filter if required (Pacifica
and Minivan only).

Inspect the make-up air filter, replace as necessary
(PT Cruiser only).

Change the all-wheel-drive power transfer unit fluid
(Pacifica only).*
INSPECT THE FOLLOWING:

Inspect the brake linings, hoses and calipers
(Sebring only).

Inspect the brake hoses (PT Cruiser, Pacifica and
Minivan only).

Check the brake master cylinder fluid level (Sebring only).

Check the automatic transmission fluid level.

Check the manual transaxle fluid level and fill-plug
condition (if equipped) (PT Cruiser only).

Check the coolant level, hoses and clamps.

Inspect the exhaust system.
*The all-wheel-drive power transfer unit fluid and overrunning
clutch/rear carrier fluid must be changed at more frequent intervals
than shown in schedule B if the vehicle is used for trailer tow, taxi,
police or other type of commercial service.
Maintenance Service Schedule “B”
25,000 km

Retailer Copy
Remove and attach to Repair Order
26-92-02-01 3N.
Maintenance Service
Schedule “B”
2006 Passenger Car • Minivan • Pacifica
Odometer Reading
Date
35,000 km Maintenance Service Schedule “B”
35,000 km

Change engine oil and engine oil filter (or every 3 months).

Inspect and lubricate, as required, all steering and suspension components.

Inspect the engine air cleaner filter and replace if necessary (Sebring,
Pacifica and Minivan only).

Change the all-wheel-drive overrunning clutch and rear carrier fluid (Pacifica only).*
INSPECT THE FOLLOWING:

Inspect the brake linings, hoses and calipers (Sebring only).

Inspect the brake hoses (PT Cruiser, Pacifica and Minivan only).

Check the brake master cylinder fluid level (Sebring only).

Check the automatic transmission fluid level.

Check the manual transaxle fluid level and fill-plug condition (if equipped)
(PT Cruiser only).

Check the coolant level, hoses and clamps.

Inspect the exhaust system.
*The all-wheel-drive power transfer unit fluid and overrunning clutch/rear carrier fluid
must be changed at more frequent intervals than shown in schedule B if the vehicle
is used for trailer tow, taxi, police or other type of commercial service.

DAIMLERCHRYSLER
RETAILERSTA M P
Signature of authorized DaimlerChrysler Canada Retailer
2006 Passenger Car • Minivan • Pacifica
Odometer Reading
Date
Repair Order No.

Change engine oil and engine oil filter (or every 3 months).

Inspect and lubricate, as required, all steering and
suspension components.

Inspect the engine air cleaner filter and replace if
necessary (Sebring, Pacifica and Minivan only).

Change the all-wheel-drive overrunning clutch and
rear carrier fluid (Pacifica only).*
INSPECT THE FOLLOWING:

Inspect the brake linings, hoses and calipers
(Sebring only).

Inspect the brake hoses (PT Cruiser, Pacifica and
Minivan only).

Check the brake master cylinder fluid level
(Sebring only).

Check the automatic transmission fluid level.

Check the manual transaxle fluid level and fill-plug
condition (if equipped) (PT Cruiser only).

Check the coolant level, hoses and clamps.

Inspect the exhaust system.
*The all-wheel-drive power transfer unit fluid and overrunning
clutch/rear carrier fluid must be changed at more frequent intervals
than shown in schedule B if the vehicle is used for trailer tow, taxi,
police or other type of commercial service.
Maintenance Service Schedule “B”
35,000 km

Retailer Copy
Remove and attach to Repair Order
26-92-02-01 3N.
Maintenance Service
Schedule “B”
2006 Passenger Car • Minivan • Pacifica
Odometer Reading
Date
50,000 km Maintenance Service Schedule “B”
50,000 km

Change engine oil and engine oil filter (or every 3 months).

Inspect and lubricate, as required, all steering and suspension components.

Replace the engine air cleaner filter if required (all models).

Replace the spark plugs (PT Cruiser and Sebring 2.4L engine only).

Check and replace, if necessary, the PCV valve (not required if previously replaced).

Replace the make-up air filter (PT Cruiser only).

Adjust the generator drive belt tension. (PT Cruiser only).

Inspect and check tension for power steering belt. Adjust or replace if required
(2.4L Sebring only).

Change the all-wheel-drive power transfer unit fluid (Pacifica only).*

Rotate tires and check tire pressure.
INSPECT THE FOLLOWING:
Inspect the brake linings, hoses and calipers (Sebring only).

Inspect the brake hoses (PT Cruiser, Pacifica and Minivan only).

Check the brake master cylinder fluid level (Sebring only).

Check the automatic transmission fluid level.

Check the manual transaxle fluid level and fill-plug condition (if equipped)
(PT Cruiser only).

Inspect the tie rod ends and boot seals (PT Cruiser, Pacifica and Minivan only).

Check the coolant level, hoses and clamps.

Inspect the exhaust system.
*The all-wheel-drive power transfer unit fluid and overrunning clutch/rear carrier fluid
must be changed at more frequent intervals than shown in schedule B if the vehicle
is used for trailer tow, taxi, police or other type of commercial service.

DAIMLERCHRYSLER
RETAILERSTA M P
Signature of authorized DaimlerChrysler Canada Retailer
2006 Passenger Car • Minivan • Pacifica
Odometer Reading
Date
Repair Order No.

Change engine oil and engine oil filter (or every 3 months).

Inspect and lubricate, as required, all steering and suspension
components.

Replace the engine air cleaner filter if required (all models).

Replace the spark plugs (PT Cruiser and Sebring 2.4L engine
only).

Check and replace, if necessary, the PCV valve (not required if
previously replaced).

Replace the make-up air filter (PT Cruiser only).

Adjust the generator drive belt tension (PT Cruiser only).

Inspect and check tension for power steering belt. Adjust or
replace if required (2.4L Sebring only).

Change the all-wheel-drive power transfer unit fluid
(Pacifica only).
*
Rotate tires and check tire pressure.
INSPECT THE FOLLOWING:

Inspect the brake linings, hoses and calipers (Sebring only).

Inspect the brake hoses (PT Cruiser, Pacifica and Minivan
only).

Check the brake master cylinder fluid level (Sebring only).

Check the automatic transmission fluid level.

Check the manual transaxle fluid level and fill-plug condition
(if equipped) (PT Cruiser only).

Inspect the tie rod ends and boot seals (PT Cruiser, Pacifica and
Minivan only).

Check the coolant level, hoses and clamps.

Inspect the exhaust system.
*The all-wheel-drive power transfer unit fluid and overrunning clutch/rear
carrier fluid must be changed at more frequent intervals than shown in
schedule B if the vehicle is used for trailer tow, taxi, police or other type of
commercial service.
Maintenance Service Schedule “B”
50,000 km

Retailer Copy
Remove and attach to Repair Order
26-92-02-01 3N.
Maintenance Service
Schedule “B”
2006 Passenger Car • Minivan • Pacifica
Odometer Reading
Date
70,000 km Maintenance Service Schedule “B”
70,000 km

Change engine oil and engine oil filter (or every 3 months).

Inspect and lubricate, as required, all steering and suspension components.

Inspect the engine air cleaner filter and replace if necessary (Sebring, Pacifica
and Minivan only).

Change the all-wheel-drive overrunning clutch and rear carrier fluid (Pacifica only).*

Rotate tires and check tire pressure.
INSPECT THE FOLLOWING:

Inspect the brake linings, hoses and calipers (Sebring only).

Inspect the brake hoses (PT Cruiser, Pacifica and Minivan only).

Check the brake master cylinder fluid level (Sebring only).

Check the automatic transmission fluid level.

Check the manual transaxle fluid level and fill-plug condition (if equipped)
(PT Cruiser only).

Check the coolant level, hoses and clamps.

Inspect the exhaust system.
*The all-wheel-drive power transfer unit fluid and overrunning clutch/rear carrier fluid
must be changed at more frequent intervals than shown in schedule B if the vehicle
is used for trailer tow, taxi, police or other type of commercial service.