2006 CHRYSLER SEBRING clutch

7
3/60 BASIC WARRANTY
If required because of a defect in material or workmanship, the 3/60
Basic Warranty will cover the adjustment, repair or replacement of
any factory-installed part of your vehicle except tires for 3 years or
60,000 kilometres, whichever occurs first. The following items are
exceptions; they are only covered (if defective) for 1 year or 20,000
kilometres, whichever occurs first:
• light bulbs and fuses
• wiper blades
• clutch discs
• brakes (rotors, pads, linings and drums)
• windshield and rear window
• wheel alignment and wheel balancingTires are warranted by the tire manufacturers, not by
DaimlerChrysler. For details, see the tire manufacturer’s warranty
booklet in your glove box. Your DaimlerChrysler Retailer may be
able to assist you if you experience a problem with a factory-
installed tire.
Tires and spare tire should be replaced after six years, regardless
of the remaining tread. Failure to follow this warning can result in
sudden tire failure. You could lose control and have an accident
resulting in serious injury or death.
Your Koss headphones are warranted by the manufacturer, not
by DaimlerChrysler. For details, see the Koss manufacturer’s
warranty card in your glove box.
3/60 BASIC WARRANTY
2006 Passenger Car • Minivan • Pacifica

8
5/100 POWERTRAIN WARRANTY
The following powertrain components are covered for 5 years or
100,000 kilometres, whichever occurs first, measured from the
vehicle’s original warranty start date.
Vehicles placed in police, taxi, limousine, postal or ambulance
service and all SRT vehicles are excluded from the 5-year or
100,000-kilometrePowertrain Warranty and are covered only under
the 3-year or 60,000-kilometreBasic Warranty.
• Engine– Cylinder block and all internal parts; cylinder head
assemblies; timing case, timing chain, timing belt, gears and
sprockets; vibration damper; oil pump; water pump and housing;
intake and exhaust manifolds; flywheel with starter ring gear; core
plugs; valve covers; oil pan; turbocharger housing and internal
parts; turbocharger wastegate actuator; supercharger; serpentine
belt tensioner; seals and gaskets for listed components only. • Transmission– Transmission case and all internal parts; torque
converter; drive/flex plate; transmission range switch;
transmission control module; bell housing; oil pan; seals and
gaskets for listed components only.
Note: Manual transmission clutch parts are not covered at any time.
• Front-Wheel Drive– Transaxle case and all internal parts; axle
shaft assemblies; constant velocity joints and boots; differential
cover; oil pan; transaxle speed sensors; transaxle solenoid
assembly; PRNDL position switch; transaxle electronic controller;
torque converter; seals and gaskets for listed components only.
Note: Manual transmission clutch parts are not covered at any time.
5/100 POWERTRAIN WARRANTY
2006 Passenger Car • Minivan • Pacifica

122006 Passenger Car • Minivan • Pacifica
WHAT IS NOT COVERED
WHAT IS NOT COVERED
DAMAGE FROM MISUSE OR ACCIDENT
The warranties in this booklet do not cover repairs required due to
fire, accidents, abuse, negligence, objects striking your vehicle,
carrying corrosive materials (such as chemicals, acids and
fertilizers), misuse (such as driving over curbs, overloading,
spinning wheels, etc.), racing or participating in a racing event,
improper disconnection of components, modifying the exhaust
system, tampering or making adjustments which do not comply
with DaimlerChrysler specifications.
Disconnecting, tampering with or changing the reading of the
odometer will void your warranties.
DAMAGE FROM THE ENVIRONMENT
The warranties in this booklet do not cover fading or deterioration
caused by exposure to the elements, or repairs required due to
airborne fallout, acid rain, chemicals, tree sap, insects, bird or insect
droppings, salt, sand, gravel, road hazards, hail, windstorms,
lightning, floods or any other event of nature. Road salt, car washes, scuffs and scratches, and everyday
abrasion from sand and dirt can affect the appearance of a vehicle’s
wheels (steel, chrome and aluminum) and other undercarriage
parts. Some surface corrosion with use is normal; it is not a defect
and is not covered by any warranty.
NORMAL MAINTENANCE AND WEAR
The warranties in this booklet do not cover normal
maintenance services, such as oil and filter changes, general
lubrication, tire rotation, engine tune-ups and replacing spark
plugs. Required maintenance services are described in detail in
your Owner’s Manual and herein. The warranties also do not
cover light bulbs and fuses, worn wiper blades, clutch discs, brake
rotors, pads, linings or drums, windshield and rear window,
wheel alignment and wheel balancing (unless they are defective,
see page 7).

Retailer Copy
Remove and attach to Repair Order
26-92-02-01 3N.
Maintenance Service
Schedule “B”
2006 Passenger Car • Minivan • Pacifica
Odometer Reading
Date
25,000 km Maintenance Service Schedule “B”
25,000 km

Change engine oil and engine oil filter (or every 3 months).

Inspect and lubricate, as required, all steering and suspension components.

Inspect the engine air cleaner filter and replace if necessary
(Sebring, and PT Cruiser only).

Replace the engine air cleaner filter if required (Pacifica and Minivan only).

Inspect the make-up air filter, replace as necessary (PT Cruiser only).

Change the all-wheel-drive power transfer unit fluid (Pacifica only).*
INSPECT THE FOLLOWING:

Inspect the brake linings, hoses and calipers (Sebring only).

Inspect the brake hoses (PT Cruiser, Pacifica and Minivan only).

Check the brake master cylinder fluid level (Sebring only).

Check the automatic transmission fluid level.

Check the manual transaxle fluid level and fill-plug condition (if equipped)
(PT Cruiser only).

Check the coolant level, hoses and clamps.

Inspect the exhaust system.
*The all-wheel-drive power transfer unit fluid and overrunning clutch/rear carrier
fluid must be changed at more frequent intervals than shown in schedule B if the
vehicle is used for trailer tow, taxi, police or other type of commercial service.

DAIMLERCHRYSLER
RETAILERSTA M P
Signature of authorized DaimlerChrysler Canada Retailer
2006 Passenger Car • Minivan • Pacifica
Odometer Reading
Date
Repair Order No.

Change engine oil and engine oil filter (or every 3 months).

Inspect and lubricate, as required, all steering and
suspension components.

Inspect the engine air cleaner filter and replace if necessary
(Sebring, and PT Cruiser, only).

Replace the engine air cleaner filter if required (Pacifica
and Minivan only).

Inspect the make-up air filter, replace as necessary
(PT Cruiser only).

Change the all-wheel-drive power transfer unit fluid
(Pacifica only).*
INSPECT THE FOLLOWING:

Inspect the brake linings, hoses and calipers
(Sebring only).

Inspect the brake hoses (PT Cruiser, Pacifica and
Minivan only).

Check the brake master cylinder fluid level (Sebring only).

Check the automatic transmission fluid level.

Check the manual transaxle fluid level and fill-plug
condition (if equipped) (PT Cruiser only).

Check the coolant level, hoses and clamps.

Inspect the exhaust system.
*The all-wheel-drive power transfer unit fluid and overrunning
clutch/rear carrier fluid must be changed at more frequent intervals
than shown in schedule B if the vehicle is used for trailer tow, taxi,
police or other type of commercial service.
Maintenance Service Schedule “B”
25,000 km

Retailer Copy
Remove and attach to Repair Order
26-92-02-01 3N.
Maintenance Service
Schedule “B”
2006 Passenger Car • Minivan • Pacifica
Odometer Reading
Date
35,000 km Maintenance Service Schedule “B”
35,000 km

Change engine oil and engine oil filter (or every 3 months).

Inspect and lubricate, as required, all steering and suspension components.

Inspect the engine air cleaner filter and replace if necessary (Sebring,
Pacifica and Minivan only).

Change the all-wheel-drive overrunning clutch and rear carrier fluid (Pacifica only).*
INSPECT THE FOLLOWING:

Inspect the brake linings, hoses and calipers (Sebring only).

Inspect the brake hoses (PT Cruiser, Pacifica and Minivan only).

Check the brake master cylinder fluid level (Sebring only).

Check the automatic transmission fluid level.

Check the manual transaxle fluid level and fill-plug condition (if equipped)
(PT Cruiser only).

Check the coolant level, hoses and clamps.

Inspect the exhaust system.
*The all-wheel-drive power transfer unit fluid and overrunning clutch/rear carrier fluid
must be changed at more frequent intervals than shown in schedule B if the vehicle
is used for trailer tow, taxi, police or other type of commercial service.

DAIMLERCHRYSLER
RETAILERSTA M P
Signature of authorized DaimlerChrysler Canada Retailer
2006 Passenger Car • Minivan • Pacifica
Odometer Reading
Date
Repair Order No.

Change engine oil and engine oil filter (or every 3 months).

Inspect and lubricate, as required, all steering and
suspension components.

Inspect the engine air cleaner filter and replace if
necessary (Sebring, Pacifica and Minivan only).

Change the all-wheel-drive overrunning clutch and
rear carrier fluid (Pacifica only).*
INSPECT THE FOLLOWING:

Inspect the brake linings, hoses and calipers
(Sebring only).

Inspect the brake hoses (PT Cruiser, Pacifica and
Minivan only).

Check the brake master cylinder fluid level
(Sebring only).

Check the automatic transmission fluid level.

Check the manual transaxle fluid level and fill-plug
condition (if equipped) (PT Cruiser only).

Check the coolant level, hoses and clamps.

Inspect the exhaust system.
*The all-wheel-drive power transfer unit fluid and overrunning
clutch/rear carrier fluid must be changed at more frequent intervals
than shown in schedule B if the vehicle is used for trailer tow, taxi,
police or other type of commercial service.
Maintenance Service Schedule “B”
35,000 km

Retailer Copy
Remove and attach to Repair Order
26-92-02-01 3N.
Maintenance Service
Schedule “B”
2006 Passenger Car • Minivan • Pacifica
Odometer Reading
Date
50,000 km Maintenance Service Schedule “B”
50,000 km

Change engine oil and engine oil filter (or every 3 months).

Inspect and lubricate, as required, all steering and suspension components.

Replace the engine air cleaner filter if required (all models).

Replace the spark plugs (PT Cruiser and Sebring 2.4L engine only).

Check and replace, if necessary, the PCV valve (not required if previously replaced).

Replace the make-up air filter (PT Cruiser only).

Adjust the generator drive belt tension. (PT Cruiser only).

Inspect and check tension for power steering belt. Adjust or replace if required
(2.4L Sebring only).

Change the all-wheel-drive power transfer unit fluid (Pacifica only).*

Rotate tires and check tire pressure.
INSPECT THE FOLLOWING:
Inspect the brake linings, hoses and calipers (Sebring only).

Inspect the brake hoses (PT Cruiser, Pacifica and Minivan only).

Check the brake master cylinder fluid level (Sebring only).

Check the automatic transmission fluid level.

Check the manual transaxle fluid level and fill-plug condition (if equipped)
(PT Cruiser only).

Inspect the tie rod ends and boot seals (PT Cruiser, Pacifica and Minivan only).

Check the coolant level, hoses and clamps.

Inspect the exhaust system.
*The all-wheel-drive power transfer unit fluid and overrunning clutch/rear carrier fluid
must be changed at more frequent intervals than shown in schedule B if the vehicle
is used for trailer tow, taxi, police or other type of commercial service.