2006 CHRYSLER SEBRING CONVERTIBLE radiator

Please note that it is the owner’s responsibility to main-
tain the proper level of protection against freezing ac-
cording to the temperatures occurring in the area where
the vehicle is operated.
NOTE:Mixing coolant types will decrease the life of the
engine coolant and will require more frequent coolant
changes.
Cooling System Pressure Cap
The cap must be fully tightened to prevent loss of
coolant, and to insure that coolant will return to the
radiator from the coolant recovery bottle.
The cap should be inspected and cleaned if there is any
accumulation of foreign material on the sealing surfaces.
WARNING!
•The warning words “DO NOT OPEN HOT” on
the cooling system pressure cap are a safety pre-
caution. Never add coolant when the engine is
overheated. Do not loosen or remove the cap to
cool an overheated engine. Heat causes pressure
to build up in the cooling system. To prevent
scalding or injury, do not remove the pressure cap
while the system is hot or under pressure.
•Do not use a pressure cap other than the one
specified for your vehicle. Personal injury or
engine damage may result.
Disposal of Used Engine Coolant
Used ethylene glycol based engine coolant is a regulated
substance requiring proper disposal. Check with your
local authorities to determine the disposal rules for your
community. To prevent ingestion by animals or children
do not store ethylene glycol based engine coolant in open
containers or allow it to remain in puddles on the
234 MAINTAINING YOUR VEHICLE

ground. If ingested by a child, contact a physician
immediately. Clean up any ground spills immediately.
Coolant Level
The coolant bottle provides a quick visual method for
determining that the coolant level is adequate. With the
engine off and cold, the level of the coolant in the bottle
should be between the ranges indicated on the bottle.
The radiator normally remains completely full, so there is
no need to remove the radiator cap unless checking for
coolant freeze point or replacing coolant. Advise your
service attendant of this. As long as the engine operating
temperature is satisfactory, the coolant bottle need only
be checked once a month. Heater performance may also
be adversely affected by low coolant levels.
When additional coolant is needed to maintain the
proper level, it should be added to the coolant bottle. Do
not overfill. Special procedures are required when filling
the engine cooling system of the 2.7L Engine. See your
authorized dealer for details.
Points To Remember
NOTE:
When the vehicle is stopped after a few miles (a
few kilometers) of operation, you may observe vapor
coming from the front of the engine compartment. This is
normally a result of moisture from rain, snow, or high
humidity accumulating on the radiator and being vapor-
ized when the thermostat opens, allowing hot coolant to
enter the radiator.
If an examination of your engine compartment shows no
evidence of radiator or hose leaks, the vehicle may be
safely driven. The vapor will soon dissipate.
•Do not overfill the coolant recovery bottle.
•Check coolant freeze point in the radiator and in the
coolant recovery bottle. If antifreeze needs to be
added, contents of coolant recovery bottle must also be
protected against freezing.
•If frequent coolant additions are required, or if the
level in the coolant recovery bottle does not drop when
the engine cools, the cooling system should be pres-
sure tested for leaks.
MAINTAINING YOUR VEHICLE 235
7

•Maintain coolant concentration at 50% HOAT engine
coolant (minimum) and distilled water for proper
corrosion protection of your engine which contains
aluminum components.
•Make sure that the radiator and coolant recovery
bottle overflow hoses are not kinked or obstructed.
•Keep the front of the radiator clean. If your vehicle is
equipped with air conditioning, keep the front of the
condenser clean, also.
•Do not change the thermostat for summer or winter
operation. If replacement is ever necessary, install
ONLY the correct type thermostat. Other designs may
result in unsatisfactory coolant performance, poor gas
mileage, and increased emissions.
Hoses and Vacuum/Vapor Harnesses
Inspect surfaces of hoses and nylon tubing for evidence
of heat and mechanical damage. Hard or soft spots,
brittle rubber, cracking, checking, tears, cuts, abrasions,
and excessive swelling indicate deterioration of the rub-
ber.Pay particular attention to those hoses nearest to high
heat sources such as the exhaust manifold. Inspect hose
routing to be sure hoses do not touch any heat source or
moving component that may cause heat damage or
mechanical wear.
Insure nylon tubing in these areas has not melted or
collapsed. Inspect all hose connections such as clamps
and couplings to make sure they are secure and no leaks
are present. Components should be replaced immedi-
ately if there is any evidence of degradation that could
cause failure.
Brakes
In order to assure brake system performance, all brake
system components should be inspected periodically.
Suggested service intervals can be found in section 8.
236 MAINTAINING YOUR VEHICLE

•Check all lights and all other electrical items for correct
operation.
•Check rubber seals on each side of the radiator for
proper fit.
At Each Oil Change
•
Change the engine oil filter.
•Inspect the exhaust system.
•Inspect the brake linings, hoses and calipers.
•Inspect the CV joints and front and rear suspension
components.
•Check the automatic transmission fluid level.
•Check the brake master cylinder fluid level.
•Check the coolant level, hoses, and clamps.
NOTE:In 2.7L Engines equipped with Flex Fuel Engine
(FFV), change engine oil every 5 months or 5,000 miles,
whichever comes first. This applies to both Maintenance
Schedule A and B.
264 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Autostick............................. 176
Auxiliary Power Outlet................... 79
Ball Joints............................ 228
Battery............................... 225
Emergency Starting.................... 204
Gas Caution......................206,225
Heater............................. 148
Jump Starting........................ 204
Keyless Transmitter Replacement (RKE)..... 18
Location.........................204,225
Belts, Drive........................... 222
Belts, Engine.......................... 224
Body Mechanism Lubrication.............. 228
Boot, Convertible Top.................... 50
B-Pillar Location....................... 163
Brake, Parking......................... 153
Brake System.......................155,236
Anti-Lock (ABS)...................... 155
Fluid Check......................... 238
Hoses.............................. 237
Master Cylinder...................... 238
Warning Light........................ 93Brake/Transmission Interlock...........149,151
Break-In Recommendations, New Vehicle...... 42
Bulb Replacement...................... 251
Bulbs, Light........................... 251
Capacities, Antifreeze (Engine Coolant)...... 257
Capacities, Fluid....................... 257
Capacity, Cargo Weight.................. 185
Caps, Filler
Fuel............................... 183
Oil (Engine)......................... 221
Radiator (Coolant Pressure).............. 234
Car Washes........................... 242
Carbon Monoxide Warning............... 180
Carpeting............................. 243
Cassette Tape and Player Maintenance....... 128
Cassette Tape Player...............100,109,112
Catalytic Converter..................... 223
CD (Compact Disc) Changer......108,113,118,120
CD (Compact Disc) Player.......105,114,116,127
Center High Mounted Stop Light........... 255
Central Locking......................... 14
Chains, Tire........................... 175
INDEX 289
10

Changing A Flat Tire.................... 199
Charging System Light................... 90
Chart, Tire Sizing....................... 160
Check Engine Light
(Malfunction Indicator Light).............. 216
Checking Your Vehicle For Safety............ 43
Child Restraint...................34,36,39,40
Child Restraint Tether Anchors............. 39
Cigar Lighter........................... 99
Circuit Breakers........................ 248
Clean Air Gasoline...................... 178
Cleaning
Glass.............................. 245
Headlights.......................... 244
Instrument Panel..................... 245
WoodTrim .......................... 245
Climate Control........................ 129
Clock................................. 99
Coin Holder........................... 55
Compact Disc (CD) Changer.............. 120
Compact Disc (CD) Maintenance........... 128
Compact Disc (CD) Player.............100,105
Compact Spare Tire..................... 170Compass.............................. 95
Compass Calibration..................... 96
Console............................... 55
Console, Floor.......................... 55
Contract, Service....................... 282
Convertible............................ 47
Convertible Boot........................ 50
Convertible Top......................... 47
Convertible Top Maintenance.............. 246
Coolant Pressure Cap.................... 234
Cooling System........................ 232
Adding Coolant (Antifreeze)............. 233
Coolant Capacity..................... 257
Coolant Level.....................232,235
Disposal of Used Coolant............... 234
Drain, Flush, and Refill................. 232
Inspection........................... 232
Points to Remember................... 235
Pressure Cap........................ 234
Radiator Cap........................ 234
Rubber and Plastic Components.......... 236
Selection of Coolant (Antifreeze)....233,257,258
Corrosion Protection.................... 241
290 INDEX

Onboard Diagnostic System............215,216
Opener, Garage Door (HomeLink) .......... 75
Operator Manual (Owner’s Manual).......... 4
Overdrive............................ 152
Overheating, Engine..................... 198
Owner’s Manual (Operator Manual).......4,283
Paint Care............................ 241
Paint Damage......................... 241
Panic Alarm........................... 17
Parking Brake......................... 153
Parking On Hill........................ 154
Passing Light........................... 69
Pets.................................. 42
Pets, Transporting....................... 42
Placard, Tire and Loading Information....... 163
Power
Brakes............................. 155
Distribution Center.................... 248
Door Locks.......................... 12
Outlet (Auxiliary Electrical Outlet)......... 79
Seats............................... 60
Steering............................ 157Steering, Checking.................... 227
Windows............................ 21
Power Steering Fluid.................... 259
Pregnant Women and Seat Belts............. 28
Preparation for Jacking................... 200
Pretensioners
Seat Belts............................ 26
Programmable Electronic Features.........75,79
Programming Transmitters
(Remote Keyless Entry)...............17,75,79
Radial Ply Tires........................ 170
Radiator Cap (Coolant Pressure Cap)........ 234
Radio Broadcast Signals................... 99
Radio Operation...............109,115,127,129
Radio Remote Controls.................. 126
Radio, Satellite......................... 123
Radio (Sound Systems).............100,109,114
Rear Window Defroster.................. 139
Rearview Mirrors........................ 56
Reformulated Gasoline................... 178
Refrigerant............................ 227
Reminder, Lights On..................... 68
INDEX 297
10