2006 CHRYSLER 300 SRT radiator

ground. If ingested by a child, contact a physician
immediately. Clean up any ground spills immediately.
Coolant Level
The coolant bottle provides a quick visual method for
determining that the coolant level is adequate. With the
engine off and cold, the level of the coolant in the bottle
should be between the ranges indicated on the bottle.
The radiator normally remains completely full, so there is
no need to remove the radiator cap unless checking for
coolant freeze point or replacing coolant. Advise your
service attendant of this. As long as the engine operating
temperature is satisfactory, the coolant bottle need only
be checked once a month.
When additional coolant is needed to maintain the
proper level, it should be added to the coolant bottle. Do
not overfill.
Points To Remember
NOTE:
When the vehicle is stopped after a few miles (a
few kilometers) of operation, you may observe vapor
coming from the front of the engine compartment. This is
normally a result of moisture from rain, snow, or highhumidity accumulating on the radiator and being vapor-
ized when the thermostat opens, allowing hot coolant to
enter the radiator.
If an examination of your engine compartment shows no
evidence of radiator or hose leaks, the vehicle may be
safely driven. The vapor will soon dissipate.
•Do not overfill the coolant recovery bottle.
•Check coolant freeze point in the radiator and in the
coolant recovery bottle. If antifreeze needs to be
added, contents of coolant recovery bottle must also be
protected against freezing.
•If frequent coolant additions are required, or if the
level in the coolant recovery bottle does not drop when
the engine cools, the cooling system should be pres-
sure tested for leaks.
•Maintain coolant concentration at 50% HOAT engine
coolant (minimum) and distilled water for proper
corrosion protection of your engine which contains
aluminum components.
MAINTAINING YOUR VEHICLE 261
7

•Make sure that the radiator and coolant recovery
bottle overflow hoses are not kinked or obstructed.
•Keep the front of the radiator clean. If your vehicle is
equipped with air conditioning, keep the front of the
condenser clean, also.
•Do not change the thermostat for summer or winter
operation. If replacement is ever necessary, install
ONLY the correct type thermostat. Other designs may
result in unsatisfactory coolant performance, poor gas
mileage, and increased emissions.
Hoses And Vacuum/Vapor Harnesses
Inspect surfaces of hoses and nylon tubing for evidence
of heat and mechanical damage. Hard or soft spots,
brittle rubber, cracking, tears, cuts, abrasions, and exces-
sive swelling indicate deterioration of the rubber.
Pay particular attention to those hoses nearest to high
heat sources such as the exhaust manifold. Inspect hose
routing to be sure hoses do not come in contact with any
heat source or moving component which may cause heat
damage or mechanical wear.Insure nylon tubing in these areas has not melted or
collapsed.
Inspect all hose connections such as clamps and cou-
plings to make sure they are secure and no leaks are
present.
Components should be replaced immediately if there is
any evidence of wear or damage that could cause failure.
Brakes
In order to assure brake system performance, all brake
system components should be inspected periodically.
Suggested service intervals can be found in the Mainte-
nance Schedules section of this manual.
262 MAINTAINING YOUR VEHICLE

Front Power Distribution Center Fuses
Cavity Fuse Circuits
1 20 Amp Yellow Left High Beam Headlight
2 20 Amp Yellow Right High Beam Head-
light
3— —
4 20 Amp Yellow Horn
5 25 Amp Clear Headlamp Washer
6 15 Amp Dk. Blue Front Control Module
(FCM)
7 20 Amp Yellow Fog Lamp
8 15 Amp Dk. Blue Park Lamp
9 15 Amp Dk. Blue Non ABS Brakes
10 5 Amp Orange Starter
11 20 Amp Yellow Auto Shutdown/
Powertrain Control Mod-
ule (PCM)
12 — —
13 — —
Cavity Fuse Circuits
14 25 Amp Clear Powertrain Control Mod-
ule
15 20 Amp Yellow Injectors, Ignition Coils
16 15 Amp Dk. Blue Powertrain Control Mod-
ule
17 30 Amp Pink Antilock Brake System
(ABS) Valves
18 30 Amp Pink Windshield Wiper/Washer
19 50 Amp Red Radiator Fan
20 20 Amp Lt. Blue Starter
21 50 Amp Red ABS Pump Motor
22 40 Amp Green Radiator Fan High/Low
23 50 Amp Red High Intensity Lighting
24 60 Amp Yellow Radiator Fan
25 30 Amp Pink Lighting Left High Beam/
Right Low Beam
26 — —
27 30 Amp Pink Lighting Left Low Beam/
Right High Beam
MAINTAINING YOUR VEHICLE 271
7

Once a Month
•
Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir and brake
master cylinder, and add as needed.
•Check all lights and all other electrical items for correct
operation.
•Check rubber seals on each side of the radiator for
proper fit.
At Each Oil Change
•
Change the engine oil filter.
•Inspect the exhaust system.
•Inspect the brake hoses.
•Inspect the CV joints and front and rear suspension
components.
•Check the coolant level, hoses, and clamps.
286 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Bearings.............................. 266
Belts, Drive........................... 250
Body Mechanism Lubrication.............. 256
B-Pillar Location....................... 204
Brake Assist System..................... 108
Brake, Parking......................... 194
Brake System.......................195,262
Anti-Lock........................... 195
Fluid Check......................264,282
Hoses.............................. 263
Warning Light....................... 136
Brake/Transmission Interlock.............. 192
Break-In Recommendations, New Vehicle...... 56
Bulb Replacement...................... 276
Bulbs, Light........................... 275
Calibration, Compass.................... 144
Capacities, Fluid....................... 281
Caps, Filler
Fuel............................... 224
Radiator (Coolant Pressure).............. 260
Car Washes........................... 267
Carbon Monoxide Warning.............56,223Cargo Tie-Downs....................... 126
Cassette Tape and Player Maintenance....... 171
Catalytic Converter..................... 251
CD Player............................ 152
Cellular Phone.......................... 66
Chains, Tire........................... 217
Chart, Tire Sizing....................... 201
Child Restraint...................48,50,52,54
Child Restraint Tether Anchors............. 52
Child Safety Locks....................... 17
Clean Air Gasoline...................... 221
Climate Control........................ 173
Clock.............................151,153
Compact Disc Maintenance............... 172
Compass............................. 143
Compass Calibration.................... 144
Compass Variance...................... 144
Computer, Trip/Travel................... 142
Console.............................. 126
Console, Floor......................... 126
Console, Overhead...................... 113
Contract, Service....................... 302
Coolant Pressure Cap.................... 260
INDEX 309
10

Cooling System........................ 258
Adding Coolant (Antifreeze)............. 259
Coolant Capacity..................... 281
Coolant Level.....................258,261
Disposal of Used Coolant............... 260
Drain, Flush, and Refill................. 258
Inspection........................... 261
Points to Remember................... 261
Pressure Cap........................ 260
Radiator Cap........................ 260
Selection of Coolant (Antifreeze)....259,281,282
Cruise Control (Speed Control)............. 111
Cup Holder........................125,270
Customer Assistance.................... 300
Data Recorder, Event..................... 47
Dealer Service......................... 246
Defroster, Windshield..................57,177
Delay (Intermittent) Wipers............... 103
Diagnostic System, Onboard............... 244
Dimmer Switch, Headlight................ 101
Disposal
Antifreeze (Engine Coolant)............. 260Door Locks............................ 15
Door Locks, Automatic................... 17
Door Opener, Garage.................... 114
Drive Belts............................ 250
Driver’s Seat Glide Feature................ 92
Driving
On Slippery Surfaces.................. 237
DVD Player (Video Entertainment System).... 163
Electric Remote Mirrors................... 64
Electrical Power Outlets.................. 122
Electronic Speed Control.................. 111
Electronic Stability Program............... 109
Electronic Vehicle Information Center........ 140
Emergency, In Case of
Freeing Vehicle When Stuck............. 238
Hazard Warning Flasher................ 230
Jump Starting........................ 235
Overheating......................... 230
Towing............................. 239
Emission Control System Maintenance....245,284
Engine............................... 243
Air Cleaner.......................... 251
310 INDEX

Steering............................ 198
Steering, Checking.................... 255
Sunroof............................ 120
Tilt/Telescoping Steering Column......... 106
Windows............................ 23
Pregnant Women and Seat Belts............. 33
Pretensioners
Seat Belts............................ 32
Programmable Electronic Features..... 115,119,147
Programming Transmitters............. 115,119
Radial Ply Tires........................ 211
Radiator Cap (Coolant Pressure Cap)........ 260
Radio Broadcast Signals.................. 170
Radio Operation.....................152,172
Radio Remote Controls.................. 168
Radio, Satellite......................... 165
Radio (Sound Systems)................... 152
Rain Sensitive Wiper System.............. 102
Rear Park Assist System................... 85
Rear Seat, Folding....................... 93
Reclining Front Seats..................... 88
Recorder, Event Data..................... 47Recreational Towing..................... 228
Refrigerant............................ 255
Reminder, Seat Belt...................... 32
Remote Keyless Entry.................... 18
Remote Sound System Controls............ 168
Remote Trunk Release.................... 25
Replacement Tires...................... 213
Reporting Safety Defects................. 303
Restraint, Head......................... 93
Restraints, Occupant..................... 27
Rocking Vehicle When Stuck.............. 238
Rotation, Tires......................... 218
Safety Checks Inside Vehicle............... 57
Safety Checks Outside Vehicle.............. 58
Safety Defects, Reporting................. 303
Safety Information, Tire.................. 199
Safety Tips............................. 56
Satellite Radio......................... 165
Satellite Radio Antenna.................. 167
Schedule, Maintenance................... 284
Seat Belt Maintenance................... 269
Seat Belt Reminder...................... 32
316 INDEX