2006 CHRYSLER 300 towing

All Wheel Drive (AWD)—If Equipped
The all wheel drive system consists of a Transfer Case,
and Front Differential. The exterior surface of these
components should be inspected for evidence of fluid
leaks. Confirmed leaks should be repaired as soon as
possible.
The transfer case fill plug is located on the rear housing
near the output shaft. The level can be verified by the
service plug in the middle of the rear housing, even with
the bottom of the hole. The front differential fill plug is on
the outer cover near the halfshaft attachment. The level
can be verified by removing the plug and inspecting the
level. The level should be even with or slightly below the
bottom of the hole.
Fluid Changes
The fluid should be changed as follows:
Normal UsageNo Service Required
Severe Usage
Front Differential No Service Required
Transfer Case Refer to Maintenance
Schedule“B”Severe Usage is defined as:
1. More than 50% of vehicle operation in stop and go
traffic where vehicle is driven regularly for more than 45
minutes of continuous operation, such as in heavy city or
in construction zone traffic.
2. Police, taxi, limousine, commercial type operation, or
trailer towing where the vehicle driven regularly for
more than 45 minutes of continuous operation.
Front And Rear Wheel Bearings
Front and rear wheel bearings are permanently sealed.
No regular maintenance is required for these compo-
nents.
Appearance Care and Protection from Corrosion
Protection of Body and Paint from Corrosion
Vehicle body care requirements vary according to geo-
graphic locations and usage. Chemicals that make roads
passable in snow and ice, and those that are sprayed on
trees and road surfaces during other seasons, are highly
corrosive to the metal in your vehicle. Outside parking,
which exposes your vehicle to airborne contaminants,
road surfaces on which the vehicle is operated, extreme
MAINTAINING YOUR VEHICLE 321
7

•Extensive engine idling.
•Driving in dusty conditions.
•Short trips of less than 10 miles (16.2 km).
•More than 50% of your driving is at sustained high
speeds during hot weather, above 90°F (32°C).
•Trailer towing.
•Taxi, police, or delivery service (commercial ser-
vice).
•Off-road or desert operation.
NOTE:IfANYof these apply to you, then change your
engine oil every 3,000 miles (5 000 km) or 3 months,
whichever comes first, and follow the maintenance rec-
ommendations in Schedule“B”in this section.
NOTE:IfANYof these apply to you, then flush and
replace the engine coolant every 102,000 miles (170 000
km) or 60 months, whichever comes first, and follow the
maintenance recommendations in Schedule“B”in this
section.
NOTE:Most vehicles are operated under the conditions
listed for ScheduleB.
Second is Schedule“A.”It is for vehicles that are not
operated under any of the conditions listed under Sched-
uleB.
Use the schedule that best describes your driving condi-
tions. Where time and mileage are listed, follow the
interval that occurs first.
NOTE:Under no circumstances should oil change
intervals exceed 6,000 miles (10 000 km) or 6 months
whichever comes first.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
MAINTENANCE SCHEDULES 351
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

SCHEDULE“B”
Follow Schedule“B”if you usually operate your vehicle
under one or more of the following conditions. Change
the automatic transmission fluid and filter every 60,000
miles (100 000 km) if the vehicle is usually operated
under one or more of the conditions marked with an.
•Day or night temperatures are below 32°F(0°C).
•Stop and go driving.
•Extensive engine idling.
•Driving in dusty conditions.
•Short trips of less than 10 miles (16.2 km).
•More than 50% of your driving is at sustained high
speeds during hot weather, above 90°F (32°C).
•Trailer towing.
•Taxi, police or delivery service (commercial ser-
vices).
•Off-road or desert operation.
•If equipped for and operating with E-85 (ethanol)
fuel.
NOTE:IfANYof these apply to you, then change your
engine oil every 3,000 miles (5 000 km) or 3 months,
whichever comes first, and follow the maintenance rec-
ommendations in Schedule“B”in this section.
NOTE:IfANYof these apply to you, then flush and
replace the engine coolant every 102,000 miles (170 000
km) or 60 months, whichever comes first, and follow the
maintenance recommendations in Schedule“B”in this
section.
SCHEDULE“B”353
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Hazard Warning Flasher................ 274
Jacking............................. 275
Jump Starting........................ 282
Overheating......................... 274
Towing............................. 286
Emission Control System Maintenance....296,350
Engine.........................292,293,294
Air Cleaner.......................... 304
Air Cleaner Filter..................... 304
Block Heater......................... 210
Break-In Recommendations............... 60
Checking Oil Level.................298,299
Compartment..................292,293,294
Coolant (Antifreeze)................312,346
Cooling............................ 312
Exhaust Gas Caution................60,256
Fails to Start......................... 209
Fuel Requirements.................253,344
Oil ..........................298,344,346
Oil Change Interval................... 300
Oil Selection......................300,344
Oil Synthetic......................... 302
Overheating......................... 274Temperature Gauge................... 146
Enhanced Accident Response Feature......... 50
Event Data Recorder..................... 51
Exhaust Gas Caution...............60,256,311
Exhaust System........................ 311
Exterior Folding Mirrors.................. 68
Filters
Air Cleaner.......................... 304
Air Conditioning..................202,308
Engine Fuel......................... 304
Engine Oil.......................303,346
Engine Oil Disposal................... 302
Flashers
Hazard Warning...................... 274
Turn Signal.......................... 143
Flash-To-Pass.......................... 106
Flat Tire Changing...................... 275
Floor Console.......................... 135
Fluid Capacities........................ 344
Fluid Leaks............................ 61
Fluid Level Checks
Brake.............................. 318
INDEX 377
10

On With Wipers...................103,108
Passing............................. 106
Switch..........................102,103
Time Delay.......................... 105
Washers......................... 110,310
Heated Seats........................... 92
Heater, Engine Block.................... 210
High Beam/Low Beam Select (Dimmer)
Switch............................... 106
Hitches
Trailer Towing....................... 264
Holder, Cup........................... 133
HomeLink(Garage Door Opener)
Transmitter........................... 123
Hood Release.......................... 99
Horn................................. 12
Hoses............................316,319
Ignition
Key ................................ 11
Illuminated Entry....................... 15
Immobilizer (Sentry Key).................. 12
Infant Restraint......................... 53Information Center, Vehicle............... 150
Instrument Cluster................141,142,143
Instrument Panel and Controls............. 140
Instrument Panel Lens Cleaning............ 324
Interior Appearance Care................. 323
Interior Fuses.......................... 326
Interior Lights......................... 101
Intermittent Wipers (Delay Wipers)......... 109
Introduction............................ 4
Jack Location.......................... 277
Jack Operation......................... 278
Jacking Instructions..................... 278
Jump Starting......................... 282
Key, Programming....................... 14
Key, Replacement....................... 13
Key, Sentry (Immobilizer).................. 12
Key-In Reminder........................ 12
Keyless Entry System..................... 20
Keys................................. 11
Knee Bolster........................... 39
INDEX 379
10

Radio (Sound Systems)................164,171
Rain Sensitive Wiper System.............. 107
Rear Park Assist System.................. 114
Rear Seat, Folding....................... 94
Rear Window Defroster.................. 193
Rearview Mirrors........................ 67
Reclining Front Seats..................... 91
Recorder, Event Data..................... 51
Recreational Towing..................... 272
Refrigerant............................ 308
Reminder, Seat Belt...................... 37
Remote Keyless Entry (RKE)............... 20
Remote Sound System (Radio) Controls...... 189
Remote Trunk Release.................... 29
Replacement Tires...................... 249
Reporting Safety Defects................. 369
Restraint, Head......................... 94
Restraints, Occupant..................... 31
Rocking Vehicle When Stuck.............. 285
Rotation, Tires......................... 252
Safety Checks Inside Vehicle............... 61
Safety Checks Outside Vehicle.............. 61Safety Defects, Reporting................. 369
Safety Information, Tire.................. 234
Safety Tips............................. 60
Satellite Radio......................... 183
Satellite Radio Antenna.................. 185
Schedule, Maintenance................... 350
Seat Belt Maintenance................... 325
Seat Belt Reminder...................... 37
Seat Belts.............................. 32
Adjustable Upper Shoulder Anchorage...... 36
And Pregnant Women.................. 38
Child Restraint....................52,53,58
Extender............................ 38
Front Seat............................ 33
Operating Instructions.................. 33
Pretensioners......................... 36
Reminder........................... 147
Seats................................. 90
Easy Entry........................... 97
Heated.............................. 92
Lumbar Support....................... 92
Memory............................. 95
Power.............................. 90
INDEX 383
10

Temperature Gauge, Engine Coolant......146,275
Theft Alarm (Security Alarm)............... 25
Theft System (Security Alarm).............. 25
Tie Down Hooks, Cargo.................. 135
Tilt Steering Column.................. 111,112
Tire and Loading Information Placard....... 239
Tire Identification Number (TIN)........... 238
Tire Markings......................... 234
Tire Safety Information................... 234
Tires ...........................61,243,371
Aging (Life of Tires)................... 249
Air Pressure......................... 243
Alignment.......................... 250
Chains............................. 251
Changing........................275,278
Compact Spare....................... 246
Flat Changing........................ 275
General Information................... 243
High Speed......................... 245
Inflation Pressures.................... 244
Jacking..........................276,278
Life of Tires......................... 249
Load Capacity....................239,240Pressure Monitor System (TPMS)......... 230
Quality Grading...................... 371
Radial............................. 246
Replacement......................... 249
Rotation............................ 252
Safety...........................234,243
Self-Sealing.......................... 229
Sizes............................... 236
Snow Tires.......................... 252
Spare Tire........................... 277
Spinning............................ 247
Tread Wear Indicators.................. 248
Tongue Weight/Trailer Weight............. 266
Torque Converter Clutch................. 214
Towing.............................. 262
Behind a Motor Home................. 272
Disabled Vehicle...................... 286
Guide.............................. 264
Recreational......................... 272
Weight............................. 264
Towing Vehicle Behind a Motor Home....... 272
Traction Control........................ 113
Traction Control Switch.................. 113
INDEX 385
10

Trailer Towing......................... 262
Cooling System Tips................... 272
Hitches............................. 264
Minimum Requirements................ 267
Trailer and Tongue Weight.............. 266
Wiring............................. 269
Trailer Towing Guide.................... 264
Trailer Weight......................... 264
Transmission.......................... 320
Automatic.....................210,215,320
Fluid.............................. 347
Shifting............................ 210
Transmitter Battery Service
(Remote Keyless Entry)................... 24
Transmitter, Garage Door Opener
(HomeLink) .......................... 123
Transmitter, Remote Keyless Entry (RKE)...... 20
Transporting Pets........................ 59
Tread Wear Indicators................... 248
Trip Odometer Reset Button............... 147
Trunk Release, Emergency................. 31
Trunk Release Remote Control.............. 29
Turn Signals........................105,143Uniform Tire Quality Grades.............. 371
Universal Transmitter.................... 123
Unleaded Gasoline...................... 253
Vanity Mirrors.......................... 70
Variance, Compass...................... 155
Vehicle Certification Label................ 260
Vehicle Identification Number (VIN).......... 6
Vehicle Loading..................240,260,261
Vehicle Modifications/Alterations............ 7
Vehicle Storage......................202,332
Vehicle Theft Alarm (Security Alarm)......... 25
Video Entertainment System
(Rear Seat Video System)................. 186
Warning Flasher, Hazard................. 274
Warnings and Cautions.................... 6
Warranty Information.................... 368
Washer, Adding Fluid..............109,110,310
Washers, Headlight..................... 110
Washers, Windshield.................... 107
Washing Vehicle........................ 322
Wheel Alignment and Balance............. 250
386 INDEX