2006 CHEVROLET OPTRA 5 Power steering

Part C: Periodic Maintenance
Inspections
Listed in this part are inspections and services which
should be performed at least twice a year (for instance,
each spring and fall).You should let your dealer’s
service department do these jobs. Make sure any
necessary repairs are completed at once.
Proper procedures to perform these services may be
found in a service manual. SeeService Publications
Ordering Information on page 7-15.
Steering, Suspension and Front
Drive Axle Boot and Seal Inspection
Inspect the front and rear suspension and steering
system for damaged, loose or missing parts, signs of
wear or lack of lubrication. Inspect the power steering
lines and hoses for proper hook-up, binding, leaks,
cracks, chafing, etc. Clean and then inspect the drive
axle boot seals for damage, tears or leakage. Replace
seals if necessary.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body
near the exhaust system. Look for broken, damaged,
missing or out-of-position parts as well as open seams,
holes, loose connections or other conditions which
could cause a heat build-up in the floor pan or could let
exhaust fumes into the vehicle. SeeEngine Exhaust
on page 2-30.
Fuel System Inspection
Inspect the complete fuel system for damage or leaks.
6-22

Part D: Recommended Fluids and
Lubricants
Fluids and lubricants identified below by name, part
number, or specification may be obtained from
your dealer.
Usage Fluid/Lubricant
Engine OilEngine oil which meets GM
Standard GM6094M and displays
the American Petroleum Institute
Certified for Gasoline Engines
starburst symbol. GM Goodwrench
®
oil meets all the requirements for
your vehicle. To determine the
proper viscosity for your vehicle’s
engine, seeEngine Oil on
page 5-13.
Engine Coolant50/50 mixture of clean, drinkable
water (preferably distilled) and good
quality Ethylene Glycol Base
Coolant (GM Part No. U.S.
12378560, in Canada 993089) and
conforming to GM Specification
1825M or recycled coolant
conforming to GM Specification
1825M. SeeEngine Coolant on
page 5-20.
Usage Fluid/Lubricant
Hydraulic Brake
SystemDelco
®Supreme 11 Brake Fluid or
equivalent DOT-3 brake fluid.
Windshield
Washer SolventGM Optikleen
®Washer Solvent.
Power Steering
SystemDEXRON
®-III Automatic
Transmission Fluid. Look for
“Approved for the H-Specification”
on the label.
Automatic
TransaxleAutomatic Transaxle Fluid ESSO LT
71141 or TOTAL ATF H50235 (GM
Part No. in Canada 89021903).
Manual
TransaxleGM Goodwrench
®Synthetic Manual
Transmission Fluid (GM Part
No. U.S. 12346190, in
Canada 10953477) or equivalent
SAE 75W-85 GL-4 gear oil.
Key Lock
CylindersMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241, in
Canada 10953474).
Manual
Transaxle Shift
LinkageChassis Lubricant (GM Part
No. U.S. 12377985, in
Canada 88901242) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
6-24

A
Accessories and Modifications............................ 5-3
Accessory Power Outlet(s)...............................3-19
Adding Equipment to Your Airbag-Equipped
Vehicle.......................................................1-64
Additives, Fuel................................................. 5-6
Add-On Electrical Equipment............................5-81
Air Cleaner/Filter, Engine.................................5-17
Air Conditioning..............................................3-22
Airbag
Passenger Status Indicator...........................3-31
Readiness Light..........................................3-30
Airbag Sensing and Diagnostic Module (SDM)...... 7-9
Airbag System................................................1-52
Adding Equipment to Your Airbag-Equipped
Vehicle...................................................1-64
How Does an Airbag Restrain?......................1-58
Passenger Sensing System...........................1-60
Servicing Your Airbag-Equipped Vehicle..........1-64
What Makes an Airbag Inflate?......................1-58
What Will You See After an Airbag Inflates?....1-58
When Should an Airbag Inflate?....................1-57
Where Are the Airbags?...............................1-55
Antenna, Integrated Windshield.........................3-75
Anti-Lock Brake System (ABS)........................... 4-7
Anti-Lock Brake, System Warning Light..............3-35Appearance Care
Aluminum Wheels........................................5-78
Chemical Paint Spotting...............................5-80
Cleaning Exterior Lamps/Lenses....................5-77
Cleaning the Inside of Your Vehicle................5-74
Fabric/Carpet..............................................5-75
Finish Care.................................................5-77
Finish Damage............................................5-79
Instrument Panel, Vinyl, and Other Plastic
Surfaces.................................................5-76
Leather......................................................5-76
Sheet Metal Damage...................................5-79
Tires..........................................................5-79
Underbody Maintenance...............................5-79
Vehicle Care/Appearance Materials................5-80
Washing Your Vehicle...................................5-77
Weatherstrips..............................................5-76
Windshield and Wiper Blades........................5-78
Ashtray(s)......................................................3-20
Audio System(s).............................................3-44
Audio Steering Wheel Controls......................3-73
Care of Your CD Player...............................3-75
Care of Your CDs ........................................3-75
Integrated Windshield Antenna.......................3-75
Radio with CD............................3-45, 3-49, 3-57
Radio with Six-Disc CD................................3-65
Understanding Radio Reception.....................3-74
1

Electrical System (cont.)
Instrument Panel Fuse Block.........................5-83
Power Windows and Other Power Options......5-82
Windshield Wiper Fuses...............................5-82
Engine
Air Cleaner/Filter.........................................5-17
Battery.......................................................5-34
Check and Service Engine Soon Light............3-37
Coolant......................................................5-20
Coolant Heater............................................2-19
Coolant Temperature Gage...........................3-36
Cooling System Inspection............................6-23
Engine Compartment Overview......................5-12
Exhaust.....................................................2-30
Oil .............................................................5-13
Overheating................................................5-23
Starting......................................................2-17
Event Data Recorders (EDR)............................. 7-9
Extender, Safety Belt.......................................1-27
Exterior Lamps...............................................3-16
F
Filter
Engine Air Cleaner......................................5-17
Finish Damage...............................................5-79
Flash-to-Pass.................................................3-10Flat Tire........................................................5-63
Flat Tire, Changing.........................................5-64
Flat Tire, Storing.............................................5-73
Fluid
Automatic Transaxle.....................................5-19
Manual Transaxle........................................5-19
Power Steering...........................................5-29
Windshield Washer......................................5-30
Fog Lamp Light..............................................3-41
Fog Lamps ....................................................3-17
Front Armrest Storage Area..............................2-35
Front Storage Area.........................................2-35
Fuel............................................................... 5-4
Additives...................................................... 5-6
California Fuel.............................................. 5-5
Filling a Portable Fuel Container..................... 5-9
Filling Your Tank........................................... 5-7
Fuels in Foreign Countries.............................. 5-6
Gage .........................................................3-42
Gasoline Octane........................................... 5-5
Gasoline Specifications.................................. 5-5
Low Warning Light.......................................3-43
System Inspection.......................................6-22
Fuses
Engine Compartment Fuse Block...................5-85
Fuses and Circuit Breakers...........................5-82
Instrument Panel Fuse Block.........................5-83
Windshield Wiper.........................................5-82
5

Light (cont.)
Malfunction Indicator....................................3-37
Oil Pressure...............................................3-39
Passenger Airbag Status Indicator..................3-31
Safety Belt Reminder...................................3-30
Safety Belt Reminder Tone...........................3-30
Speed Sensitive Power Steering (SSPS)
Warning Light..........................................3-35
TCS Warning Light......................................3-36
Traction Control System (TCS) Warning..........3-36
Trunk Ajar..................................................3-42
Loading Your Vehicle.......................................4-28
Lockout Protection..........................................2-10
Locks
Central Door Unlocking System....................... 2-8
Door ........................................................... 2-7
Lockout Protection.......................................2-10
Power Door .................................................. 2-8
Rear Door Security Locks............................... 2-9
Long Trip/Highway Scheduled Maintenance........6-13
Loss of Control...............................................4-13
Low Fuel Warning Light...................................3-43
Lumbar
Manual Controls............................................ 1-4M
Maintenance, Normal Replacement Parts............5-89
Maintenance Schedule
At Each Fuel Fill.........................................6-18
At Least Once a Month................................6-18
At Least Once a Year..................................6-19
At Least Twice a Year..................................6-18
Brake System Inspection..............................6-23
Engine Cooling System Inspection.................6-23
Exhaust System Inspection...........................6-22
Fuel System Inspection................................6-22
How This Section is Organized....................... 6-3
Introduction.................................................. 6-2
Long Trip/Highway Scheduled Maintenance.....6-13
Maintenance Requirements............................. 6-2
Part A - Scheduled Maintenance Services......... 6-4
Part B - Owner Checks and Services.............6-18
Part C - Periodic Maintenance Inspections......6-22
PartD-Recommended Fluids and
Lubricants...............................................6-24
PartE-Maintenance Record........................6-26
Selecting the Right Schedule.......................... 6-5
Short Trip/City Scheduled Maintenance............. 6-6
8

Maintenance Schedule (cont.)
Steering, Suspension and Front Drive
Axle Boot and Seal Inspection...................6-22
Throttle System Inspection............................6-23
Using.......................................................... 6-4
Your Vehicle and the Environment................... 6-2
Malfunction Indicator Light................................3-37
Manual Lumbar Controls.................................... 1-4
Manual Seats............................................1-2, 1-3
Manual Transaxle
Fluid..........................................................5-19
Operation...................................................2-24
Manual Windows............................................2-12
Map Lamps ....................................................3-19
Mirrors
Manual Rearview Mirror................................2-32
Outside Convex Mirror.................................2-33
Outside Heated Mirrors................................2-34
Outside Manual Mirrors................................2-32
Outside Power Mirrors..................................2-33
MyGMLink.com................................................ 7-3
N
New Vehicle Break-In......................................2-15
Normal Maintenance Replacement Parts............5-89
O
Odometer......................................................3-29
Odometer, Trip...............................................3-29
Off-Road Recovery..........................................4-12
Oil
Engine.......................................................5-13
Pressure Light.............................................3-39
Older Children, Restraints................................1-28
Online Owner Center........................................ 7-3
Other Warning Devices...................................... 3-8
Outlet Adjustment............................................3-25
Outside
Convex Mirror.............................................2-33
Heated Mirrors............................................2-34
Manual Mirrors............................................2-32
Power Mirrors.............................................2-33
Owners, Canadian............................................... ii
P
Park (P)
Shifting Into................................................2-26
Shifting Out of............................................2-28
Parking
Brake........................................................2-25
Over Things That Burn.................................2-29
9

Parking Your Vehicle.......................................2-29
Part A - Scheduled Maintenance Services............ 6-4
Part B - Owner Checks and Services................6-18
PartC-Periodic Maintenance Inspections..........6-22
PartD-Recommended Fluids and Lubricants....6-24
PartE-Maintenance Record...........................6-26
Passenger Airbag Status Indicator.....................3-31
Passenger Compartment Air Filter.....................3-26
Passenger Sensing System..............................1-60
Passing.........................................................4-12
Power
Accessory Outlet(s)......................................3-19
Door Locks.................................................. 2-8
Electrical System.........................................5-82
Steering Fluid.............................................5-29
Windows....................................................2-12
Pretensioners, Safety Belt................................1-27
Q
Questions and Answers About Safety Belts.........1-15
R
Radios..........................................................3-44
Care of Your CD Player...............................3-75
Care of Your CDs ........................................3-75
Radio with CD............................3-45, 3-49, 3-57
Radio with Six-Disc CD................................3-65
Understanding Reception..............................3-74
Rear Door Security Locks.................................. 2-9
Rear Seat Armrest..........................................2-36
Rear Seat Operation......................................... 1-9
Rear Seat Passengers, Safety Belts..................1-24
Rear Windshield Washer/Wiper.........................3-13
Rearview Mirrors.............................................2-32
Reclining Seatbacks.......................................... 1-5
Recreational Vehicle Towing.............................4-34
Remote Keyless Entry System............................ 2-3
Remote Keyless Entry System, Operation............ 2-4
Removing the Flat Tire and Installing
the Spare Tire.............................................5-69
Removing the Spare Tire and Tools...................5-66
Replacement Bulbs.........................................5-48
10

Service (cont.)
Engine Soon Light.......................................3-37
Publications Ordering Information...................7-15
Servicing Your Airbag-Equipped Vehicle..............1-64
Sheet Metal Damage.......................................5-79
Shifting Into Park (P).......................................2-26
Shifting Out of Park (P)...................................2-28
Short Trip/City Scheduled Maintenance................ 6-6
Shoulder Belt Height Adjuster...........................1-23
Signals, Turn and Lane-Change........................3-10
Spare Tire
Compact....................................................5-73
Installing....................................................5-69
Removing...................................................5-66
Storing.......................................................5-73
Specifications, Capacities.................................5-88
Speed Sensitive Power Steering (SSPS)
Warning Light.............................................3-35
Speedometer..................................................3-29
Starting Your Engine.......................................2-17
Steering........................................................4-10
Steering, Suspension and Front Drive Axle
Boot and Seal Inspection..............................6-22
Steering Wheel Controls, Audio.........................3-73
Steering Wheel, Tilt Wheel................................. 3-9Storage Areas................................................2-34
Convenience Net.........................................2-36
Cupholder(s)...............................................2-34
Front Armrest Storage Area...........................2-35
Front Storage Area......................................2-35
Glove Box..................................................2-34
Hideaway Rear Storage Bins.........................2-37
Rear Seat Armrest.......................................2-36
Roof Rack Provisions...................................2-36
Sunglasses Storage Compartment..................2-35
Stuck in Sand, Mud, Ice or Snow......................4-27
Sun Visors.....................................................2-13
Sunroof.........................................................2-38
T
Tachometer....................................................3-29
Taillamps
Stoplamps, and Back-Up Lamps....................5-48
Turn Signal, and Stoplamps..........................5-46
Turn Signal, Stoplamps and Back-up Lamps....5-47
TCS Warning Light..........................................3-36
Theft-Deterrent System....................................2-13
Theft-Deterrent Systems...................................2-13
12