2006 CHEVROLET KODIAK ECU

Relay Usage
NOTE 1LG4 Powertrain Control Valve,
L18 Fuel Pump, LG5 Heated Fuel
IGN B Ignition
STARTER Starter
HORN Horn
IGN A Ignition
PTO/ECU*Power Take-Off/Engine Control Unit
*Diesel 7.8L DURAMAX
®
REVERSE Reverse
NEUTRAL
STARTNeutral Start
Fuse Usage
IGN 1 Four-Wheel Drive Module
IGN 4 Ignition 4
IGN 3 Ignition 3
BATT/HAZ Battery/Hazard Warning Flashers
HEADLAMP Headlamps
LIGHTING Interior/Exterior Lamps
HVAC Climate Control System
NOTEC4/C5 Electric Brake,
C6/C7/C8 Brake Lamps Secondary Underhood
Fuse Block
5-98

(11)= Chassis Lubrication Service: Lubricate all grease
fittings in front suspension, front axle, and steering
linkage. DO NOT lubricate kingpin bushings with
air pressure equipment; instead, use a hand grease gun
to ensure complete purge and eliminate sealer cap
distortion. Front axle tie rod ends, both upper and lower
kingpin fittings, and both steering linkage relay rod
ends should be greased with the vehicle loaded on the
ground and wheels turned straight ahead, NOT with
the vehicle on a hoist. Apply kingpin bushing lubricant to
both upper and lower kingpin grease fittings until new
lubricant purges from between the upper shim pack and
thrust bearing. Lubricate transmission and shift
linkage, hood latches and hood hinges, parking brake
lever pivot, clevis pins and linkage, disc brake caliper
rails, clutch linkage and release bearing (if equipped),
bearing pads, propshaft universal joints, brake camshaft
bracket, slack adjusters, pedal shaft, clutch cross
shaft, clutch pedal springs, and clutch cable bushing at
transmission. Lubricate suspension, axle, and steering
linkage more often when operating under dusty or
muddy conditions and in excessive off-road use.
Frequently power-washed vehicles will require more
frequent lubrication.(12)= Check steering system:
•Look for damaged, loose, or missing parts. Inspect
the steering linkage relay rod and tie rod ends for
looseness or lack of lubricant. Also look for
parts showing signs of wear or lack of lubrication.
Replace parts as needed. Also check steering gear
mounting bolts, pitman arm nut, gear housing
upper cover and side cover attaching bolts, steering
column mounting bolts and cardan joint clamp
bolts; tighten if necessary. See the service manual.
•Inspect power steering hoses, tubes, and fittings for
leaks. Hoses and lines must not be twisted, kinked,
or tightly bent. Make sure clips, clamps, supporting
tubes, and hoses are in place and properly
secured.
•Check steering gear for leakage around pitman
shaft and housing. If leakage is evident (lubricant
oozing out, not just oily film), leak should be
corrected immediately.
(13)= Check front and rear suspension. Look for
damaged, loose, or missing parts or parts showing signs
of wear or lack of lubrication. Replace parts as
needed.
6-24

Check
Engine Light...............................................3-38
Gages Warning Light...................................3-44
Checking Things Under the Hood......................5-22
Chemical Paint Spotting...................................5-90
Child Restraints
Child Restraint Systems...............................1-34
Infants and Young Children...........................1-31
Lower Anchors and Tethers for Children..........1-41
Older Children.............................................1-28
Securing a Child Restraint in a Rear
Outside Seat Position...............................1-42
Securing a Child Restraint in the Center
Rear Seat Position (Crew Cab) or
Center Front Position................................1-44
Securing a Child Restraint in the Right
Front Seat Position...................................1-46
Where to Put the Restraint...................1-38, 1-40
Chime Level Adjustment..................................3-67
Cigarette Lighter.............................................3-20
Cleaning
Aluminum or Chrome-Plated Wheels..............5-89
Exterior Lamps/Lenses.................................5-87
Fabric/Carpet..............................................5-85
Finish Care.................................................5-87
Inside of Your Vehicle..................................5-83
Instrument Panel, Vinyl, and Other
Plastic Surfaces.......................................5-86Cleaning (cont.)
Tires..........................................................5-89
Underbody Maintenance...............................5-90
Washing Your Vehicle...................................5-87
Weatherstrips..............................................5-86
Windshield and Wiper Blades........................5-88
Climate Control System...................................3-20
Outlet Adjustment........................................3-24
Rear Heating System...................................3-24
Collision Damage Repair................................... 7-7
Control of a Vehicle.......................................... 4-6
Coolant
Engine Temperature Gage............................3-36
Heater, Engine............................................2-26
Low Warning Light.......................................3-37
Surge Tank Pressure Cap.............................5-40
Cooling System..............................................5-42
Cruise Control................................................3-10
Customer Assistance Information
Customer Assistance for Text
Telephone (TTY) Users............................... 7-3
Customer Assistance Offices........................... 7-4
Customer Satisfaction Procedure..................... 7-2
GM Mobility Reimbursement Program............... 7-5
Reporting Safety Defects to
General Motors........................................7-11
Reporting Safety Defects to the
Canadian Government..............................7-11
3

Securing a Child Restraint
Center Rear Seat Position (Crew Cab)
or Center Front Position............................1-44
Rear Outside Seat Position...........................1-42
Right Front Seat Position..............................1-46
Service........................................................... 5-3
California Proposition 65 Warning.................... 5-3
Doing Your Own Work................................... 5-4
Engine Fan Breakage.................................... 5-5
Engine Soon Light.......................................3-38
Publications Ordering Information...................7-11
Transmission Warning Light..........................3-32
Servicing Your Airbag-Equipped Vehicle..............1-61
Setting the Time.............................................3-49
Sheet Metal Damage.......................................5-89
Shoulder Belt Height Adjuster...........................1-22
Signals, Turn and Lane-Change.......................... 3-8
Sliding Rear Windows.....................................2-10
Snow Plow....................................................4-36
Specifications, Capacities.................................5-99
Speedometer..................................................3-27
Split Bench Seat.............................................. 1-6
Starting Your Diesel Engine..............................2-15
Starting Your Gasoline Engine..........................2-13
Steering........................................................4-13
Steering Wheel, Tilt Wheel................................. 3-7Storage Areas................................................2-49
Center Console Storage Area........................2-49
Stuck in Sand, Mud, Ice, or Snow.....................4-32
Sun Visors.....................................................2-10
Suspension, Air..............................................2-44
Switchbanks, Instrument Panel..........................3-18
T
Tachometer....................................................3-27
Theft-Deterrent, Radio.....................................3-64
Tilt Wheel........................................................ 3-7
Tires.............................................................5-74
Aluminum or Chrome-Plated Wheels,
Cleaning.................................................5-89
Cleaning....................................................5-89
Dual Tire Operation.....................................5-76
If a Tire Goes Flat.......................................5-82
Inflation - Tire Pressure................................5-75
Tightening the Wheel Nuts............................5-77
Wheel Alignment and Tire Balance.................5-77
Wheel Loading............................................5-75
Wheel Replacement.....................................5-81
When It Is Time for New Tires......................5-76
Tow Hooks.....................................................4-33
12