2005 YAMAHA VX110 fuel

8-17
E
HULL
HOODHOSES
HOSES
EXPLODED DIAGRAM
REMOVAL AND INSTALLATION CHART
Step Procedure/Part name Q’ty Service points
HOSES REMOVAL
Follow the left “Step” for removal.
Fuel tank Refer to “FUEL TANK AND FUEL PUMP
MODULE” in Chapter 4.
Accelerator position sensor Refer to “Throttle cable inspection and
adjustment” in Chapter 3.
NOTE:
When removing the ventilation hose and
fuel tank breather hose, it is not necessary
to remove the fuel tank.
1 Band 8
2 Grommet 2
4
1 7
9
8
5
6
1
11
3
1
1
2
3
21
1
4
4.2 N • m (0.42 kgf • m, 3.0 ft • Ib)
(VENT)
(VENT)
FWD
ProCarManuals.com

8-18
E
HULL
HOODHOSES
EXPLODED DIAGRAM
Step Procedure/Part name Q’ty Service points
3 Ventilation hose 2
4 Fuel tank breather hose 2
5Clamp 1
6 Cooling water hose 1
7Nut 1
8 Cooling water pilot outlet 1
9 Seal 1
Reverse the removal steps for installation.
4
1 7
9
8
5
6
1
11
3
1
1
2
3
21
1
4
4.2 N • m (0.42 kgf • m, 3.0 ft • Ib)
(VENT)
(VENT)
FWD
ProCarManuals.com

9-4
E
TRBL
ANLS
TROUBLE ANALYSIS
TROUBLE ANALYSIS
NOTE:
Before consulting the “TROUBLE ANALYSIS CHART,” check the following items.
1. Check that the battery is charged and that its specified gravity is within specification.
2. Check that there are no incorrect wiring connections.
3. Check that all wiring connections are properly secured and that they are not rusty.
4. Check that the engine shut-off cord (lanyard) is connect to the engine shut-off switch.
5. Check that fuel is reaching the fuel rail.
TROUBLE ANALYSIS CHART
Trouble mode Check elements
ENGINE WILL NOT START
HARD STARTING
ROUGH IDLING
HIGH IDLING
ENGINE STALLS
POOR ACCELERATION
ENGINE WILL NOT STOP
POOR PERFORMANCE
LIMITED ENGINE SPEED
OVERHEATING
LOW OIL PRESSURE
LOOSE STEERING
BILGE INCREASE
IRREGULAR WARNING INDICATION
POOR BATTERY CHARGING
Relative partReference
chapter
FUEL SYSTEM
Fuel tank 4
Fuel tank breather hose 4
Fuel hose 4
Fuel filter 4
Fuel pump 4
Fuel rail 4
Fuel injectors 4
Trolling speed 3
Air filter 3
ProCarManuals.com

9-6
E
TRBL
ANLS
TROUBLE ANALYSIS
JET PUMP UNIT
Duct 6
Impeller 6
Intake grate 6
Bearings 6
Water inlet hose 6
Bilge hose 6
Bilge strainer 3
Bilge hose joint 6
ELECTRICAL
Ignition system, fuel control system
Pickup coils 7
ECM 7
Ignition coils 7
Slant detection switch 7
Engine stop switch 7
Engine shut-off switch 7
Spark plugs 3
Main and fuel pump relay 7
Electronic control throttle
valve relay7
Thermoswitch 7
Sensor assembly 7
Engine temperature
sensor7
Throttle body assembly
(throttle position sensor)7
Accelerator position
sensor7
Cam position sensor 7 Trouble mode Check elements
ENGINE WILL NOT START
HARD STARTING
ROUGH IDLING
HIGH IDLING
ENGINE STALLS
POOR ACCELERATION
ENGINE WILL NOT STOP
POOR PERFORMANCE
LIMITED ENGINE SPEED
OVERHEATING
LOW OIL PRESSURE
LOOSE STEERING
BILGE INCREASE
IRREGULAR WARNING INDICATION
POOR BATTERY CHARGING
Relative partReference
chapter
ProCarManuals.com

WIRING DIAGRAM
VX110 Sport
1Battery
2Starter motor
3Fuse (30 A)
4Fuse (20 A)
5Fuse (3 A)
6Fuse (10 A)
7Fuse (10 A)
8Starter relay
9Main and fuel pump relay
0Electronic control throttle valve relay
ASlant detection switch
BIgnition coil
CSpark plug
DCam position sensor
ESensor assembly
(intake air pressure and intake air tempera-
ture)
FEngine temperature sensor
GThermoswitch (engine)
HThermoswitch (exhaust)
IOil pressure switch
JFuel injector
KECM
LRectifier/regulator
MThrottle body assembly
NAccelerator position sensor
OPickup coil
PLighting coil
QBuzzer
RElectric fuel pump
SSteering sensor
TFuel sender
USpeed sensor
VMultifunction meter
WStart switch
XEngine stop switch
YEngine shut-off switch
ÈTo tachometerColor code
B: Black
Br : Brown
G: Green
Gy : Gray
L: Blue
O : Orange
P: Pink
R: Red
W: White
Y : Yellow
B/G : Black/green
B/O : Black/orange
B/R : Black/red
B/W : Black/white
B/Y : Black/yellow
G/B : Green/black
G/O : Green/orange
G/R : Green/red
G/Y : Green/yellow
L/R : Blue/red
P/G : Pink/green
P/W : Pink/white
Pu/B : Purple/black
Pu/G : Purple/green
Pu/R : Purple/red
Pu/Y : Purple/yellow
R/W : Red/white
R/Y : Red/yellow
W/B : White/black
W/L : White/blue
W/R : White/red
Y/G : Yellow/green
Y/W : Yellow/white
ProCarManuals.com

WIRING DIAGRAM
VX110 Deluxe
1Battery
2Starter motor
3Fuse (30 A)
4Fuse (20 A)
5Fuse (3 A)
6Fuse (10 A)
7Fuse (10 A)
8Starter relay
9Main and fuel pump relay
0Electronic control throttle valve relay
ASlant detection switch
BIgnition coil
CSpark plug
DCam position sensor
ESensor assembly
(intake air pressure and intake air tempera-
ture)
FEngine temperature sensor
GThermoswitch (engine)
HThermoswitch (exhaust)
IOil pressure switch
JFuel injector
KRemote control unit
LAntenna
MECM
NRectifier/regulator
OThrottle body assembly
PAccelerator position sensor
QPickup coil
RLighting coil
SBuzzer
TElectric fuel pump
USteering sensor
VFuel sender
WSpeed sensor
XMultifunction meter
YStart switch
ZEngine stop switch
[Engine shut-off switch
ÈTo entry box
ÉTo tachometerColor code
B: Black
Br : Brown
G: Green
Gy : Gray
L: Blue
O : Orange
P: Pink
R: Red
W: White
Y : Yellow
B/G : Black/green
B/O : Black/orange
B/R : Black/red
B/W : Black/white
B/Y : Black/yellow
G/B : Green/black
G/O : Green/orange
G/R : Green/red
G/Y : Green/yellow
L/B : Blue/black
L/R : Blue/red
L/Y : Blue/yellow
P/G : Pink/green
P/W : Pink/white
Pu/B : Purple/black
Pu/G : Purple/green
Pu/R : Purple/red
Pu/Y : Purple/yellow
R/W : Red/white
R/Y : Red/yellow
W/B : White/black
W/L : White/blue
W/R : White/red
Y/G : Yellow/green
Y/W : Yellow/white
ProCarManuals.com