2005 YAMAHA JOG50R check oil

and the cables and cable ends should
be lubricated if necessary. If a cable is
damaged or does not move smoothly,
have a Yamaha dealer check or repla-
ce it.
EWA10720
s s
WARNING
Damage to the outer sheath may
interfere with proper cable opera-
tion and will cause the inner cable
to rust. Replace a damaged cable
as soon as possible to prevent
unsafe conditions.
EAU23110
Checking and lubricating the
throttle grip and cable
The operation of the throttle grip
should be checked before each ride.
In addition, the cable should be lubri-
cated or replaced at the intervals spe-
cified in the periodic maintenance
chart.
EAU23120
Adjusting the Autolube pump
The Autolube pump is a vital and sop-
histicated component of the engine,
which must be adjusted by a Yamaha
dealer at the intervals specified in the
periodic maintenance and lubrication
chart.
EAU23170
Lubricating the front and
rear brake levers
The pivoting points of the front and
rear brake levers must be lubricated
at the intervals specified in the perio-
dic maintenance and lubrication
chart.
EAU23190
Checking and lubricating the
centerstand
The operation of the centerstand
should be checked before each ride,
and the pivots and metal-to-metal
contact surfaces should be lubricated
if necessary.
EWA11300
s s
WARNING
If the centerstand does not move
up and down smoothly, have a
Yamaha dealer check or repair it.
Recommended lubricant:
Lithium-soap-based grease (all-
purpose grease)
Recommended lubricant:
Lithium-soap-based grease (all-
purpose grease)
Recommended lubricant:
Engine oil
6
PERIODIC MAINTENANCE AND MINOR REPAIR
6-14
5RW-F8199-E3.qxd 23/12/2004 09:33 Página 41

EAU23271
Checking the front fork
The condition and operation of the
front fork must be checked as follows
at the intervals specified in the perio-
dic maintenance and lubrication chart.
To check the condition
EWA10750
s s
WARNING
Securely support the motorcycle so
that there is no danger of it falling
over.
Check the inner tubes for scratches,
damage and excessive oil leakage.
To check the operation
1. Place the motorcycle on a level
surface and hold it in an upright
position.2. While applying the front brake,
push down hard on the handle-
bars several times to check if the
front fork compresses and
rebounds smoothly.
ECA10590
CAUTION
If any damage is found or the front
fork does not operate smoothly,
have a Yamaha dealer check or
repair it.
EAU23280
Checking the steering
Worn or loose steering bearings may
cause danger. Therefore, the opera-
tion of the steering must be checked
as follows at the intervals specified in
the periodic maintenance and lubrica-
tion chart.1. Place a stand under the engine to
raise the front wheel off the
ground.
EWA10750
s s
WARNING
Securely support the motorcycle so
that there is no danger of it falling
over.
2. Hold the lower ends of the front
fork legs and try to move them
forward and backward. If any free
play can be felt, have a Yamaha
dealer check or repair the stee-
ring.
EAU23290
Checking the wheel bearings
The front and rear wheel bearings
must be checked at the intervals spe-
cified in the periodic maintenance and
lubrication chart. If there is play in the
wheel hub or if the wheel does not
turn smoothly, have a Yamaha dealer
check the wheel bearings.
6
PERIODIC MAINTENANCE AND MINOR REPAIR
6-15
5RW-F8199-E3.qxd 23/12/2004 09:33 Página 42

NOTE:
Consult a Yamaha dealer for advice
on what products to use.
EAU26300
Storage
Short-term
Always store your scooter in a cool,
dry place and, if necessary, protect it
against dust with a porous cover.
ECA10820
CAUTION
Storing the scooter in a poorly
ventilated room or covering it
with a tarp, while it is still wet,
will allow water and humidity to
seep in and cause rust.
To prevent corrosion, avoid
damp cellars, stables (because
of the presence of ammonia)
and areas where strong chemi-
cals are stored.
Long-term
Before storing your scooter for seve-
ral months:
1. Follow all the instructions in the
“Care” section of this chapter.
2. Drain the carburetor float cham-ber by loosening the drain bolt;
this will prevent fuel deposits
from building up. Pour the drai-
ned fuel into the fuel tank.
3. Fill up the fuel tank and add fuel
stabilizer (if available) to prevent
the fuel tank from rusting and the
fuel from deteriorating.
4. Perform the following steps to
protect the cylinder, piston rings,
etc. from corrosion.
a. Remove the spark plug cap and
spark plug.
b. Pour a teaspoonful of engine oil
into the spark plug bore.
c. Install the spark plug cap onto
the spark plug, and then place
the spark plug on the cylinder
head so that the electrodes are
grounded. (This will limit sparking
during the next step.)
d. Turn the engine over several
times with the starter. (This will
coat the cylinder wall with oil.)
e. Remove the spark plug cap from
the spark plug, and then install
the spark plug and the spark plug
cap.
EWA10950
s s
WARNING
To prevent damage or injury from
sparking, make sure to ground the
spark plug electrodes while turning
the engine over.
5. Lubricate all control cables and
the pivoting points of all levers
and pedals as well as of the
sidestand/centerstand.
6. Check and, if necessary, correct
the tire air pressure, and then lift
the scooter so that both of its
wheels are off the ground. Alter-
natively, turn the wheels a little
every month in order to prevent
the tires from becoming degra-
ded in one spot.
7. Cover the muffler outlet with a
plastic bag to prevent moisture
from entering it.
8. Remove the battery and fully
charge it. Store it in a cool, dry
place and charge it once a
month. Do not store the battery in
an excessively cold or warm pla-
ce [less than 0 °C (30 °F) or more
than 30 °C (90 °F)]. For more
7
SCOOTER CARE AND STORAGE
7-3
5RW-F8199-E3.qxd 23/12/2004 09:33 Página 50

22-Stroke engine oil .....................................1-1
AAcceleration and deceleration ...................2-1
Adjusting the autolube pump ....................2-1
Adjusting the carburetor ............................2-2
Adjusting the front brake lever free play....2-3
Adjusting the rear brake lever free play .....3-1
Adjusting the throttle cable free play .........3-1
BBattery........................................................3-1
Braking .......................................................3-2
CCare............................................................3-3
Changing the brake fluid............................3-3
Checking and lubricating the cables .........3-3
Checking and lubricating the centerstand.3-4
Checking and lubricating the throttle
grip and cable ..........................................3-4
Checking the front brake fluid level ...........3-4
Checking the front fork ..............................3-5
Checking the spark plug ............................3-6
Checking the steering ................................3-6
Checking the wheel bearings ....................3-6
Cheking the front brake pads and
rear brake shoes ......................................4-1
Cleaning the air filter element ....................4-2
Clock ..........................................................5-1
Controls and instruments ..........................5-1
Coolant (only for liquid-cooled models) ...5-2
EEngine break-in ..........................................5-2
FFinal transmission oil .................................5-2Front brake lever ........................................6-1
Fuel and 2 stroke engine oil tank caps......6-2
Fuel gauge .................................................6-5
HHandlebar switches ...................................6-6
IIndicator lights ...........................................6-6
KKickstarter ..................................................6-8
LLeft view .....................................................6-9
Lubricating the front and rear brake
levers .......................................................6-9
M
Main switch/steering lock ..........................6-9
PParking .....................................................6-11
Periodic maintenance and lubrication
chart .......................................................6-12
Pre-operation check list ...........................6-13
RRear brake lever .......................................6-14
Replacing a turn signal light bulb or
the tail/brake light bulb ..........................6-14
Replacing the fuse ...................................6-14
Replacing the headlight bulb or a
front turn signal light bulb .....................6-14
Replacing the license plate light bulb......6-15
Right view ................................................6-15
SSeat ..........................................................6-16
Speedometer unit ....................................6-17
Starting a cold engine ..............................6-18
Starting off ...............................................6-19Storage compartment ..............................6-20
Storage compartment ................................7-1
TTires ...........................................................7-1
To check the coolant level .........................7-3
Troubleshooting .........................................8-1
Troubleshooting chart ................................9-1
INDEX
5RW-F8199-E3.qxd 23/12/2004 09:33 Página 55