2005 VOLKSWAGEN GOLF ESP

Never excee d the maximum inflation pressure listed o n the tire sidewall for
that the ve hicle manufacturer. no t the tir e m anufacturer. determines the co rrect
tir e
pressure for the tire s on your vehic le
the required tire pressure from the tire pressure label on the open ed ge of the driver's
door.
Place the air pressure gauge on the dust caps -the re is no need
The tire pressures should only be ch ecked when the tires are co ld. T he s lightl y raised pres­
sures of warm t ires mus t not be red uced.
Adjust the tire pressure to the load you are
carrying.
Vehicle with
Head the required tir e pres sure from the tire
pressure on the ope n edge of the driver's
d oor.
Turn the va lve stem cap counter-cloc kwise to
remove i t from the ti re va lve.
Place the air pressure gauge on the valve.
The tire pressures should onl y be c hecked and adjusted when the tire s are cold. The slightl y
raised pressures of warm tires must not b e re­
duced.
Adju st the tir e pressure to the load you are
carryin g.
the valve stem cap on the valve.
When should check the tire pressure?
The correct tire pressure is especi ally important
at high speeds. The pressure sh oul d there fore be ch ecked at least once a month and always before
s tarting a journey. Do not forge t check the tire pressure on th e spare whee l7l
When should odjust the tire pressures?
Adju st
the tire pressure to the load you are car­
ry ing. Af ter changing a
addition on vehicles with TPMS,
yo u should sp ecify new tire
sudden tire failure loss of control, collision, serious personal injury even death.
Always fill tires to the recommende d and correct tire pressure before dri ving ofT.
Driving with underinflated tires bend m ore, letting them get too hot resulting in
tread separation, sudden tire failure tire
failure and loss of control.
Excessive speed and/or overloading can heat build-up, sudden tire failu re in­cluding a blowout and sudden deflation and
loss o f co ntrol.
If the tir e pressure is too low or too high, the tires w ill wear prematurely and the ve hicle
will not handle we ll.
with tire pressure monitoring system To prevent this, make sure that factory
For the sake of environment
Tip s
For vehicles
may find differences between the pres­
s ur e read ings fro m a hand-held pressure gauge
a nd the pressure readings disp laye d in the in­
s trument The tire pres sure monitoring syste m is more acc urat e.
the is too
applicable =Tire press ure monitoring
applicable
69

(continued)
T ires age even if they arc not being used
and can f ail suddenly, especially at high
s peeds. Tire s that are more than 6 years old can only be used in an emerge ncy and then special care and at lo we r speeds.
(continued)
Never mount used tires on yo ur ve hicle if yo u are not sure of their used tir es may have been damaged eve n though the damage cannot be seen that can lead to sudden tire fa ilure and loss of vehicl e control.
Ne w tires and wheels have to be broke n in.
Ratio of height to width (aspect ratio)
of tire - Load
index &
speed rating
in
hicle's design
. The tires and rim s approved by Volk swagen are specially matched to th e te ristics of th e ve hicl e and can make a major comribution to good road ho ldin g and safe
We recommend that all wo rk on tires and wheels be performed by an authorized Volkswage n dealer. They arc famil iar with recommended procedures and have the sp ecial tools
and spare pa rts as well as the proper facilit ies for disposing of the old tires .
Author ized Volkswage n dealers have
the sary info rmation about technical requirements for installing or changin g tires and rims.
R
eplacing tires and wheels
Tires should b e replaced at lea st in pairs and not
individuall y (fo r example both front !ires or
ve hicle with read and heed th e page 75,

Maximum Load Ratin g
This number indi cates the maximum load in and pounds that can be carried b y th e
tire. Tire
and temperature resistance.
Tire quality grading for tr ead wear, traction,
and temperature resistance
Tread trac tion tempe rature grades
Maximum Permissibl e
su re that sh o ul d ever be put in t he tir e under normal driv in g con d itio ns.
Replacin g tire s
or rims on
stantly monitors the air pressure in sid e the tire , and then transmit s thi s information to th e
you arc goin g to replace the wheel
rims on your ve hicl e, have these se n sors. The sensors must be compatibl e with the sys te m on yo ur hicle .
you rims. which do not sors, or have sensors w hi ch are not compatibl e,
then the TPM S will no t wo rk properly. wo uld not be able to monit or the tir e pressure o r you if it i s necessaty.
senso rs mus t b e rep laced at sp ecific va ls.
yo u ch an ge sen sors, yo u have to new valv es.
driv e wi th the stem caps curely m ounted . valve stem caps. your authorized Volk swage n dealer to re p lace lost va lve stem caps.
T he in stallat i
on of replacement ti res w ith steel cord p lie s in th e tire sidewal l may cause m alfuncti on of the tire pressure monitoring sys te m and is no t recomme nded (cord material inform ation in molded o n the tir e
if your ve hicle was equipped with r un-flat tires. rep la cin g them
wi th tire s that are not identical to th ose fill ed may cause mal function of the
3.2 Tips and Advice
and i s not recommended. Run-flat ti res should not be used to replace regular tires.
indicator after p la cing o ne or more tire s on you r ve hicle. the m alfu nctio n indi cator is is
not working p ro perly. Your r eplacement tire
m ight be incompatible with system,
o r some component of the be age d.
Usin g incorrect or unmatch ed tires and I or wheels or imprope r tire and wheel
use tires , rims and wheel b o lts that meet the sp ecificatio ns o f o ri ginal
Tires age even if they are n o l b eing used and can fail suddenly, especially a t hi gh
s peeds. Tires that arc m ore tha n 6 years old can only be used in an em erge ncy and then
w ith special care and lower speed s.
Never moun t used tires o n your ve hicl e if you are not sure o f their
four whee ls mus t be fitt ed with radial tires o f the same ence) and the same tread pattern. Dri ving with different tires reduces vehicle and can lead t o loss of contro l.
If the s pare wheel is no t the sam e as the tires that are m ounted on the vehicle-fo r ample with winter tires-on ly usc th e spare w heel fo r a short perio d of t im e and drive with extra care. Refit the normal road w heel as s oo n
a s safe ly possibl e.
Neve r drive fa ster th a n the maximum
speed f or which the tires on your ve hicl e are
r a te d because ti res that are driven faste r than their ra te d speed can suddenly.
Ov erloading tires cause heat build -up,
sudde n tire failure, including a blowout and sudden d eflati on and loss of control.

The g rad e C corresponds to a level of passe nger car tires must meet under the Federa l Motor G rades
trac tion tests, does not acceleration, cornerin g, droplaning or peak traction ch aracteristics.
Winter tire s
3.2 Tips and Advice
Winter tires can improve vehicle handling on snow and ice. At temperatures
b elow
F
some heav y snow areas, local governments may require true w inter or tires, those with very deeply cut trea d. T hese tires should only be used in pair s and be installed on fou r
wheels. Make sure you purchase snow tires that are the same size and construction type as th e
other tires on your
fou r wheels on you r
performance and reduces stoppin g di stances.
S
ummer tire s provide less grip on ice and snow.
tires (snow tir es) must have th e same specification and must always be fille d on four wheels.
yo u want to usc the tire pressure monitoring system compatibl e sensors must be ins talled on fou r winte r page
dealer or
tires lose their effectiveness when the tread is worn down to a dept h of 4 mm inch).
drive with winter tires under winter tion s. Summe r tire s handl e whe n th ere is n
o s
now or ice on the roads and the temperature is above F C).
you have a sec notes on spare wheel 73, tires and replacing tires and
alway s remember that winter tires may have a lower speed rati ng than the tires installed on your veh icle at the time it was manufactured. page 59, rating (letter for listin g oft he speed
r at ing le tt er
codes and the maximum speed at
w hi ch the t ires can be driven.
The speed ratin g le tter page 59) is o n
t h e s ide of th e page 73, fig. 19.
tires have maximum speed that may be lower than your m aximum speed. Always know the maximum speed fo re driving off. Never drive faster than the
s peed permilled fo r your specific winter tire s.
T his will cause damage to the t ires leadin g to an accident and serious pe rsonal injury to you and your passe nge rs.
= Tire press ure monito ring sys tem )
and

3.2 Tips and Advice
WARNING
The spare whee l may be smaller than the origina l tir e. The s maller spare wheel is identi­fied with a sticker and the words
The spare whee l m ust be returned to the
spare whee l well so on as the standard road
wheel can be re pla ced.
Getting started
The spare wheel must always be secured
with the w hee l bolts provided by the factory .
After
r
vehicle in a safe place before changing a wheel.
If yo u have a flat tire or puncture, park
the vehicle as far away fro m the of
traffic as possib le on a firm, even surface
Turn off the e ngin e. Turn on the emer­
gency flasher.
App ly the parkin g brake firm ly and e n ­
gage a
gear or put the selector in
If yo u are towin g a trailer, unhitch it
from yo
ur vehicle.
WARNING
Changin g a wheel, especially on
Alw ays stop the ve hicl e
to change the
Turn on th e e merge ncy fla sh er and se t up an o th er warning device ab o ut 27 ya rds (25 meters) beh ind the vehicl e to warn ap­
proa ching traffic.
Always sure th at th e ground is leve l and firm, if necessary usc sturdy under the ja ck .
When one wh eel is lift ed off the ground putting the se lec to r l ever in
Always apply tl1e par k in g brake firmly and firmly engage gea r or put th e selec tor lever in

WARNING
Alwa ys sto p the as soon as it is safe
to do so and move th e a safe di stance off the road where it is sa fe to lock doors in an em erge ncy. Turn on the em erg ency to warn approaching traffic.
Neve r a door without making sure that it is s afe to do so. ca n injure self or other people. Always make certain that no one is in the way of the door that is be ing
3.2 Tips and Adv ic e
(continue d)
Never le ave childr en, di sa ble d person s or
anyo ne w ho cannot he lp themselves in the
in peo pl e bein g trapped in the in em erge ncy. For example, depending o n th e time of year, people trapp ed in the can be ex posed to very high or low temperatures.
Tips
ca n unlock the passenger's door a nd the rear doors from the inside again if yo u the door openin g leve r once .
rea r lid can be opened from inside the luggag e compartment.
__ _ ,
Fig. 31 Emergency unlocking of t he rear lid
-Fold the rea r seat back forward
booklet 3.1
the release lever in the direction
of the fig. 31 to re lease the rear lid .
WARNING
A chi ld or oth er p erson trapped in the lu ggage compartment of a can be se riously jure d and eve n die .
Neve r leave your unatt ended or let
childr en play around your especia lly
wit h th e trunk lid le ft open.A child could cra wl
int o th e through the lugga ge ment and
wh en it is very hot or cold .
Neve r leave childr en, disabled persons or
a n yone T he doors ca n b e lock ed usi ng mote contro l key or the powe r lock butto n .
T his could res ult in peop le bei ng trapped in
th e
ment and lugg age compartment of a parked vehicle can resu lt in tempe ratures in the that arc mud1 higher than th e outs ide
t emperatur es , particu larly in summer. peratures can quickl y reac h levels that can cause unconscio usn ess and d eath, larly to c hildr en .
What do do now? 89

left side of the instrument panel and behind fu se box covers in
the engine
compa rtment.
Fig. 32
- Turn off the igni tion and the con­
cerning component.
-
Insert the flat blade of a screwdri ver
into
the openin g of th e fuse box cove r
32.
-
the respeclive fuse.
-
the fuse tables to find out the loca-
tion of the blown page 92.
- If
the fuse is blown (the m etal strip is
melted) , replace it w ith a new fuse of the
same amp ra tin g (sa m e co lo r and sam e
marking).
Fuse bo x Bin the engine compartment
-Turn off the ign ition an d the con ­
cerning component.
-th e eng in e hood.
fig . 33 .
- Remove
the cover.
-To remount the cover, place it ove r the
fuse box and press th e lock buttons back­
ward aga inst the directio n of the arrow
until
they latch securely .
Th e indi vidual electric a l c ir cuit s are pro tected by fuses. recommend you carry severa l spare
f uses at
clear 2 5

Booklet 3.2 Tips and Advice
Changing
Light bulbs should be changed by a qualified technician
m an y cases changing a light bul b
invol ves remov in g other pa ns of the car to
recommen d light bulbs o nl y be chan ge d
b y an authorized Volkswage n dea le r or qual ified workshop.
Before changin g a light bulb. yo u must sw itch ofT the light (lig ht switch in
tical light bulbs w ith sam e s pecificati o ns. The
s p ecifi catio ns arc prime d on the lig h t bulb . ther on the glass bulb or o n th e m eta l base.
is advi sable to alw ay s carry a box of
for traffi c safe ty. swage n dealer for re comm ended light bulbs.
Additional light specificati o ns
light bulbs in the headli gh ts or in verse lights can hav e fac tory-set s pecifi cntion s that diffe r fro m conventi onnllight bulbs. Th e corresp onding model identifi cation is either on the bulb bas e or on th e bulb itself.
LL = LongLife bulbs w ith a lo nger life compared to con ve ntional light bulb s.
Blue =
Light bulbs w ith blui sh -w hite abl e for di scharge light s (Xenon/Bi-Xcno n light s).
Stop! Before workin g in the engine always read and heed all
94 What do
(cont inued)
page 39. The engine compartment of any motor vehicl e is a p otentiall y dangerous area and can cause serious personal injury.
Gas discharge la m ps (Xen on) get power from a high voltage source that can cause rious personal injury and even death if dled improperly.
bulbs arc under hi gh pressure and can exp lode if handled improperly.
Always have a qualified technician r eplace burnt-out light bulbs, especially gas discharge
lamp s (Xenon) and bulbs.
Neve r remove the headlight unless you know exactly how to carry out the job and have the correct tool and li ght bulbs.
yo u arc uncertain about what to do, have the work performed by an auth orize d swagen d ealer or a qualified workshop. rious personal injury m ay result from erly performe d work.
There arc parts w ith sh arp edges on the headlight h ousin g in the en gi ne compartment and on the rear light h o usings.
Do not touc h glass bulb with bare hands. can clo ud the o uter surface of the bul b when thus afTccting the refle ction , and th us reducing the power of illuminat ion.
A bulb can only be re placed b y a bulb of the sam e ty pe . The m odel identifica tion is either o n the bulb base or on the bulb itself.