2005 TOYOTA LAND CRUISER fuel pump

207
INFORMATION BEFORE DRIVING
YOUR TOYOTA
Off−road vehicle precautions 208
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Break −in period 209
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . .
Fuel 209
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . . . . . .
Fuel pump shut off system 211
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operation in foreign countries 211
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Three −way catalytic converter 212
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine exhaust cautions 213
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
Facts about engine oil consumption 214
. . . . . . . . . . . . . . . . . . . . . . . . . .
Iridium −tipped spark plugs 215
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Brake system 215
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . .
Brake pad wear limit indicators 219
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear step bumper 219
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . .
Limited −slip differential 220
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. .
Your Toyota’s identification 220
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Theft prevention labels 221
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. .
Suspension and chassis 221
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
Tire information 222
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . .
Vehicle load limits 230
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . .
Cargo and luggage 230
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . .
Types of tires 233
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . .
SECTION 2

209
Always slow down in gusty cross-
winds. Because of its profile and
higher center of gravity, your ve-
hicle is more sensitive to side
winds than an ordinary passenger
car. Slowing down will allow you
to have better control.
When driving offroad or in rugged
terrain, do not drive at excessive
speeds, jump, make sharp turns,
strike objects, etc. This may cause
loss of control or vehicle rollover
causing death or serious injury.
You are also risking expensive dam-
age to your vehicle’s suspension
and chassis.
Do not drive horizontally across
steep slopes. Driving straight up
or straight down is preferred. Your
vehicle (or any similar offroad ve-
hicle) can tip over sideways much
more easily than forward or back-
ward.
Breakin period
Drive gently and avoid high speeds.
Your vehicle does not need an elaborate
break−in. But following a few simple tips
for the first 1600 km (1000 miles) can add
to the future economy and long life of
your vehicle:
Avoid full −throttle acceleration when
starting and driving.
Avoid racing the engine.
Try to avoid hard stops during the first
300 km (200 miles).
Do not drive for a long time at any
single speed, either fast or slow.
Do not tow a trailer during the first 800
km (500 miles).
Fuel
FUEL TYPE
Your new vehicle must use only un-
leaded gasoline.
To help prevent gas station mix −ups, your
Toyota has a smaller fuel tank opening.
The special nozzle on pumps with un-
leaded fuel will fit it, but the larger stan-
dard nozzle on pumps with leaded gas will
not.
At a minimum, the gasoline you use
should meet the specifications of ASTM
D4814 in the U.S.A. and CGSB 3.5 −M93
in Canada.
NOTICE
Do not use leaded gasoline. Use of
leaded gasoline will cause the three
way catalytic converter to lose its ef-
fectiveness, the emission control sys-
tem to function improperly, and dam-
age to the engine. Also, this can in-
crease maintenance costs.

211
GASOLINE QUALITY
In a very few cases, you may experience
driveability problems caused by the partic-
ular gasoline that you are using. If you
continue to have unacceptable driveability,
try changing gasoline brands. If that does
not rectify your problem, then consult your
Toyota dealer.
NOTICE
Do not use gasohol other than
stated above. It will cause fuel sys-
tem damage or vehicle performance
problems.
 If drive ability problems are occur
(poor hot starting, vaporizing, en-
gine knock, etc.), discontinue the
use.
 Take care not to spill gasohol dur-
ing refueling. Gasohol may cause
paint damage.
FUEL TANK CAPACITY
96 L (25.4 gal., 21.1 Imp.gal.)
Fuel pump shut off system
The fuel pump shut off system stops sup-
plying fuel to the engine when the engine
stalls or an airbag inflates upon collision.
To restart the engine after the fuel pump
shut off system activates, turn the ignition
switch to “ACC” or “LOCK” once and start
it.
CAUTION
Inspect the ground under the vehicle
before restarting the engine. If you
find that liquid has leaked onto the
ground, it is the fuel system has
been damaged and it is in need of
repair. In this case, do not restart the
engine.
Operation in foreign countries
If you plan to drive your Toyota in
another country...
First, comply with the vehicle registration
laws.
Second, confirm the availability of the
correct fuel (unleaded and minimum oc-
tane number).

298
Oil identification marks
Either or both API registered marks are
added to some oil containers to help
you select the oil you should use.
The API Service Symbol is located any-
where on the outside of the container.
The top portion of the label shows the oil
quality by API (American Petroleum Insti-
tute) designations such as SL. The center
portion of the label shows the SAE viscos-
ity grade such as SAE 5W−30. “Energy −
Conserving” shown in the lower portion,
indicates that the oil has fuel −saving ca-
pabilities.
The ILSAC (International Lubricant Stan-
dardization and Approval Committee) Certi-
fication Mark is displayed on the front of
the container.
To ensure excellent lubrication perfor-
mance for your engine, “Toyota Genuine
Motor Oil” is available, which has been
specifically tested and approved for all
Toyota engines.
Please contact your Toyota dealer for fur-
ther details about “Toyota Genuine Motor
Oil”. Look at the seethrough coolant reser-
voir when the engine is cold. The cool-
ant level is satisfactory if it is between
the “FULL” and “LOW” lines on the
reservoir. If the level is low, add the
coolant. (For the coolant type, see
“Coolant type selection” described be-
low.)
The coolant level in the reservoir will vary
with engine temperature. However, if the
level is on or below the “LOW” line, add
coolant. Bring the level up to the “FULL”
line.
If the coolant level drops within a short
time after replenishing, there may be a
leak in the system. Visually check the
radiator, hoses, radiator cap and drain
cock and water pump.
If you can find no leak, have your Toyota
dealer test the cap pressure and check
for leaks in the cooling system.
CAUTION
To prevent burning yourself, do not
remove the radiator cap when the en-
gine is hot.
Checking the engine coolant
level

303
5. After completing the tire inflation
pressure measurement and adjust-
ment, apply soap water to the
valve and check the leakage.
6. Install the tire valve cap.
If the gauge and the air pump are not
available, have your vehicle checked
by your Toyota dealer.
CAUTION
Be sure to reinstall the tire valve
caps. Without the valve caps, dirt
or moisture could get into the
valve core and cause air leakage.
If the caps have been lost, have
new ones put on as soon as pos-
sible.
Incorrect tire infl ation pressure may
waste fuel, reduce the comfort of driv-
ing, reduce tire life and make your ve-
hicle less safe to drive.
If a tire frequently needs refilling,
have it checked by your Toyota deal-
er.
CAUTION
Keep your tires properly inflated.
Otherwise, the following condi-
tions may occur and cause an ac-
cident resulting in death or seri-
ous injuries.
Low tire pressure ( underinfla-
tion)—
 Excessive wear
 Uneven wear
 Poor handling
 Possibility of blowouts from an
overheated tire
 Poor sealing of the tire bead
 Wheel deformation and/or tire
separation
 A greater possibility of tire
damage from road hazards
High tire pressure (overinfla-
tion)—
Poor handling
 Excessive wear
 Uneven wear
 A greater possibility of tire
damage from road hazards

336
Tank cap29
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel information 209
. . . . . . . . . . . . . . . . . . . . .
Fuel pump shut off system 211
. . . . . . . . . . . .
Fuse
Fuse box 314
. . . . . . . . . . . . . . . . . . . . . . . . . .
Fuse locations 291
. . . . . . . . . . . . . . . . . . . . . . .
G
Gauge
Engine coolant temperature 118 . . . . . . . . .
Engine oil pressure 119 . . . . . . . . . . . . . . . . .
Fuel 118 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Glove box 195 . . . . . . . . . . . . . . . . . . . . . . . . . . .
H
Hazard switch 110
. . . . . . . . . . . . . . . . . . . . . . .
Head restraints 46
. . . . . . . . . . . . . . . . . . . . . . .
Headlight switch 108
. . . . . . . . . . . . . . . . . . . . .
High speed operation
During break −in 209
. . . . . . . . . . . . . . . . . . . .
Hood release, Engine 27
. . . . . . . . . . . . . . . . . .
How to start the engine 236
. . . . . . . . . . . . . . .
I
Identification
Engine 221 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Vehicle 220 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
If your vehicle becomes stuck 268 . . . . . . . . .
Ignition switch 134 . . . . . . . . . . . . . . . . . . . . . . .
Ignition switch light 113 . . . . . . . . . . . . . . . . . . . Indicator symbols 7
. . . . . . . . . . . . . . . . . . . . . .
Installation with child restraint lower anchorages 94 . . . . . . . . . . . . . . . . . . .
Instrument panel
Brightness control 110 . . . . . . . . . . . . . . . . . .
Cigarette lighter and ashtray 192 . . . . . . . . .
Clock 188 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine oil pressure gauge 119 . . . . . . . . . . .
Fuel gauge 118 . . . . . . . . . . . . . . . . . . . . . . . .
Indicator symbols 7 . . . . . . . . . . . . . . . . . . . .
Odometer 121 . . . . . . . . . . . . . . . . . . . . . . . . .
Tachometer 120 . . . . . . . . . . . . . . . . . . . . . . . .
Trip meter 121 . . . . . . . . . . . . . . . . . . . . . . . . .
Instrument panel light control 110 . . . . . . . . . .
Instrument panel overview 2, 6 . . . . . . . . . . . .
Interior light 111 . . . . . . . . . . . . . . . . . . . . . . . . .
J
Jack
Location 259 . . . . . . . . . . . . . . . . . . . . . . . . . .
Jump starting 253 . . . . . . . . . . . . . . . . . . . . . . . .
K
Keys 10, 273
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
L
Light bulbs
Back −up lights 321 . . . . . . . . . . . . . . . . . . . . .
Front fog lights 318 . . . . . . . . . . . . . . . . . . . . .
Front side marker lights 319 . . . . . . . . . . . . . Front turn signal lights 319
. . . . . . . . . . . . . .
Headlights 316 . . . . . . . . . . . . . . . . . . . . . . . .
License plate lights 321 . . . . . . . . . . . . . . . . .
Parking lights 319 . . . . . . . . . . . . . . . . . . . . . .
Rear turn signal lights 321 . . . . . . . . . . . . . .
Stop and tail lights 320, 321 . . . . . . . . . . . . .
Light bulbs, Replacing 315 . . . . . . . . . . . . . . . .
Limited slip differential 220 . . . . . . . . . . . . . . . .
Load limits 230 . . . . . . . . . . . . . . . . . . . . . . . . . .
Lock
Back door 25 . . . . . . . . . . . . . . . . . . . . . . . . . .
Side doors 18 . . . . . . . . . . . . . . . . . . . . . . . . .
Steering column 134 . . . . . . . . . . . . . . . . . . .
M
Maintenance
Do −it−yourself maintenance 292 . . . . . . . . .
Does your vehicle need repairing? 287 . . .
General maintenance 285 . . . . . . . . . . . . . . .
Maintenance requirements 284 . . . . . . . . . .
Parts and tools 293 . . . . . . . . . . . . . . . . . . . . .
Where to go for service 284 . . . . . . . . . . . . .
Maximum allowable speed
Automatic transmission 135 . . . . . . . . . . . . .
Mirrors
Folding rear view 100 . . . . . . . . . . . . . . . . . . .
Outside rear view 99 . . . . . . . . . . . . . . . . . . .
Power rear view 99 . . . . . . . . . . . . . . . . . . . . .
Vanity 105 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Moon roof 31 . . . . . . . . . . . . . . . . . . . . . . . . . . . .