2005 TOYOTA AVENSIS Actuator control motor
[x] Cancel search: Actuator control motorPage 424 of 5135
±
DIAGNOSTICS SFI SYSTEM (1AZ±FSE)
05±315
AVENSIS REPAIR MANUAL (RM1018E)
\f
*
1
CHK ENG
\b
P0746 *3,4
(05±954)
Pressure Control Solenoid ºAº
Performance (Shift Solenoid
Valve SL1)
Electronic controlled automatic transmission (ECT)
P0748 *4
(05±956)
Pressure Control Solenoid ºAº
Electrical (Shift Solenoid Valve
SL1)
Electronic controlled automatic transmission (ECT)
P0766 *3,4
(05±962)
Shift Solenoid ºDº Performance
(Shift Solenoid Valve S4)Electronic controlled automatic transmission (ECT)
P0776 *3,4
(05±963)
Pressure Control Solenoid ºBº
Performance (Shift Solenoid
Valve SL2)
Electronic controlled automatic transmission (ECT)
P0778 *4
(05±956)
Pressure Control Solenoid ºBº
Electrical (Shift Solenoid Valve
SL2)
Electronic controlled automatic transmission (ECT)
P0793 *4
(05±965)
Intermediate Shaft Speed Sen-
sor ºAº Circuit No SignalElectronic controlled automatic transmission (ECT)
P0982 *4
(05±956)Shift Solenoid ºDº Control LowElectronic controlled automatic transmission (ECT)
P0983 *4
(05±956)Shift Solenoid ºDº Control HighElectronic controlled automatic transmission (ECT)
P1235
(05±477)High Pressure Fuel Pump Circuit
Open or short in fuel pump (high pressure)
Fuel pump (high pressure)
ECM
P2008
(05±480)Intake Manifold Runner Control
Circuit/Open (Bank 1) Open of short in VSV for IACV circuit
VSV for IACV
ECM
P2102
(05±483)Throttle Actuator Control Motor
Circuit Low Open in throttle control motor circuit
Throttle control motor
ECM
P2103
(05±483)Throttle Actuator Control Motor
Circuit High Short in throttle control motor circuit
Throttle control motor
ECM
P2111
(05±485)Throttle Actuator Control System
± Stuck Open Throttle control motor circuit
Throttle control motor
P2112
(05±485)Throttle Actuator Control System
± Stuck Closed Throttle body
Throttle valve
P2118
(05±487)Actuator Control Motor Current
Range/Performance Open in ETCS power source circuit
ECM
P2119
(05±490)Throttle Actuator Control Throttle
Body Range/Performance Electric throttle control system
ECM
P2120
(05±492)Throttle/Pedal Position Sensor/
Switch ºDº Circuit Open or short in accelerator pedal position sensor circuit
Accelerator pedal position sensor
ECM
P2121
(05±499)Throttle/Pedal Position Sensor/
Switch ºDº Circuit Range/Perfor-
mance Open or short in accelerator pedal position sensor circuit
Accelerator pedal position sensor
ECM
Page 606 of 5135
05±490
±
DIAGNOSTICS SFI SYSTEM(1AZ±FSE)
AVENSIS REPAIR MANUAL (RM1018E)
DTCP2119THROTTLE ACTUATOR CONTROL THROTTLE BODY RANGE/PERFORMANCE
CIRCUIT DESCRIPTION
The Electric Throttle Control System (ETCS) is composed of the throttle m\
otor that operates the throttle
valve, the throttle position sensor that detects the opening angle of the throttle valve, the accelerator pedal
position sensor that detects the accelerator pedal position, the ECM that contro\
ls the ETCS, and the one
valve type throttle body.
The ECM controls the throttle motor to provide the proper throttle valve\
opening angle in response to the
driving condition.
The throttle position sensor which is mounted on the throttle body detects \
the opening angle of the throttle
valve, and it provides feedback to the ECM to control the throttle motor.
If the ETCS has a malfunction, the ECM shuts down the power for the throttle motor, and the throttle valve
is closed by the return spring. And the throttle valve is locked at a ce\
rtain opening angle. Also, the whole
electronically controlled throttle operation is cancelled until the system returns to normal and the ignition
switch is turned OFF.
DTC No.DTC Detection ConditionTrouble Area
P2119Throttle opening angle continues to vary greatly from target
throttle opening angleElectric throttle control system
ECM
WIRING DIAGRAM
Refer to DTC P2102 on page 05±483.
INSPECTION PROCEDURE
HINT:
Read freeze frame data using the hand±held tester. Freeze frame data records the engine conditions when
a malfunction is detected. When troubleshooting, it is useful for determi\
ning whether the vehicle was running
or stopped, the engine was warmed up or not, the air±fuel ratio was lea\
n or rich, etc. at the time of the mal-
function.
1CHECK OTHER DTC OUTPUT(IN ADDITION TO DTC P2119)
(a)Read the DTC using hand±held tester.
Result:
Display (DTC output)Proceed to
Only P2119 is outputA
P2119 and other DTCs are outputB
HINT:
If any other codes besides P2119 are output, perform the troubleshooting for those DTCs first.
BGO TO RELEVANT DTC CHART (See page 05±309)
A
05CKS±01
Page 608 of 5135
A76877
ECM
+BM
FL MAINTHROTTLE Engine Room J/B No. 1 and
Engine Room R/B No. 1
E10
IE2 1A 4B15
2 Engine Room J/B No. 4
6
B±G
Battery4A1
B±G
1 1
1G±R G±Y
± DIAGNOSTICSSFI SYSTEM (1AZ±FSE)
05±487
AVENSIS REPAIR MANUAL (RM1018E)
DTC P2118 THROTTLE ACTUATOR CONTROL MOTOR
CURRENT RANGE/PERFORMANCE
CIRCUIT DESCRIPTION
If this DTC is detected, the ECM shuts down the power for the throttle motor, and the throttle valve is closed
by the return spring. And the throttle valve is locked at a certain opening angle. Also, the whole electronically
controlled throttle operation is cancelled until the system returns to normal and the ignition switch is turned
OFF.
HINT:
This electrical throttle control system (ETCS) does not use the throttle cable.
DTC No.DTC Detection ConditionTrouble Area
P2118Open in ETCS power source circuitOpen in ETCS power source circuit
ECM
WIRING DIAGRAM
05CKR±01
Page 611 of 5135
A54292
T1
Throttle Control Motor
(Built in Throttle Body)
2
1B
WECM
3
2
17M+
M±
E11
(Shielded)
E11
E11
GE01
± DIAGNOSTICSSFI SYSTEM (1AZ±FSE)
05±483
AVENSIS REPAIR MANUAL (RM1018E)
DTC P2102 THROTTLE ACTUATOR CONTROL MOTOR
CIRCUIT LOW
DTC P2103 THROTTLE ACTUATOR CONTROL MOTOR
CIRCUIT HIGH
CIRCUIT DESCRIPTION
The throttle motor is operated by the ECM and it opens and closes the throttle valve.
The opening angle of the throttle valve is detected by the throttle position sensor which is mounted on the
throttle body. It provides feedback to the ECM to control the throttle motor in order to regulate the throttle
valve opening angle properly in response to the driving condition.
If this malfunction is detected, the ECM shuts down the power for the throttle motor, and the throttle valve
is closed by the return spring. And the throttle valve is locked at a certain opening angle. Also, the whole
electronically controlled throttle operation is cancelled until the system returns to normal and the ignition
switch is turned OFF.
HINT:
This electrical throttle system does not use the throttle cable.
DTC No.DTC Detection ConditionTrouble Area
P2102
Conditions (a) and (b) continue for 2.0 seconds:
(a) Throttle control motor output duty greater than 80 %
(b) Throttle control motor current less than 0.5 AOpen in throttle control motor circuit
Throttle control motor
ECM
Throttle control motor current greater than 10 AShort in throttle control motor circuit
P2103Condition (a) continues for 0.6 seconds:
(a) Throttle control motor current greater than 7 A
Short in throttle control motor circuit
Throttle control motor
ECM
WIRING DIAGRAM
05CKP±01
Page 786 of 5135
F45132
Battery FL MAINSkid Control ECU
with Actuator
B±G (*1) L (*1)
1 ALT ABS Engine Room R/B No.4 & Engine Room J/B No.4
1
4B
W±BS2
S21 2
+BM
12
1 2
GND1 GND2
S24
W±BW±B
*1: Gasoline
*2: 1CD±FTVEA4
L (*2)
W (*2)
2 12 33 11B1ABS ALT Engine Room R/B No.3Engine Room R/B No.1 &
Engine Room J/B No.1
B (*2)
B±G (*1)
± DIAGNOSTICSABS WITH EBD SYSTEM
05±719
AVENSIS REPAIR MANUAL (RM1018E)
DTC C0273/13 OPEN OR SHORT CIRCUIT IN ABS MOTOR
RELAY CIRCUIT
CIRCUIT DESCRIPTION
The ABS motor relay supplies power to the ABS pump motor. While the ABS is activated, the ECU switches
the motor relay ON and operates the ABS pump motor.
DTC No.DTC Detecting ConditionTrouble Area
C0273/13
Detection of any conditions from 1 to 3:
1. Pump motor voltage is 2.0 V or more for 1 sec. or more
at motor relay OFF.
2. Pump motor voltage is (IG ± 4.0 V) or less for 0.1 sec. or
more at motor relay ON.
3. After the end of the actuation of the motor relay slow
down condition of motor does not meet the specification.
ABS motor relay
ABS motor relay circuit
WIRING DIAGRAM
056ST±06
Page 802 of 5135
050XB±14
05±704
±
DIAGNOSTICS ABS WITH EBD SYSTEM
AVENSIS REPAIR MANUAL (RM1018E)
DIAGNOSTIC TROUBLE CODE CHART
HINT:
Using SST 09843±18040, connect the terminal Tc and CG of the DLC3.
If malfunction is not found when inspecting parts, inspect the ECU and grou\
nd points for poor contact.
If a malfunction code is displayed during the DTC check, check the circuit\
listed for that code. For de-
tails of each code, refer to the ºSee pageº for respective ºDTC No.º\
in the DTC chart.
When 2 or more DTCs are detected, perform circuit inspection one by one unti\
l the problem is identi-
fied.
\f
\b\f
C0200/31 (05±709)Right front wheel speed sensor signal malfunction Right front speed sensor
Right front speed sensor rotor
C0205/32
(05±709)Left front wheel speed sensor signal malfunction Left front speed sensor
Left front speed sensor rotor
C0210/33
(05±713)Right rear wheel speed sensor signal malfunction Right rear speed sensor
Right rear speed sensor rotor
C0215/34
(05±713)Left rear wheel speed sensor signal malfunction Left rear speed sensor
Left rear speed sensor rotor
C0226/21
(05±717)Open or short circuit in ABS actuator solenoid (SFR) circuit SFRR or SFRH circuit
C0236/22
(05±717)Open or short circuit in ABS actuator solenoid (SFL) circuit SFLR or SFLH circuit
C0246/23
(05±717)Open or short circuit in ABS actuator solenoid (SRR) circuit SRRR or SRRH circuit
C0256/24
(05±717)Open or short circuit in ABS actuator solenoid (SRL) circuit SRLR or SRLH circuit
C0273/13
(05±719)Open or short circuit in ABS motor relay circuit ABS motor relay
ABS motor relay circuit
C0278/11
(05±722)Open or short circuit in ABS solenoid relay circuit ABS solenoid relay
ABS solenoid relay circuit
C1237/37
(05±725)Speed sensor rotor is wrong number of teeth on one of the 4
wheels Speed sensor
Sensor rotor
Speed sensor circuit
C1241/41
(05±726)Low battery voltage or abnormally high battery voltage
Battery
Charging system
Power source circuit
C1249/58
(05±730)Open circuit in stop light switch circuit Stop light switch
Stop light switch circuit
C1300/62
(05±733)Malfunction in skid control ECU Battery
Skid control ECU
C1330/35
(05±709)Open circuit in right front speed sensor Right front speed sensor
Right front speed sensor circuit
C1331/36
(05±709)Open circuit in left front speed sensor Left front speed sensor
Left front speed sensor circuit
C1332/38
(05±713)Open circuit in right rear speed sensor Right rear speed sensor
Right rear speed sensor circuit
C1333/39
(05±713)Open circuit in left rear speed sensor Left rear speed sensor
Left rear speed sensor circuit
C1350 / 51
(05±735)Pump motor is locked
Open circuit in pump motor ground Brake actuator pump motor
Always ON
(05±737)Malfunction in ECU
Battery
Charging system
ABS warning light circuit
Power source circuit
Skid control ECU
Page 813 of 5135
0542Q±04
05±766
±
DIAGNOSTICS ABS WITH EBD & BA & TRC & VSC SYSTEM
AVENSIS REPAIR MANUAL (RM1018E)
DIAGNOSTIC TROUBLE CODE CHART
HINT:
Using SST 09843±18040, connect the terminal Tc and CG of the DLC3.
If malfunction is not found when inspecting parts, inspect the ECU and grou\
nd points for poor contact.
If a malfunction code is displayed during the DTC check, check the circuit\
listed for that code. For de-
tails of each code, refer to the ºSee pageº for respective ºDTC No.º\
in the DTC chart.
When 2 or more DTCs are detected, perform circuit inspection one by one unti\
l the problem is identi-
fied.
DTC chart of ABS system:
DTC No.
(See Page)Detection ItemTrouble Area
C0200 / 31 (05±774)Right front wheel speed sensor signal malfunction
Right front speed sensor
Right front speed sensor circuit
Right front speed sensor rotor
C0205 / 32
(05±774)Left front wheel speed sensor signal malfunction
Left front speed sensor
Left front speed sensor circuit
Left front speed sensor rotor
C0210 / 33
(05±778)Right rear wheel speed sensor signal malfunction
Right rear speed sensor
Right rear speed sensor circuit
Right rear speed sensor rotor
C0215 / 34
(05±778)Left rear wheel speed sensor signal malfunction
Left rear speed sensor
Left rear speed sensor circuit
Left rear speed sensor rotor
C0226 / 21
(05±782)Open or short circuit in brake actuator Brake actuator
SFRR or SFRH circuit
C0236 / 22
(05±782)Open or short circuit in brake actuator Brake actuator
SFLR or SFLH circuit
C0246 / 23
(05±782)Open or short circuit in brake actuator Brake actuator
SRRR or SRRH circuit
C0256 / 24
(05±782)Open or short circuit in brake actuator Brake actuator
SRLR or SRLH circuit
C0273 / 13
(05±784)Open or short circuit in ABS motor relay circuit ABS motor relay
ABS motor relay circuit
C0278 / 11
(05±787)Open or short circuit in ABS solenoid relay circuit ABS solenoid relay
ABS solenoid relay circuit
C1237 / 37
(05±807)Wrong tire size Tire size
Speed sensor rotor
C1241 / 41
(05±808)Low battery positive voltage or abnormally high battery positive
voltage Battery
Charging system
Power source circuit
C1249 / 58
(05±815)Open circuit in stop light switch circuit Stop lamp switch
Stop lamp switch circuit
C1300 / 62
(05±819)Malfunction in skid control ECU Battery
Skid control ECU
C1330 / 35
(05±774)Open circuit in right front speed sensor circuit Right front speed sensor
Right front speed sensor circuit
C1331 / 36
(05±774)Open circuit in left front speed sensor circuit Left front speed sensor
Left front speed sensor circuit
C1332 / 38
(05±778)Open circuit in right rear speed sensor circuit Right rear speed sensor
Right rear speed sensor circuit
Page 814 of 5135
±
DIAGNOSTICS ABS WITH EBD & BA & TRC & VSC SYSTEM
05±767
AVENSIS REPAIR MANUAL (RM1018E)C1333 / 39
(05±778)
Open circuit in left rear speed sensor circuit Left rear speed sensor
Left rear speed sensor circuit
Always ON
(05±827)Malfunction in skid control ECU
Open circuit in ABS warning light circuit
Battery
Charging system
Power source circuit
Skid control ECU
DTC chart of VSC system:
DTC No.
(See Page)Detection ItemTrouble Area
C0365 / 43 (05±790)Malfunction in lateral acceleration sensor (combined in yaw
rate sensor) Yaw rate sensor
Yaw rate sensor circuit
C0371 / 55
(05±793)Malfunction in yaw rate sensor circuit Yaw rate sensor
Yaw rate sensor circuit
C1224 / 44
(05±797)Open or short circuit in NE signal circuit
NEO circuit
ECM
Skid control ECU
C1201/45
(05±796)VSC shut down due to ECM failure ECM
C1203 / 59
(05±799)ECM communication circuit malfunction
TRC+ or TRC± circuit
ENG+ or ENG± circuit
ECM
C1208 / 54
(05±801)Malfunction in steering angle sensor Steering angle sensor
Steering angle sensor circuit
C1225 / 25
(05±805)Open or short circuit in brake actuator solenoid circuit (SMC1
circuit) Brake actuator
SMC1 circuit
C1226 / 26
(05±805)Open or short circuit in brake actuator solenoid circuit (SMC2
circuit) Brake actuator
SMC2 circuit
C1227 / 27
(05±805)Open or short circuit in brake actuator solenoid circuit (SRC1
circuit) Brake actuator
SRC1 circuit
C1228 / 28
(05±805)Open or short circuit in brake actuator solenoid circuit (SRC2
circuit) Brake actuator
SRC2 circuit
C1246 / 53
(05±812)Malfunction in master cylinder pressure sensor Master cylinder pressure sensor
Master cylinder pressure sensor circuit
C1288 / 88
(05±818)Malfunction in ECM version Steering angle sensor zero point calibration
C1301 / 42
(05±821)Malfunction in CAN communication circuit
(steering angle sensor circuit, yaw rate sensor circuit) Steering angle sensor circuit
Yaw rate sensor circuit
C1350 / 51
(05±825)Pump motor is locked
Open circuit in pump motor ground Brake actuator pump motor
Always ON
(05±831)Malfunction in skid control ECU
Open circuit in VSC warning light circuit
Battery
Charging system
Power source circuit
Skid control ECU