2005 SUBARU OUTBACK maintenance schedule

11 - 2 4
Maintenance and service
Air cleaner element
Do not operate the engine with the air cleaner
element removed. The air cleaner element not
only filters intake air but also stops flames if the
engine backfires. If the air cleaner element is
not installed when the engine backfires, you
could be burned.
The air cleaner element functions as a filter screen.
When the element is perforated or removed, engine
wear will be excessive and engine life shortened.
The air cleaner element is a dry type. It is unnecessary
to clean or wash the element. ! Replacing the air cleaner element
Replace the air cleaner element according to the
maintenance schedule in the “Warranty and Mainte-
nance Booklet”. Under extremely dusty conditions, re-
place it more frequently. It is recommended that you
always use genuine SUBARU parts. !
Non-turbo models
0
A) Connector
B) Duct
C) Clamp
1. Unplug the connector that is attached to the top of
the air cleaner case.
2. Remove the hose that is located at the bottom of
the side surface of the air cleaner case.
3. Undo the screw and pull the air duct out of the air
cleaner case.
4. Unsnap the two clamps holding the air cleaner
case cover.
A
C
BUBB512CB

11 -2 9
Maintenance and service
– CONTINUED –
Spark plugs
"When disconnecting the spark plug cables,
always grasp the spark plug cap, not the ca-
bles. " Make sure the cables are replaced in the cor-
rect order.
It may be difficult to replace the spark plugs. It is rec-
ommended that you have the spark plugs replaced by
your SUBARU dealer. The spark plugs should be replaced according to the
maintenance schedule in the “Warranty and Mainte-
nance Booklet”. !
Recommended spark plugs
2.5-liter non-turbo models:
FR5AP-11 (NGK)
2.5-liter turbo and 3.0-liter models:
ILFR6B (NGK)
HSB032BA

11 -4 5
Maintenance and service
– CONTINUED –
Brake pedal
Check the brake pedal free play and reserve distance
according to the maintenance schedule in the “War-
ranty and Maintenance Booklet”. !Checking the brake pedal free play
A) 0.02 – 0.08 in (0.5 – 2.0 mm)
Stop the engine and firmly depress the brake pedal
several times. Lightly pull the brake pedal up with one
finger to check the free play with a force of less than 2
lbs (10 N, 1 kg).
If the free play is not within proper specification, con- tact your SUBARU dealer. !
Checking the brake pedal reserve dis-
tance
A) More than 2.56 in (65 mm)
Depress the pedal with a force of approximately 66 lbs
(294 N, 30 kg) and measure the distance between the
upper surface of the pedal pad and the floor.
When the measurement is smaller than the specifica-
tion, or when the pedal does not operate smoothly,
contact with your SUBARU dealer.
A
HSB049BC
A
HSB050BC

11 - 4 6
Maintenance and service
Clutch pedal (Manual transmission
vehicles)
Check the clutch pedal free play and reserve distance
according to the maintenance schedule in the “War-
ranty and Maintenance Booklet”. !
Checking the clutch function
Check the clutch engagement and disengagement.
1. With the engine idling, check that there are no ab-
normal noises when the clutch pedal is depressed,
and that shifting into 1st or reverse feels smooth.
2. Start the vehicle by releasing the pedal slowly to
check that the engine and transmission smoothly cou-
ple without any sign of slippage. !
Checking the clutch pedal free play
A) 0.16 – 0.51 in (4.0 – 13.0 mm)
Lightly press the clutch pedal down with your finger
until you feel resistance, and check the free play.
If the free play is not within proper specification, con-
tact your SUBARU dealer.
A
HSB049BC

11 - 4 8
Maintenance and service
may cause the rear wheels to lock. To avoid
this, be certain to pull the lever up slowly and
gently.
1. Drive the vehicle at a speed of about 22 mph (35
km/h).
2. With the parking brake release button pushed in,
pull the parking brake lever SLOWLY and GENTLY.
(Pulling with a force of approximately 33 lbs [147 N, 15 kg].)
3. Drive the vehicle for about 220 yards (200 meters)
in this condition.
4. Wait 5 to 10 minutes for the parking brake to cool
down. Repeat this procedure.
5. Check the parking brake stroke. If the parking
brake stroke is out of the specified range, adjust it by
turning the adjusting nut located on the parking brake
lever.
Parking brake stroke:
5 – 6 notches / 44 lbs (196 N, 20 kg)
Parking brake stroke
Check the parking brake stroke according to the main-
tenance schedule in the “Warranty and Maintenance
Booklet”. When the parking brake is properly adjusted,
braking power is fully applied by pulling the lever up
five to six notches gently but firmly (about 44 lbs, 196
N, 20 kg). If the parking brake lever stroke is not within the specified range, have the brake system checked
and adjusted at your SUBARU dealer.
UBB568BA

14-6
Index
K Key
Keyless entry system .................................... 2-12
Number ........................................................... 2-3
Reminder chime ............................................. 3-6
Keys .................................................................... 2-2 L
Leather seat materials ....................................... 10-6
Light Cargo area ..................................................... 6-3
Control switch ............................................... 3-44
Dome .............................................................. 6-2
Map ................................................................ 6-3
Light control switch ............................................ 3-44
Limited slip differential (LSD) ............................ 7-36
Loading your vehicle ......................................... 8-18
Low fuel warning light ...................... 3-13, 3-19, 3-30
LSD (Limited slip differential) ............................ 7-36
Lumbar support ................................................... 1-9 M
Main fuse ......................................................... 11-71
Maintenance Precautions .................................................. 11-3
Schedule ...................................................... 11-3 Seatbelt ........................................................ 1-33
Tools ............................................................. 9-33
Manual Climate control system ................................... 4-4
Mode ................................................... 7-20, 7-30
Seat ................................................................ 1-3
Transmission ................................................ 7-13
Transmission oil ......................................... 11-31
Map light ................................................... 6-3, 11-83
Maximum load limits .......................................... 8-31
Meters and gauges ........................................... 3-14
Mirrors ............................................................... 3-59
Moonroof .................................................. 2-41, 9-30 N
New vehicle break-in driving – the first 1,000 miles (1,600 km) .............................................. 8-2
O
Odometer ............................................................ 3-9
Off road driving .................................................... 8-9
Oil filter ............................................................ 11-13
Oil level Engine ........................................................ 11-12
Front differential gear (AT vehicles) ........... 11-35
Manual transmission .................................. 11-31
Rear differential .......................................... 11-37