2005 SUBARU LEGACY clutch

11 - 1 0
Maintenance and service !
2.5-liter turbo models
12 4 6
35
13 12 11 10 9 8 7
UBB203BB
1) Power steering fluid reservoir (page 11-41)
2) Manual transmission oil level gauge (MT) (page 11-31) or Dif-
ferential gear oil level gauge
(AT) (page 11-35)
3) Clutch fluid reservoir (page 11-
43)
4) Brake fluid reservoir (page 11- 42)
5) Automatic transmission fluid lev- el gauge (page 11-33)
6) Fuse box (page 11-68)
7) Battery (page 11-67)
8) Windshield washer tank (page 11-58)
9) Engine oil filler cap (page 11-12)
10) Engine coolant reservoir (page 11-19)
11) Engine oil level gauge (page 11- 12)
12) Radiator cap (page 11-19)
13) Air cleaner element (page 11- 24)

11 -4 3
Maintenance and service
– CONTINUED –
faces or rubber parts. Alcohol contained in the
brake fluid may damage them.
Check the fluid level monthly.
Check the fluid level on the outside of the reservoir. If
the level is below “MIN”, add the recommended brake
fluid to “MAX”.
Use only brake fluid from a sealed container. ! Recommended brake fluid
FMVSS No. 116, fresh DOT 3 or 4 brake fluid
Clutch fluid (MT vehicles) !Checking the fluid level
Never let clutch fluid contact your eyes be-
cause clutch fluid can be harmful to your eyes.
If clutch fluid gets in your eyes, immediately
flush them thoroughly with clean water. For
safety, when performing this work, wearing eye
protection is advisable.
"Clutch fluid absorbs moisture from the air.
Any absorbed moisture can cause improper
clutch operation." If the vehicle requires frequent refilling, there
may be a leak. If you suspect a problem, have
the vehicle checked at your SUBARU dealer." Never use different brands of clutch fluid to-
gether. " When clutch fluid is added, be careful not to
allow any dirt into the tank.
UBB565BA

11 - 4 4
Maintenance and service
Check the fluid level on the outside of the reservoir. If
the level is below “MIN” level mark, add the recom-
mended clutch fluid to “MAX” level mark.
Use only clutch fluid from a sealed container. !
Recommended clutch fluid
FMVSS No. 116, fresh DOT 3 or 4 brake fluid
Brake booster
If the brake booster does not operate as described be-
low, have it checked by your SUBARU dealer.
1. With the engine off, depress the brake pedal sever-
al times, applying the same pedal force each time. The
distance the pedal travels should not vary.
2. With the brake pedal depressed, start the engine.
The pedal should move slightly down to the floor.
3. With the brake pedal depressed, stop the engine
and keep the pedal depressed for 30 seconds. The
pedal height should not change.
4. Start the engine again and run for about one minute
then turn it off. Depress the brake pedal several times
to check the brake booster. Brake booster operates
properly if the pedal stroke decreases with each de-
pression.
UBB566BA

11 - 4 6
Maintenance and service
Clutch pedal (Manual transmission
vehicles)
Check the clutch pedal free play and reserve distance
according to the maintenance schedule in the “War-
ranty and Maintenance Booklet”. !
Checking the clutch function
Check the clutch engagement and disengagement.
1. With the engine idling, check that there are no ab-
normal noises when the clutch pedal is depressed,
and that shifting into 1st or reverse feels smooth.
2. Start the vehicle by releasing the pedal slowly to
check that the engine and transmission smoothly cou-
ple without any sign of slippage. !
Checking the clutch pedal free play
A) 0.16 – 0.51 in (4.0 – 13.0 mm)
Lightly press the clutch pedal down with your finger
until you feel resistance, and check the free play.
If the free play is not within proper specification, con-
tact your SUBARU dealer.
A
HSB049BC

14-3
Index
Bulb
Chart ........................................................... 12-10
Replacing .................................................... 11-73
C
Capacities .......................................................... 12-4
Cargo area Cover ............................................................ 6-23
Light ................................................................ 6-3
Tie-down hooks ............................................ 6-29
Catalytic converter ............................................... 8-4
Center Console .......................................................... 6-8
Ventilators ....................................................... 4-3
Changing
Flat tire ............................................................ 9-5
Oil and oil filter ............................................ 11-13
Charge warning light ......................................... 3-26CHECK ENGINE warning light/Malfunction
indicator lamp ................................................ 3-25
Checking
Brake pedal free play .................................. 11-45
Brake pedal reserve distance ..................... 11-45
Clutch function ............................................ 11-46
Clutch pedal free play ................................. 11-46
Engine oil level ........................................... 11-12
Fluid level ................. 11-33, 11-41, 11-42, 11-43 Gear oil level ............................................... 11-37
Child restraint systems ...................................... 1-38
Installation with seatbelt ............................... 1-42
Lower and tether anchorages ....................... 1-49
Child safety ............................................................. 7
Locks ............................................................ 2-30
Chime
Key ................................................................. 3-6
Seatbelt ........................................................ 1-19
Cigarette lighter socket ...................................... 6-16
Cleaning
Aluminum wheels ......................................... 10-4
Interior .......................................................... 10-6
Ventilator grille .............................................. 4-17
Climate control system Automatic ...................................................... 4-10
Manual ............................................................ 4-4
Clock ................................................................. 3-36
Clutch Fluid ............................................................ 11-43
Pedal .......................................................... 11-46
Coat hook .......................................................... 6-20
Cooling system ................................................ 11-18
Corrosion protection ................................. 8-14, 10-4
Cruise control .................................................... 7-53
Set indicator light .......................................... 3-35

14-4
Index
Cup holder
Front passenger’s ......................................... 6-12
Rear passenger’s ......................................... 6-13
D
Daytime running light system ............................ 3-46
Differential gear oil Front ........................................................... 11-35
Rear ............................................................ 11-37
Dimensions ........................................................ 12-2
Disarming the system ........................................ 2-26
Disc brake pad wear warning indicators ............ 7-38
Dome light ................................................ 6-2, 11-82
Door locks ........................................................... 2-6
Door open warning light .................................... 3-31
Drive belts ....................................................... 11-30
Driving All-wheel drive vehicle .................................. 3-31
Car phone/mobile phone ................................. 10
Drinking ............................................................. 9
Drugs ................................................................. 9
Foreign countries ............................................ 8-7
Pets ................................................................. 11
Snowy and icy roads .................................... 8-13
Tips ..................................... 7-15, 7-23, 7-33, 8-7
Tired or sleepy ................................................. 10 E
Electrical system ............................................... 12-3
Electronic Brake Force Distribution (EBD)
system ........................................................... 7-41
Emergency Locking Retractor (ELR) ................ 1-18
Engine
Compartment overview ................................ 11-8
Coolant ....................................................... 11-19
Exhaust gas (Carbon monoxide) ................ 8, 8-3
Hood ............................................................. 11-5
Oil ............................................................... 11-12
Overheating .................................................. 9-20
Starting ......................................................... 7-10
Stopping ....................................................... 7-12
Exterior care ...................................................... 10-2 F
Flat tires .............................................................. 9-5
Floor mat ........................................................... 6-22
Fluid level
Automatic transmission .............................. 11-33
Brake .......................................................... 11-42
Clutch ......................................................... 11-43
Power steering ........................................... 11-41
Fog light switch ................................................. 3-50
Front
Differential gear oil ..................................... 11-35

14-7
Index
Oil pressure warning light .................................. 3-26
Outside mirrors .................................................. 3-61
Outside temperature indicator ........................... 3-37
Overheating engine ........................................... 9-20 P
Parking
Brake stroke ............................................... 11-48
Light switch ................................................... 3-49
Periodic inspection .............................................. 8-6 Power Door locking switches ................................... 2-10
Seat ................................................................ 1-5
Steering fluid ............................................... 11-41
Windows ....................................................... 2-31
Precautions against vehicle modification .. 1-37, 1-92
Preparing to drive .............................................. 7-10
Printed antenna ................................................... 5-2 R
Rear Combination lights ...................................... 11-76
Differential gear oil ...................................... 11-37
Gate .............................................................. 2-39
Seats ............................................................ 1-11
Rear seat
Folding down (Station wagon) ...................... 1-12 Rear window
Defogger button ............................................ 3-57
Wiper and washer switch .............................. 3-55
Recommended
Automatic transmission fluid ....................... 11-35
Brake fluid ................................................... 11-43
Clutch fluid .................................................. 11-44
OIL grade and viscosity ....... 11-16, 11-17, 11-32, 11-36, 11-40
Power steering fluid .................................... 11-42
Spark plugs ................................................. 11-29
Remote keyless entry system ........................... 2-12
Replacement Brake pad and lining ................................... 11-47
Wiper blades ............................................... 11-60
Replacing
Air cleaner element ..................................... 11-24
Battery (remote keyless entry system) ......... 2-16
Lost transmitters (keyless entry system) ...... 2-17
Replacing bulbs ............................................... 11-73 Cargo area light .......................................... 11-85
Dome light .................................................. 11-82
Door step light ............................................ 11-84
Front fog light .............................................. 11-76
Front turn signal light .................................. 11-76
Headlight .................................................... 11-74
High mount stop light .................................. 11-86