2005 SKODA OCTAVIA radiator

Starting-off and Driving
142
Caution
you should not switch the engine off right away at the end of your journey
after the engine has been operated for a lengthy period at high loads but
should be allowed it to run at idling speed for about 2 minutes. This
prevents any accumulation of heat when the engine is switched off.
Note
•The radiator fan may continue running for a further 10 minutes or so
after the engine and the ignition have been switched off. The coolant fan
may, however, also switch on again after some time if the coolant temper-
ature rises because of an accumulation of heat in the engine or if the
engine is warm and the engine compartment is additionally heated by
strong sunlight.
•This is why particular care is required when carrying out any work in
the engine compartment ⇒page 248, “Working in the engine
compartment”.
Shifting (manual gearbox)
Shift into reverse only when the car is stationary. Depress the clutch pedal
and hold it fully depressed. Wait a moment before engaging reverse gear
in order to avoid any shift noises.
The reversing lights will come on once reverse gear is engaged, provided
the ignition is on.
WARNING
Never engage the reverse gear when driving - risk of accident!
Note
•One should not lay the hand on the shift lever while driving the vehicle.
The pressure of the hand will be transferred to the gearshift forks in the
gearbox. This can, over a period of time, lead to early wear of the gearshift
forks.
Fig. 130 The shift
pattern: 5-speed or 6-
speed manual gearbox
s24s.book Page 142 Thursday, November 24, 2005 12:27 PM

Inspecting and Replenishing247
Using the systemSafetyDriving TipsGeneral MaintenanceBreakdown assistanceTechnical Data
Inspecting and Replenishing
Engine compartment
Bonnet remote release
Bonnet remote release
– Pull the unlocking lever below the dash panel on the driver's
side ⇒fig. 189 .
The bonnet jumps out of its lock as a result of the spring force. A handle
appears at the same time in the radiator grille.
Opening and closing the bonnet.
Fig. 189 Bonnet
release lever
Fig. 190 Radiator
grille: handle
Fig. 191 Securing the
bonnet with the bonnet
support
s24s.book Page 247 Thursday, November 24, 2005 12:27 PM

Inspecting and Replenishing
248
Opening the bonnet
– Unlock the bonnet ⇒page 247, fig. 189 .
– Ensure that the arms of the windscreen wipers are correctly in place against the windscreen before opening the bonnet
otherwise damage could occur to the paintwork.
– Pulling on the handle ⇒page 247, fig. 190 will lock the bonnet
fully.
– Grip with the hand under the radiator grille and lift up the bonnet.
– Take the bonnet support out of its holder and set it in the opening designed for it ⇒page 247, fig. 191.
Closing the bonnet
– Lift the bonnet slightly and unhook the bonnet support. Press the bonnet support into the holder designed to hold it.
– Allow the bonnet to drop from a height of about 30 cm into the lock - bonnet do not press down on it !
WARNING
•Never open the bonnet if you see that steam or coolant is
flowing out of the engine compartment - risk of scalding! Wait long
enough until the steam or coolant has stopped escaping.
•For safety reasons, the bonnet must always be properly closed
when driving. One should therefore check that the lock has in fact
engaged properly after closing the bonnet.
•Stop your vehicle immediately whil e driving if you notice that
the lock is not properly engaged and close the bonnet properly -
risk of an accident!
Caution
Never open the bonnet using the handle - danger of causing damage.
Working in the engine compartment
Particular care is required when carrying out any work in
the engine compartment!
There is a risk of injuries, scalding, accidents and fire when working
in the engine compartment, e.g. inspecting and replenishing oil and
other fluids. For this reason, it is essential to comply with the
warning instructions stated below and with the general applicable
rules of safety. The engine compartment of your car is a hazardous
area ⇒ .
WARNING
•Never open the bonnet if you see that steam or coolant is
flowing out of the engine compartment - risk of scalding! Wait long
enough until the steam or coolant has stopped escaping.
•Switch off the engine and pull out the ignition key.
•Apply the handbrake firmly.
•If your vehicle is fitted with a manual gearbox, move the gear-
shift lever into Neutral, or if it is fitted with automatic gearbox,
move the selector lever into position P.
WARNING (continued)
s24s.book Page 248 Thursday, November 24, 2005 12:27 PM

Inspecting and Replenishing249
Using the systemSafetyDriving TipsGeneral MaintenanceBreakdown assistanceTechnical Data
•Allow the engine to cool down.
•Keep children clear of the engine compartment.
•Never spill oil and other fluids over the hot engine. Such fluids
(e.g. the antifreeze contained in the coolant) may ignite!
•Avoid short circuits in the electrical system - particularly on the
battery.
•Never place your hand into the radiator fan as long as the
engine is still warm. The fan might suddenly start running!
•Never open the cap of the coolant expansion bottle as long as
the engine is still warm. The cooling system is pressurized!
•Cover over the cap of the coolant expansion reservoir with a
large cloth when opening it as protection for your face, hands and
arms from hot steam or hot coolant.
•Do not let objects, such as e.g cleaning cloth or tools lie in the
engine compartment.
•If you wish to work under the vehicle, you must secure the
vehicle from rolling away and support it with suitable supporting
blocks: the car jack is not sufficient for this - risk of injury!
•In cases where it be necessary to carry out inspection work
when the engine is running there is an additional risk from rotating
parts (e.g. the V-ribbed belt, alternator, radiator fan) and from the
high-voltage ignition system. Please observe in addition the
following:
−Never touch the electrical cables of the ignition system.
− Absolutely avoid any jewellery, loose items of clothing or
long hair from getting into the rotating parts of the engine -
Hazard! Therefore remove any jewellery beforehand, tie up your
hair and wear tight fitting clothing.
•Please also comply with the warning instructions stated below
when carrying out any essential work on the fuel system or on the
electrical system:
−Always separate the car battery from the electrical system.
− Do not smoke.
− Never carry out any work close to naked flames.
− Always keep a working fi re extinguisher at hand.
Caution
When replenishing fluids in the engine, always ensure that the fluids are
on no account mixed up. This may result in major operating problems and
also vehicle damage!
WARNING (continued)WARNING (continued)
s24s.book Page 249 Thursday, November 24, 2005 12:27 PM

Inspecting and Replenishing
256
Caution
Do not continue your journey if for some reason it is not possible
under the conditions prevailing to top up with coolant. Switch of the
engine and contact and obtain professional assistance from a specialist
garage.
For the sake of the environment
Do not re-use coolant if it is necessary to drain the coolant in the system.
It should be collected and disposed of in compliance with environmental
protection regulations.
The radiator fan
The radiator fan may switch on suddenly.
The radiator fan is driven by an electric motor and controlled according to
the coolant temperature.
The radiator fan may continue running for up to 10 minutes after the
engine has been switched off - even if the ignition is also off. It may also
switch on suddenly after a certain time, if
•the coolant temperature has risen because of an accumulation of heat
or
•the warm engine compartment is heated up additionally by strong
sunlight.
WARNING
You must therefore be aware when working in the engine compart-
ment that the fan may switch on suddenly - risk of injury!
Brake fluid
Inspecting the brake fluid level
The brake fluid reservoir is located on the left of the engine
compartment. The brake fluid reservoir on right-hand steering
models is positioned on the other side of the engine compart-
ment.
– Switch the engine off.
– Open the bonnet ⇒ in “Working in the engine compart-
ment” on page 248.
– Inspect the brake fluid level in the reservoir ⇒fig. 195 . The
level must be between the “MIN” and “MAX” markings.
Fig. 195 Engine
compartment: Brake
fluid reservoir
s24s.book Page 256 Thursday, November 24, 2005 12:27 PM

Inspecting and Replenishing
262
We recommend that you only have an old battery disposed of by your
Škoda dealer since it does require special disposal.
For the sake of the environment
Batteries contain poisonous substances such as sulphuric acid and lead.
They must be disposed of in accordance with local environmental protec-
tion regulations and on no account as domestic waste.
Windscreen Wiper and Washer System
The windshield washer reservoir contains the cleaning fluid for the wind-
screen or rear window and for the headlamp cleaning system*. The reser-
voir is located at the front right of the engine compartment ⇒fig. 198 .
The filling level of the container is 3 litres, 5.5 litres on vehicles which also
have a headlight washing system. Clear water is not sufficient to intensively clean the windscreen and head-
lights. We therefore recommend using clean washing water together with
the screen cleaner from Škoda genuine accessories (in winter additionally
with antifreeze) which is capable of removing stubborn dirt. Follow the
instructions for use on the packaging when using screen cleaning prod-
ucts.
You should always add antifreeze to the cleaning water in winter even if
your vehicle is fitted with heated windscreen washer nozzles*.
It is also possible in exceptional cases to use methylated spirits when no
screen cleaner with antifreeze is available. The concentration of methyl-
ated spirits must not be more than 15 %. Please note, however, that the
antifreeze protection at this concentration is only adequate down to -5°C.
WARNING
Read and observe the warning notes ⇒
page 248, “Working in the
engine compartment” before working in the engine compartment.
Caution
•On no account should you add radiator antifreeze or other additives to
the windscreen washer fluid.
•If the vehicle is fitted with headlight cleaning system, you should only
add cleaning products which do not attack the polycarbonate coating of
the headlights to the windscreen washer fluid. Please contact your Škoda
dealer, who will tell you which cleaning agent you can use.
Note
Do not take the filter out of the windscreen wash container when filling it
up again with liquid otherwise dirt can get into the liquid transportation
system and can lead to faults in operation of the windscreen wash
system.
Fig. 198 Engine
compartment: Wind-
shield washer fluid
reservoir
s24s.book Page 262 Thursday, November 24, 2005 12:27 PM

Fuses and light bulbs291
Using the systemSafetyDriving TipsGeneral MaintenanceBreakdown assistanceTechnical Data
Fuse assignment in engine compartment - version 2
F23Engine control unit10
F24Control unit for CAN databus5
F25Not assigned
F26Not assigned
F27Not assigned
F28Engine control unit25
F29Actuation for coolant pump after-running5
F30Control unit for auxiliary heating20
F31Front window wiper30
F32Not assigned
F33Not assigned
F34Not assigned
F35Not assigned
F36Not assigned
F37Not assigned
F38Radiator fan, valves10
F39Clutch pedal switch, brake pedal switch5
F40Ignition coils20
F41Not assigned
F42Actuation of fuel pump5
F43Not assigned
F44Not assigned
F45Not assigned
F46Not assigned
No.Power consumerAmperes
F47Central control unit, Left main headlights40
F48Central control unit, Right main headlights40
F49Power supply for terminal 15 (ignition on)40
F50Not assigned
F51Not assigned
F52Power supply relay - terminal X a)40
F53Accessory equipment50
F54Not assigned
a)In order not to drain the battery unnecessarily when starting the engine, the elec-
trical components of this terminal are automatically switched off.
No.Power consumerAmperes
Fig. 220 Schematic
representation of fuse
box in engine compart-
ment - version 2
s24s.book Page 291 Thursday, November 24, 2005 12:27 PM

Index
310
The air conditioning system . . . . . . . . . . . . 123
Air outlet vents . . . . . . . . . . . . . . . . . . . 127
Defrosting windows . . . . . . . . . . . . . . . . 125
Recirculated air mode . . . . . . . . . . . . . . 126
The armrest at the rear . . . . . . . . . . . . . . . . . 91
The automatic wiper/washer system . . . . . . 75
The battery . . . . . . . . . . . . . . . . . . . . . . 40, 258 changing . . . . . . . . . . . . . . . . . . . . . . . . 261
Charge . . . . . . . . . . . . . . . . . . . . . . . . . 260
Inspecting the electrolyte level . . . . . . . 260
Operation in winter . . . . . . . . . . . . . . . . 260
The CD changer . . . . . . . . . . . . . . . . . . . . . 176
The electronic immobiliser . . . . . . . . . . . 32, 45
The outside temperature . . . . . . . . . . . . . . . . 20
The radiator fan . . . . . . . . . . . . . . . . . . . . . 256
The roof luggage rack system . . . . . . . . . . 102
Thickness of brake pads Warning light . . . . . . . . . . . . . . . . . . . . . . 36
Tilting roof . . . . . . . . . . . . . . . . . . . . . . . . . . . 59
Tiptronic . . . . . . . . . . . . . . . . . . . . . . . . . . . 149 automatic gearbox DSG . . . . . . . . . . . . 160
Tool . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 274
Towing a trailer . . . . . . . . . . . . . . . . . . . . . . 229
Towing a vehicle . . . . . . . . . . . . . . . . . . . . . 283
Towing device . . . . . . . . . . . . . . . . . . . . . . . 231
Towing protection monitoring . . . . . . . . . . . . 55
Tow-starting a vehicle . . . . . . . . . . . . . . . . . 283
Tow-starting and towing vehicle Automatic gearbox . . . . . . . . . . . . 155, 162
Traction Control System . . . . . . . . . . . . . . . 215 Traction control system (TCS)
Warning light . . . . . . . . . . . . . . . . . . . . . . 39
Trailer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 229 General Maintenance . . . . . . . . . . . . . . 229
Transporting children . . . . . . . . . . . . . . . . . 202
Tread depth . . . . . . . . . . . . . . . . . . . . . . . . . 265
Turn signal lights . . . . . . . . . . . . . . . . . . . . . . 68
Turn signals . . . . . . . . . . . . . . . . . . . . . . . . . 68 Warning light . . . . . . . . . . . . . . . . . . . . . . 32
Two-way radio systems . . . . . . . . . . . . . . . 175
Type plate . . . . . . . . . . . . . . . . . . . . . . . . . . 303
Tyres . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 264 Winter tyres . . . . . . . . . . . . . . . . . . . . . . 268
U
Underbody protection . . . . . . . . . . . . . . . . . 238
Unlocking . . . . . . . . . . . . . . . . . . . . . . . . . . . 46Remote control . . . . . . . . . . . . . . . . . . . . 52
Uphill-Start off-Assist . . . . . . . . . . . . . . . . . 219
V
Vanity mirror . . . . . . . . . . . . . . . . . . . . . . . . . 73
Vehicle condition . . . . . . . . . . . . . . . . . . . . . . 26
Vehicle data sticker . . . . . . . . . . . . . . . . . . . 303
Vehicle immobiliser . . . . . . . . . . . . . . . . . . . . 45 Warning light . . . . . . . . . . . . . . . . . . . . . . 32
Vehicle tool kit . . . . . . . . . . . . . . . . . . . . . . . 274
Ventilation Auxiliary ventilation . . . . . . . . . . . . . . . . 134 Visors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 73
W
Warning lights . . . . . . . . . . . . . . . . . . . . . . . . 30
Warning symbols . . . . . . . . . . . . . . . . . . . . . . 30
Warning triangle . . . . . . . . . . . . . . . . . . . . . 273
Washing . . . . . . . . . . . . . . . . . . . . . . . . . . . 234
with high-pressure cleaner . . . . . . . . . . . 235
Washing the vehicle . . . . . . . . . . . . . . . . . . 233
Washing vehicle by hand . . . . . . . . . . . . . . 234
Wax treatment . . . . . . . . . . . . . . . . . . . . . . . 235
Wheel Changing . . . . . . . . . . . . . . . . . . . . . . . . 276
Spare . . . . . . . . . . . . . . . . . . . . . . . . . . . 275
Wheel bolts . . . . . . . . . . . . . . . . . . . . . . . . . 267
Wheel rims . . . . . . . . . . . . . . . . . . . . . . . . . 263
Wheel trim . . . . . . . . . . . . . . . . . . . . . . . . . . 278
Wheels . . . . . . . . . . . . . . . . . . . . . . . . . . . . 263
Window . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 56 De-icing . . . . . . . . . . . . . . . . . . . . . . . . . 236
Window lifter . . . . . . . . . . . . . . . . . . . . . . . . . 56
Windows De-icing . . . . . . . . . . . . . . . . . . . . . . . . . 236
Windscreen washer nozzles . . . . . . . . . . . . . 75
Windscreen Wiper and Washer System . . . 262 Warning light . . . . . . . . . . . . . . . . . . . . . . 36
Windscreen wipers . . . . . . . . . . . . . . . . . . . . 75
Windshield washer fluid reservoir . . . . . . . . 262 Warning light . . . . . . . . . . . . . . . . . . . . . . 36
s24s.book Page 310 Thursday, November 24, 2005 12:27 PM