2005 PORSCHE BOXSTER wheel bolts

224
Practical Tips, Emergency Service
Changing a wheel
Warning!
Risk of injury. The car may slip off the jack.
fMake sure that no one is in the vehicle when
jacking up and changing a wheel.
fAlways place the car on stable supports if work
has to be carried out under the car.
Risk of damage to the brake discs of the
Porsche Ceramic Composite Brake (PCCB).
fAlways screw in both assembly aids when changing a wheel.
Note
The tools required for changing a wheel (e.g. jack,
wheel bolt wrench, assembly aids) are not sup-
plied with the car. They are available at your
authorized Porsche dealer.
1. Fully apply the handbrake, engage 1st gear or
select position P and withdraw the ignition key.
2. Secure the car against rolling away, e.g. by
means of wedges under the wheels on the op-
posite side.
This is particularly important on slopes.
Screw in assembly aid for vehicles without
Porsche Ceramic Composite Brake3. Slightly slacken the wheel bolts of the wheel to
be changed.
4. Raise the car until the wheel lifts off the
ground.
Please observe the chapter “LIFTING THE VE-
HICLE WITH A LIFTING PLATFORM OR GARAGE
LIFT” on Page 218.
Screw in two assembly aids for vehicles with
Porsche Ceramic Composite Brake5. Remove 1 or 2 wheel bolts (see respective
illustration). Screw in assembly aids instead of
the wheel bolts.
Remove the remaining wheel bolts.

Practical Tips, Emergency Service
225
6. Take the wheel off and put a new wheel on.
7. Please observe the chapter “WHEEL BOLTS”
on Page 222.
Screw in wheel bolts; remove assembly aids
and screw in the remaining wheel bolts. Initially
tighten bolts in diagonally opposite sequence
so that the wheel is centered.
8. Lower the car completely.
9. Tighten wheel bolts in diagonally opposite
sequence.
Immediately after changing a wheel, use a
torque wrench to check the prescribed
tightening torque (130 Nm/96 ftlb.).

Vehicle Identification, Technical Data
263
fWhen changing tires or fitting new ones: Please observe the chapter “WHEEL BOLTS” on Page 222.
Danger!
Installation of sizes not authorized by
Porsche may have a dangerous effect on
the driving stability and could result in
severe personal injury or death.
fBefore mounting new tires, check with yourPorsche dealer about the current release status. Boxster S Tires Rim Rim offset Track
Summer tiresfront 235/40 ZR 18 91Y 8 J x 18 H2 57 mm 58.5 in./1486 mm
rear 265/40 ZR 18 101Y XL 9 J x 18 H2 43 mm 60.2 in./1528 mm
or front 235/35 ZR 19 87Y 8 J x 19 H2 57 mm 58.5 in./1486 mm
rear 265/35 ZR 19 94Y 9.5 J x 19 H2 46+ mm 60.0 in./1522 mm
Snow tiresfront 255/40 R 18 91V M+S 8 J x 18 H2 57 mm 58.5 in./1486 mm
rear * 255/40 R 18 95V M+S 9 J x 18 H2 43 mm 60.2 in./1528 mm
The load capacity coefficient (e.g. “91”) and maximum speed code letter (e.g. “Y”) are minimum requirements.
Tire and rim sizes
Extensive tests are performed before specific tires and wheels are approved by Porsche. Your Porsche dealer has information
about approved tires and wheels and is happy to assist you. If aftermarket tires and/or wheels are installed which are not
approved by Porsche, the vehicle’s roadability and handling characteristics might be impaired. Since Porsche has no data on
such combinations, Porsche cannot stand behind the safety or durability of these aftermarket combinations.
* Snow chains Can be mounted only on the rear wheels; maximum speed 30 mph/50 km/h. Use only Porsche authorized fine-link
cross-type or edge chains. Snow chain clearance can be guaranteed only with the tire + rim combination marked.

264
Vehicle Identification, Technical Data
Tire pressure for cold tires fThese tire pressures apply only to the tire makes and types approved by Porsche.
Please observe the chapter “WHEEL BOLTS” on Page 222. Summer and snow tires
17 inch wheels front 29 psi (2.0 bar)
rear 36 psi (2.5 bar)
18 inch wheels front 29 psi (2.0 bar)
rear 36 psi (2.5 bar)
19 inch wheels front 32 psi (2.2 bar)
rear 36 psi (2.5 bar)

276UUndercoating ............................. 182
, 196
, 197
VValves ........................................................ 210
Vanity mirror................................................. 41
Vehicle
Care .................................................. 191
Identifikation label............................... 258
Identifikation number ........................... 258
Laying up the car................................ 231
Putting into operation .......................... 232
Washing ............................................. 191
Ventilation .................................................. 117
Vents .................................................114
, 117
Viscosity, engine oil.................................... 174
WWarning messages ..................................... 102
Washer fluid .......................................184
, 266
Washer lever .............................................. 110
Washing ..................................................... 191
Weights...................................................... 267
Welcome Home Function............................. 108
Wheel ............................... 198
, 203
, 262
, 263
Bolts ............................................17, 222
Changing............................................ 224
Checking pressure..........................5, 223
Inscription .......................................... 214
Loading information............................ 216
Pressure plate .................................... 259
Sidewall ............................................. 214Size ................................................... 214
Tire pressure ................................. 5
, 206
Tire sealant ........................................ 220
Windows ............................... 25
, 28, 154
, 196
Washer nozzles................................... 110
Washer system .......................... 184, 266
Windshield wipers .............................. 110, 169
Replacing ........................................... 169
Windstop .................................................... 161
Winter driving
Battery ............................................... 230
Jump lead starting.............................. 236
Winter operation
Coolant .............................................. 170
Locks................................................. 193
Seals ................................................. 197
Snow chains ....................................... 213
Tires .................................................. 212
Washer fluid........................................ 184
Wiper blades....................................... 169