2005 NISSAN PICK-UP engine

RHD MODELS
HEL211C
HARNESS LAYOUT
Engine Room Harness (Cont'd)EL-34

HEL212C
HARNESS LAYOUT
Engine Room Harness (Cont'd)EL-35
GI
MA
EM
LC
EC
FE
CL
MT
AT
TF
PD
FA
RA
BR
ST
RS
BT
HA
IDX

Precautions for Fuel
DIESEL ENGINE*:
For Turkey:
Diesel fuel of above 50 cetane
EN590 Euro 3 Euro Diesel Fuel
Except for Turkey:
Diesel fuel of above 50 cetane
* If two types of diesel fuel are available, use summer or winterfuel properly according to the following temperature conditions.
I Above þ7ÉC (20ÉF) ... Summer type diesel fuel.
I Below þ7ÉC (20ÉF) ... Winter type diesel fuel.
CAUTION:
I Do not use home heating oil, gasoline, or other alternate
fuels in your diesel engine. The use of those can cause
engine damage.
I Do not use summer fuel at temperature below þ7ÉC (20ÉF).
The cold temperature will cause wax to form in the fuel. As
a result, it may prevent the engine from running smoothly.
I Do not add gasoline or other alternate fuels to diesel fuel.
PRECAUTIONS
GI-2

Function and System Application
Diagnostic testmode Function ENGINE A/T ABS AIR BAG
Work support This mode enables a technician to
adjust some devices faster and more
accurate by following the indications
on CONSULT-II. xxÐÐ
Self-diagnostic
results Self-diagnostic results can be read
and erased quickly.
xxxx
Trouble diagnos-
tic record Current self-diagnostic results and all
trouble diagnostic records previously
stored can be read.
ÐÐÐ x
ECU discrimi-
nated No. Classification number of a replace-
ment ECU can be read to prevent an
incorrect ECU from being installed.
ÐÐÐ x
Data monitor Input/Output data in the ECU can be
read. xxxÐ
DTC work sup-
port The operating condition to confirm
Diagnosis Trouble Codes can be
selected.
ÐxÐÐ
Active test Diagnostic Test Mode in which CON-
SULT-II drives some actuators apart
from the ECUs and also shifts some
parameters in a specified range. xÐxÐ
ECU (ECM/TCM)
part number ECU (ECM/TCM) part number can
be read.
xxxÐ
Function test This mode can show results of self-
diagnosis of ECU with either ªOKº or
ªNGº. For engine, more practical
tests regarding sensors/switches
and/or actuators are available. xxxx
x: Applicable
Nickel Metal Hydride Battery Replacement
CONSULT-II contains a nickel metal hydride battery. When replacing the battery obey the following:
WARNING:
Replace the nickel metal hydride battery with Genuine CONSULT-II battery only. Use of another bat-
tery may present a risk of fire or explosion. The battery may present a fire or chemical burn hazard if
mistreated. Do not recharge, disassemble of dispose of in fire.
Keep the battery out of reach of children and discard used battery conforming to the local regulations.
CONSULT-II CHECKING SYSTEM
GI-3
MA
EM
LC
EC
FE
CL
MT
AT
TF
PD
FA
RA
BR
ST
RS
BT
HA
EL
IDX

Model Variation
DestinationClass
AxleModel
Engine Transmission Differential carrier
Cab Wheelbase Grade LH drive RH drive Front Rear
Europe Single Long DX
2WD Ð AVLGRDF-UQL
YD25DDTi FS5R30AÐ
C200
STD AVLGLCF-UQL Ð
DX AVLGLDF-UQL Ð
STD
4WD Ð AVLURCF-UQL
R180
DX Ð AVLURDF-UQL
STD AVLULCF-UQL Ð DX AVLULDF-UQL Ð
IDENTIFICATION INFORMATION
GI-5
MA
EM
LC
EC
FE
CL
MT
AT
TF
PD
FA
RA
BR
ST
RS
BT
HA
EL
IDX

Prefix and suffix designations
(Pickup)
AVLGRDFD22 UQL
L: Regular rear body
Q: Europe
U: Turbocharged engine with intercooler
F: 5-speed floor shift manual transmission
C: Standard model D: DX model
L: LH drive R: RH drive
G: Long wheelbase (2WD)
U: Long wheelbase (4WD)
VL: YD25DDTi engine
A: Single Cab
Identification Number
VEHICLE IDENTIFICATION NUMBER
Prefix and suffix designations
For Europe
ADNAPUD22UOXXXXXX
Vehicle serial number
O: Stopgap (no meaning)
U: For Europe
Model
G: Long wheelbase (2WD) U: Long wheelbase (4WD)
P: YD25DDTi engine
A: Pick-up
ADN: Nissan South Africa produced vehicle
IDENTIFICATION INFORMATION
Model Variation (Cont'd)
GI-6

FluidsandLubricants
Capacity (Approximate)Recommended Fluids/Lubricants
Liter Imp
measure
Engine oil (Refill) With oil filter YD25DDTi 2WD 5.6
4WD 4.3*6 4-7/8 qt
3-3/4 qt*6 For Europe:
Genuine NISSAN engine oil
API CF-4 for YD engine*1, *4
ACEA B1 for YD engine
Without oil filter YD25DDTi
2WD 5.3
4WD 4.0*6 4-5/8 qt
3-1/2 qt*6
Cooling system (With
reservoir) YD25DDTi 9.4 8-1/4 qt For Europe:
Genuine NISSAN Anti-freeze Coolant (L250) or equiva-
lent*5
Manual transmission
gear oil FS5R30A2WD 2.8
4WD 5.1 4-7/8 pt
9pt API GL-4, Viscosity SAE 75W-85 only
Transfer fluid TX10A 2.2 2 qt Genuine NISSAN ATF Matic Fluid D or equivalent*2 or
API GL-4*1
Differential gear oil
Front R180A 1.3 2-1/4 pt Standard differential gear: Differential Oil Hypoid Super
GL-5, 80W-90 (Part No.: KLD33-8090201) or API GL-5*1
Limited-slip differential (LSD) gear: Differential Oil
Hypoid LSD (Part No.: KLD31-8090403) or equivalent
Rear C200 1.3 2-1/4 pt
Power steering fluid Ð Ð Genuine NISSAN PSF or equivalent*7
Brake and clutch fluid Ð Ð For Europe: DOT 3 or DOT 4 (U.S. FMVSS No. 116)*3
Propeller shaft grease Ð Ð NLGI No. 2 (Lithium soap base)
Multi-purpose grease Ð Ð NLGI No. 2 (Lithium soap base)
*1: For further details, see ªSAE Viscosity Numberº.
*2: Contact a NISSAN dealership for more information regarding suitable fluid, including recommended brand(s) of DEXRON
TMIII/MERCONTMAuto-
matic Transmission Fluid.
*3: Never mix DOT 3 and DOT 4. (DOT 3 is filled at factory.)
*4: Never use CG-4 grade oil.
*5: Use NISSAN Genuine Engine Coolant, or equivalent in its quality, in order to avoid possible aluminum corrosion within the engine cooling system caused by the use of non-genuine engine coolant.
Note that any repairs for the incidents within the engine cooling system while using non-genuine engine coolant may not be covered by
the warranty even if such incidents occurred during the warranty period.
*6: Including 4WD appearance 2WD models
*7: DEXRON
TMIII type ATF can be used.
RECOMMENDEDFLUIDSANDLUBRICANTS
MA-2

SAEViscosityNumber
DIESEL ENGINE
I5W-30 is preferable.
If 5W-30 is not available, select the viscosity, from the chart,
that is suitable for the outside temperature range.
SMA204D
RECOMMENDED FLUIDS AND LUBRICANTS
MA-3
GI
EM
LC
EC
FE
CL
MT
AT
TF
PD
FA
RA
BR
ST
RS
BT
HA
EL
IDX