2005 MINI COOPER capacity

63
OVERVIEW REPAIRS OPERATIONCONTROLS DATA INDEX
ODOMETER
CLOCK
FUEL GAUGE
1 Trip odometer/clock
Resetting to zero when the trip odometer is
in the display:With ignition key in position
1, press the
button until the trip odometer is at zero.
To show the clock:Press the button briefly.2 Odometer
When the ignition key is not in the ignition
lock, you can activate the displays shown in
the illustration by pressing the button in
the display elements.
Setting 1. Press button
1 to display the clock
2. Press button
1 for approx. 5
seconds to
activate the clock-setting mode
3. Press button
1 to select 12-hour or 24-
hour mode
4. Wait approx. 5
seconds until the hours
display flashes
5. Press button
1 to set the hour
6. Wait approx. 5
seconds until the min
-
utes display flashes
7. Press button
1 to set the minute.
The set time is saved automatically after
approx. 1
minute.
In the speedometer or Cockpit Chrono Pack* If the indicator light
1 begins to be lit con
-
tinuously, there are approx. 2.1
gallons
/
8
liters of fuel in the tank.

Fuel tank capacity:

Approx. 13.2
gallons
/ 50
liters.
When you switch on the ignition, the indi
-
cator lamp lights up briefly to confirm that
the system is operational. If the angle of the vehicle varies, for exam
-
ple when you are driving in mountainous
areas, the needle may fluctuate slightly.
Refill the gas tank early. If you drive to the last drop of fuel, engine func
-
tions are not guaranteed and damage can
occur.<
ProCarManuals.com

87
OVERVIEW REPAIRS OPERATIONCONTROLS DATA INDEX
LOADING CARGO
Avoid overloading the vehicle so that the permitted load on the tires is not
exceeded. Overloading can lead to over
-
heating and damage inside the tires.
Depending on the circumstances, this can
result in sudden air loss.<
Determining cargo limit1. Locate the following statement on your
vehicle's placard:
The combined weight of occu
-
pants and cargo should never
exceed XXX
kg or YYY
lbs, as this could
otherwise result in damage to the vehi
-
cle and unstable driving conditions.<
2. Determine the combined weight of the
driver and passengers that will be riding
in your vehicle3. Substract the combined weight of the
driver and passengers from XXX kilo
-
grams or YYY
pounds
4. The resulting figure equals the available
amount of cargo and luggage load
capacity.

For example, if the XXX amount equals
1,400 lbs. and there will be four 150
lbs.
passengers in your vehicle, the amount
of available cargo and luggage load
capacity is 800
lbs.:

1,400
lbs. minus 600
lbs. = 800
lbs.
5. Determine the combined weight of lug
-
gage and cargo being loaded on the
vehicle. That weight may not safely
exceed the available cargo and luggage
load capacity calculated in Step
4
6. If your vehicle will be towing a trailer,
load from your trailer will be transferred
to your vehicle. Consult the manual for
transporting a trailer to determine how
this may reduce the available cargo and
luggage load capacity of your vehicle.
ProCarManuals.com

94
REFUELING
Always switch off the engine before refueling. If you do not, fuel cannot
be filled into the tank and the SERVICE
ENGINE SOON lamp may come on.<
1. Open the fuel filler door2. Turn the gas cap counterclockwise3. Put the gas cap in the bracket attached
to the fuel filler door.
Always observe all applicable precau
-
tions and regulations when handling
fuels. Never carry spare fuel containers in
your vehicle. Whether empty or full, these
containers can leak, cause an explosion,
and lead to fire in the event of a collision.<
Observe the following when refueling
Always observe all safety precautions posted at the service station when
handling fuel.<
When refueling, insert the filler nozzle
completely into the filler pipe. Pulling the
nozzle out of the pipe during refueling:>Results in premature pump shutoff>Will reduce the effect of the fuel vapor
recovery system on the pump.As long as the filler nozzle is used properly,
the fuel tank is full whenever the nozzle
shuts off the first time.Closing the gas cap1. Put on gas cap 2. Turn gas cap clockwise until it clicks3. Close fuel filler door.
Close the gas cap carefully after

refuelling until a click is heard.

While closing, be sure not to squeeze the
strap which is fastened to the cap.<
US models only:
The warning lamp
* comes on.

The gas cap is not correctly closed
or missing. Check if the gas cap is
correctly closed.
Fuel tank volumeApprox. 13.2
gallons
/ 50
liters, of which
approx. 2.1
gallons
/ 8
liters are reserve
capacity.
Do not drive until the fuel tank is totally empty. Otherwise engine
operations are not guaranteed and damage
could occur.<
Fuel specification The engine uses lead-free gasoline only.Required fuel Premium Unleaded Gasoline,

Minimum Octane Rating: 91.Minimum Octane Rating corresponds to
the Anti Knock Index (AKI) and is deter
-
mined according to the so-called (R+M)/2
method.
ProCarManuals.com

108
WASHER FLUID
ENGINE OIL
Headlamp* and window washer systems The capacity of the headlamp washer sys
-
tem is approx. 2.6
quarts
/ 2.5
liters, that of
the windshield and rear window washer
system approx. 2.1
quarts
/ 2.0
liters.
Fill with water and, if necessary, with anti
-
freeze, according to manufacturer's recom
-
mendations.
We recommend that you mix the washer fluid before filling either res
-
ervoir.<
Antifreeze agent for the washer sys
-
tems is flammable. Always keep it
well away from sparks and open flames,
and store it in tightly closed containers well
out of the reach of children. Always observe
the instructions on the containers.<
The illustration shows by way of example the dipstick of the MINI
COOPER and the
MINI
COOPER Convertible.
Measuring the oil level1. Park the vehicle on a level surface2. Switch the engine off after it has
reached normal operating temperature3. Pull the dipstick out after approx.
5
minutes and wipe it off with a lint-free
cloth, paper towel, or similar material
4. Carefully push the dipstick all the way
into the guide tube and pull it out again.
The oil level must be between the two
marks on the dipstick.
As with fuel economy, oil consumption is
directly influenced by your driving style and
vehicle operating conditions.
The oil volume between the two notches –
MIN, MAX – on the dipstick corresponds to
approx. 1.1
quarts
/ 1
liter. Do not fill
beyond the upper notch on the dipstick.
Excess oil will damage the engine.
ProCarManuals.com

134
JUMP-STARTINGWhen your battery is discharged, you can
use two jumper cables to start your vehicle
with power from the battery in a second
vehicle. Correspondingly you can help start
another vehicle. Only use jumper cables
with fully insulated handles on the termi
-
nal clamps.Preparing for jump-starting
Do not touch live wiring and cables on a running engine. There is a risk of
fatal injury if you do this. Carefully observe
the following instructions to avoid per
-
sonal injury and/or damage to either vehi
-
cle or both vehicles. Make sure that there is
no contact between the bodywork of the
two vehicles to avoid a short circuit haz
-
ard.<
1. Check whether the battery of the sup
-
port vehicle has 12
Volts and approxi
-
mately the same capacity measured in
Ah. These data are printed on the bat
-
tery
2. Switch off the engine of the support
vehicle3. Switch off any electrical systems and
components in both vehicles.Connect the jumper cables
Always adhere to this sequence when connecting the jumper cables; failure
to observe this procedure can lead to spark
-
ing and pose an injury hazard.<
The illustration shows the auxiliary jump-starting terminal on the MINI
COOPER S
and the MINI COOPER
S Convertible. In the
MINI COOPER
S and the MINI COOPER
S
Convertible, the auxiliary jump-starting
terminal, arrow
1, acts as the positive bat
-
tery terminal, refer to view of engine com
-
partment on page
107
. The cover is marked
with a
+.
1. Remove the cover of the battery or open
the cover of the auxiliary jump-starting
terminal:
>MINI COOPER and MINI COOPER Con
-
vertible:

Remove the battery cover.

To do so, press the two clips simulta
-
neously.
ProCarManuals.com

143
OVERVIEW REPAIRS OPERATION CONTROLS DATA INDEX
WEIGHTS: MINI
MINI COOPER
MINI COOPER
S
Curb weight, with all optional special equipmentwith manual transmissionwith Continuously Variable automatic

Transmission (CVT)
lbs
/ kg
lbs
/ kg
2,524 / 1,1452,557 / 1,160
2,678 / 1,215
–
Approved gross vehicle weightwith manual transmissionwith Continuously Variable automatic

Transmission (CVT)
lbs
/ kg
lbs
/ kg
3,340 / 1,5153,373 / 1,530
3,494 / 1,585
–
Cargo and luggage load capacity
lbs
/ kg
816 / 370
816 / 370
Approved front axle load
lbs
/ kg
1,918 / 870
1,962 / 890
Approved rear axle load
lbs
/ kg
1,609 / 730
1,698 / 770
Approved roof load, with special MINI roof rack
lbs
/ kg
165 / 75
165 / 75
Luggage compartment volumewith rear backrest folded down
cu ft / liters
cu ft / liters
5.3 / 15023.7 / 670
5.3 / 15023.7 / 670
ProCarManuals.com

144
WEIGHTS: MINI CONVERTIBLE
MINI COOPER Convertible
MINI COOPER
S Convertible
Curb weight, with all optional special equipmentwith manual transmissionwith Continuously Variable automatic

Transmission (CVT)
lbs
/ kg
lbs
/ kg
2,700 / 1,2252,734 / 1,240
2,844 / 1,290
–
Approved gross vehicle weightwith manual transmissionwith Continuously Variable automatic

Transmission (CVT)
lbs
/ kg
lbs
/ kg
3,472 / 1,5753,505 / 1,590
3,616 / 1,640
–
Cargo and luggage load capacity
lbs
/ kg
771 / 350
771 / 350
Approved front axle load
lbs
/ kg
1,918 / 870
1,962 / 890
Approved rear axle load
lbs
/ kg
1,697 / 770
1,763 / 800
Approved roof load, with special MINI roof rack
lbs
/ kg
–
–
Luggage compartment volumewith luggage compartment cover folded upwith rear backrest folded down
cu ft / liters
cu ft / liters
cu ft / liters
4.2 / 1205.8 / 16521.4 / 605
4.2 / 1205.8 / 16521.4 / 605
ProCarManuals.com

EVERYTHING FROM A TO Z
151
OVERVIEW REPAIRS OPERATION CONTROLS DATA INDEX
Electric glass sunroof
33
Electric power windows
31
initializing
32
Electrical malfunction

Continuously Variable
automatic Transmission
(CVT)
56
convertible top
37
door lock
27
driver's door
27
fuel filler door
95
glass sunroof, electric
34
tailgate
30
Electronic Brake Force
Distribution (EBD)
70
Electronic Stability Program
(ESP), refer to

Dynamic Stability Control
(DSC)
69
Emergency operation, refer to
Manual operation

convertible top
37
driver's door
27
fuel filler door
95
glass sunroof, electric
34
tailgate
30
transmission lock for
Continuously Variable
automatic Transmission
(CVT)
54
Engine

break-in procedures
92
data
140

electronics
18
indicator lamp
18
speed
65
starting
51
switching off
52
Engine compartment

MINI COOPER and MINI
COOPER Convertible
106

MINI COOPER S and MINI
COOPER S Convertible
107

Engine coolant
110

Engine data
140

Engine oil
108

capacity
145

indicator/warning lamp
16
recommended oils
109

specified oil grades
109

viscosities
109

Engine oil level
108

indicator/warning lamp
16
Engine oil level, checking
108

Engine oil pressure, indicator/
warning lamp
16
Engine output, refer to Engine
data
140

Entry to the rear
44
ESP Electronic Stability
Program, refer to Dynamic
Stability Control (DSC)
69
Exhaust system, refer to

Hot exhaust system
93
Exterior mirrors
46
folding in and out
46
Eyelet, for towing and tow-
starting
136

F Failure of an electrical
consumer
132

Fastening safety belts, refer to
Safety belts
45
Filling canister, refer to MINI
Mobility System
130

Filling hose, refer to MINI
Mobility System
130

Filter, refer to

Microfilter
77
Microfilter/Activated-
charcoal filter
80
Flat tire

Flat Tire Monitor
71, 72
MINI Mobility System
129

Run Flat tires
101

space-saver spare tire
125

Flat Tire Monitor
71
indicator lamp
17
Flat tire, refer to Changing
tires
127

Flat tire, refer to Tires,
condition
100

Floor mats
115

Fog lamps
58
indicator lamp
58
Foldable rear backrest
85, 86
Folding roof
35
'Follow me home' lamps
57
Foot brake, refer to General
driving notes
93
Front airbags
72
Front turn signal indicators,
bulb replacement
122

Fuel
94
average consumption
67
gauge
63, 64
quality
94
tank capacity
145

Fuel filler door
94
unlocking in the event of
electrical malfunction
95
Fuel tank capacity
145

Fuses
133

G Garage door opener, refer to
Integrated universal remote
control
83
ProCarManuals.com