2005 MERCEDES-BENZ ML350 GEAR OIL

ContentsAt the gas station............................... 219
Refueling ...................................... 219
Check regularly and
before a long trip .......................... 221
Engine compartment.......................... 222
Hood ............................................ 222
Engine oil...................................... 223
Transmission fluid level ................ 227
Coolant level ................................ 227
Battery ......................................... 228
Windshield / rear
window washer system and
headlamp cleaning system*......... 230
Tires and wheels ................................ 231
Important guidelines .................... 231
Life of tire ..................................... 232
Direction of rotation ..................... 232
Checking tire inflation pressure ... 232
Rotating wheels............................ 233
Winter driving..................................... 235
Winter tires................................... 235
Block heater (Canada only) .......... 236
Snow chains ................................. 236Maintenance ...................................... 237
Clearing the
maintenance service indicator ..... 237
Maintenance service
term exceeded ............................. 238
Calling up the
maintenance service indicator ..... 238
Resetting the
maintenance service indicator ..... 238
Vehicle care ....................................... 240
Cleaning and care of the vehicle .. 240
Practical hints.................................. 247
What to do if … .................................. 248
Lamps in instrument cluster ........ 248
Additional indicators
in the speedometer display .......... 263
Where will I find ...? ........................... 264
First aid kit ................................... 264
Vehicle tool kit ............................. 264
Spare wheel (space-saver tire) ..... 266Unlocking / locking in
an emergency .................................... 268
Unlocking the vehicle................... 268
Locking the vehicle ...................... 269
Fuel filler flap ............................... 269
Manually unlocking the
transmission gear selector lever .. 270
Opening / closing in
an emergency .................................... 271
Power tilt / sliding sunroof* ......... 271
Replacing key batteries ..................... 272
Remote control ............................ 273
Replacing bulbs ................................. 274
Bulbs ............................................ 274
Replacing bulbs for front lamps ... 276
Replacing bulbs for rear lamps .... 279
Adjusting headlamp aim .............. 282
Replacing wiper blades ...................... 283
Removing ..................................... 283
Installing ...................................... 283
Flat tire .............................................. 284
Mounting the spare wheel ........... 284

205 Operation
Driving instructions
Special driving features for off-road
driving
The following driving features are available
for specific kind of operation:

LOW RANGE mode (
page 127)


LOW RANGE – ABS (
page 77)


LOW RANGE – 4-ETS (
page 80)


LOW RANGE – ESP (
page 81)
Off-road driving rules
Engage the LOW RANGE mode before driv-
ing under off-road conditions
(
page 127).
Fasten items being carried as securely as
possible (
page 160).Checklist before off-road driving
Engine oil level


Check the engine oil level
(page 224). The display
OIL i.O

must appear via display in the speed-
ometer.
Only then can the vehicle obtain a trou-
ble-free oil supply, even on steep gradi-
ents.
iWe recommend keeping doors, liftgate,
windows, and tilt / sliding sunroof*
closed whenever driving in off-road
mode.
!Observe the following during off-road
driving:

Adjust vehicle speed to condition of
terrain. The more uneven, rutty and
steeper the terrain, the lower the
speed should be.


Watch out for obstacles, such as
rocks, holes, tree stumps and ruts.


Be especially careful when driving
in unknown territory. It may be nec-
essary to get out of the vehicle and
scout the path you intend to take.


Before driving through water, deter-
mine is depth.


Do not stop vehicle while immersed
in water, and do not shut off the
engine.


In sandy soil, please drive at a
steady speed as allowed by condi-
tions. This helps overcome the vehi-
cle rolling resistance and reduces
the likelihood of the vehicle sinking
into the ground.


Do not initiate jumps with the vehi-
cle. It interrupts the forward mo-
mentum of the vehicle.


Always drive onto slopes with the
the engine running and the vehicle
in gear.

206 OperationDriving instructionsTires

Check the tread depth and maintain
specified tire pressure (see tire pres-
sure label inside the fuel filler flap).


Check tires for possible damage and
remove foreign objects.


Replace missing valve caps.
Rims


Dented or bent rims can cause tire
pressure loss and damage the tire
beads. For this reason, check and, if
necessary, change rims before driving
off-road.
Vehicle tool kit


Check if the vehicle jack is functional.


In all cases take the vehicle tool kit, a
strong tow rope, a shovel and a small
plank (to put under the vehicle jack on
sandy soil) with you.Driving in steep terrain
Slope angle1 25°
226°

Switch to LOW RANGE mode before
starting to drive up or down steep in-
clines (
page 127).


Driving on embankments, slopes and
other steep inclines should only be
done straight up or downhill, i.e. in the
line of gravity. Maximum vehicle climb-
ing ability is a 60% grade.


Do not drive along the side of a slope
(danger of vehicle rollover). If in doing
so the vehicle begins to show a tenden-
cy to roll, immediately steer into a line
of gravity (straight up or downhill).


To help avoid the vehicle rolling over,
never turn it around on steep inclines.
If the vehicle cannot complete the at-
tempted climb, back it down in reverse
gear.


Utilize the engine’s braking power
when descending a slope, observe the
engine speed (do not overrev the en-
gine). Apply the service brake as need-
ed.


Check the brakes after a lengthy down-
grade drive.iAvoid excessive engine speeds – drive
with moderate engine speeds
(max. 3000 RPM).
Select gear range2 or1 on the auto-
matic transmission (
page 122).

227 Operation
Engine compartment

Screw filler cap2 back on filler neck.
For more information on engine oil, see the
“Technical data” section (
page 312) and
(
page 314).
Transmission fluid level
The transmission fluid level does not need
to be checked. If you notice transmission
fluid loss or gear shifting malfunctions,
have an authorized Mercedes-Benz Light
Truck Center check the automatic trans-
mission.Coolant level
The engine coolant is a mixture of water
and anticorrosion / antifreeze. To check
the coolant level, the vehicle must be
parked on level ground and the engine
must be cool.
!Excess oil must be siphoned or drained
off. It could cause damage to the
engine and catalytic converter not
covered by the Mercedes-Benz Limited
Warranty.
Warning!
G
In order to avoid any possibly serious burns:

Use extreme caution when opening the
hood if there are any signs of steam or
coolant leaking from the cooling system,
or if the coolant temperature gauge indi-
cates that the coolant is overheated.


Do not remove pressure cap on coolant
reservoir if coolant temperature is
above 158°F (70°C). Allow engine to
cool down before removing cap. The
coolant reservoir contains hot fluid and
is under pressure.


Using a rag, slowly open the cap approx-
imately
1/2 turn to relieve excess pres-
sure. If opened immediately, scalding
hot fluid and steam will be blown out un-
der pressure.


Do not spill antifreeze on hot engine
parts. Antifreeze contains ethylene gly-
col which may burn if it comes into con-
tact with hot engine parts.

312 Technical dataFuels, coolants, lubricants, etc.Capacities
Vehicle components and their respective
lubricants must match.Therefore only use products tested and
approved by Mercedes-Benz.Please refer to the Factory Approved
Service Products pamphlet, or inquire at
your Mercedes-Benz Light Truck Center.
Model
Capacity
Fuels, coolants, lubricants, etc.
Engine with oil filter
ML 350, ML 500
8.5 US qt (8.0 l)
Approved engine oils
Automatic transmis-
sion
9.0 US qt (8.5 l)
MB Automatic Transmission Oil
Transfer case
1.6 US qt (1.5 l)
(Dexron 3 or Dexron 2E)
Rear axle
1.3 US qt (1.25 l)
(Hypoid gear oil SAE 90, 85 W 90)
Front axle
1.2 US qt (1.1 l)
(Hypoid gear oil SAE 90)
Power steering
approx. 0.65 US qt (0.6 l)
MB Power Steering Fluid
Front wheel hubs
approx. 1.5oz (43g) each
High temperature roller bearing grease

324 Technical termsEngine oil viscosity
Measurement for the inner friction (vis-
cosity) of the oil at different tempera-
tures. The higher the temperature an
oil can tolerate without becoming thin,
or the lower the temperature it can tol-
erate without becoming viscous, the
better the viscosity.
ESP
(E
lectronic S
tability Pr
ogram)
Improves vehicle handling and direc-
tional stability.
ETD
(E
mergency T
ensioning D
evice)
Device which deploys in certain frontal
and rear collisions exceeding the sys-
tem's threshold to tighten the seat
belts.
->SRSFSS (Canada vehicles)
(F
lexible S
ervice S
ystem)
Maintenance service indicator in the
speedometer display that informs the
driver when the next vehicle mainte-
nance service is due. FSS evaluates en-
gine temperature, oil level, vehicle
speed, engine speed, distance driven
and the time elapsed since your last
service, and calls for the next mainte-
nance service accordingly.
GAWR
(G
ross A
xle W
eight R
ating)
The GAWR is the maximum permissible
axle weight. The gross vehicle weight
on each axle must never exceed the
GAWR for the front and rear axle indi-
cated on the certification label located
on the driver’s door pillar.GVW
(G
ross V
ehicle W
eight)
The GVW comprises the weight of the
vehicle including fuel, tools, spare
wheel, installed accessories, passen-
gers and cargo. The GVW must never
exceed the GVWR, indicated on the
certification label located on the driv-
er’s door pillar.
GVWR
(G
ross V
ehicle W
eight R
ating)
This is the maximum permissible vehi-
cle weight. It is indicated on certifica-
tion label located on the driver’s door
pillar.
Gear range
Number of gears which are available to
the automatic transmission for shifting.
The automatic gear shifting process
can be adapted to specific operating
conditions using the gear selector
lever.

340 IndexLighting 107
Automatic headlamp mode 108
Cargo compartment 116
Daytime running lamp mode 109
Fog lamps 111
Front fog lamps 112
High beam 111
High beam flasher 111
Instrument cluster illumination 117
Interior 114
Locator lighting 111
Night security illumination 109
Limiting the gear range 122
Limp Home Mode 126
Line of fall 325
Loading 160
Cargo compartment cover
blind* 164
Cargo floor plates 165
Cargo tie-down rings 161
Hooks 162
Instructions 160
Partition net* 162
Roof rack 166
Split rear bench seat 100
Trailer 212Locator lighting 111
Lock button 325
Locking 88
Automatic while driving 93
Centrally from inside 94
Fuel filler flap 219
Global 89
Vehicle in an emergency 269
Locking knobs 32
Loss of keys 90
Loss of Service and Warranty Information
Booklet 303
Low beam bulbs
Replacing bulbs 276
Low beam headlamps
Replacing bulbs 274
Switching on 50
Low engine oil level
Indicator lamp 260
LOW RANGE - 4-ETS 80
LOW RANGE - ABS 77
LOW RANGE - ESP 81
LOW RANGE mode 127
Low washer system fluid level
Indicator lamp 260Lowering
Vehicle 287
M
Main dimensions 310
Main fuse box 298
Maintenance 12
Display messages 263
Maintenance System (U.S. vehicles) 327
Manual operations
Fuel filler flap 269
Interior lighting control 115
Locking the vehicle 269
Power tilt/sliding sunroof* 271
Unlocking the driver’s door 268
Unlocking transmission selector
lever 270
Manual seat
Adjusting 36
Adjusting backrest tilt 37
Adjusting head restraint height 37
Adjusting head restraint tilt 38, 40
Seat fore and aft adjustment 36
Seat height 37
MB Tex upholstery
Cleaning 245

341 Index
MCS
Modular Control System 325
Mechanical key 268
Memory function 105, 325
Memory function* 106
Recalling positions from
memory 106
Mirrors
Activating exterior mirror parking
position 129
Adjusting 41
Automatic antiglare for rear view
mirror 128
Exterior rear view mirror 41
Storing exterior rear view mirror
parking position 106
MON 220
MON (Motor Octane Number) 325
Multifunction display 325
N
Night security illumination 109
Deactivation temporarily 110O
Occupant safety 58
Children and airbags 60
Children in the vehicle 67
Fastening the seat belt 43
Infant and child restraint systems 68
LATCH child seat mounts 73
Seat belts 43, 62
Odometer display 118
Odometer, main 25
Off-road driving
Checklist 205, 210
Crossing obstacles 209
Driving instructions off-road
driving 204
Driving through water 208
Returning 210
Rules 205
Special driving features 205
Steep terrain 206
Oil
Adding 226
Consumption 223
Dipstick 223
Oil dipstick 226
Viscosity 324One-touch gearshifting 121
Canceling gear range limit 121
Downshifting 121
Upshifting 121
Opening
Doors from the inside 90
Fuel filler flap 219
Fuel filler flap manually 269
Glove box 167
Hood 222
Liftgate 89, 91
Liftgate from inside 91
Liftgate from outside 91
Power tilt/sliding sunroof* 271
Rear quarter windows* 148
Side windows 147
Storage compartment in front of
armrest 169
Storage compartment under passenger
seat 168
Tilt/sliding sunroof* 150
Tilt/Sliding sunroof* in an
emergency 271
Windows 147