2005 MERCEDES-BENZ G500 checking oil

ContentsOperation......................................... 213
The first 1000 miles (1500 km) ......... 214
Driving instructions ............................ 216
Drive sensibly – save fuel ............. 216
Drinking and driving ..................... 216
Pedals .......................................... 216
Power assistance ......................... 217
Brakes .......................................... 217
Driving off..................................... 218
Parking ......................................... 218
Tires ............................................. 219
Hydroplaning ................................ 220
Tire traction .................................. 220
Tire speed rating .......................... 221
Winter driving instructions ........... 221
Standing water ............................. 222
Passenger compartment .............. 223
Off-road driving ............................ 223
Control and operation of radio
transmitters.................................. 231
Driving abroad .............................. 232
Catalytic converter ....................... 232
Emission control........................... 233
Coolant temperature .................... 233At the gas station .............................. 235
Refueling ...................................... 235
Check regularly and before
a long trip ..................................... 236
Engine compartment ......................... 238
Hood ............................................ 238
Engine oil ..................................... 239
Transmission fluid level ................ 244
Coolant level ................................ 244
Windshield/rear window
washer system and headlamp
cleaning
system ......................................... 245
Battery ............................................... 247
Tires and wheels ................................ 248
Important guidelines .................... 248
Tire care and maintenance ........... 249
Direction of rotation ..................... 251
Loading the vehicle ...................... 251
Recommended tire inflation
pressure ....................................... 257
Checking tire inflation pressure ... 259
Tire labeling.................................. 261
Load identification ....................... 265DOT, Tire Identification Number
(TIN) ............................................. 266
Maximum tire load ....................... 267
Maximum tire inflation pressure .. 268
Uniform Tire Quality Grading
Standards (U.S. vehicles) ............. 268
Tire ply material ........................... 270
Tire and loading terminology........ 271
Rotating tires ............................... 274
Winter driving .................................... 275
Winter tires .................................. 275
Block heater (Canada only) .......... 276
Snow chains................................. 276
Maintenance...................................... 277
Clearing the maintenance
service indicator .......................... 278
Maintenance service term
exceeded ..................................... 278
Calling up the maintenance
service indicator .......................... 278
Resetting the maintenance
service indicator .......................... 279
Vehicle care....................................... 280
Cleaning and care of the vehicle .. 280

237 Operation
At the gas station
G55AMG1Coolant
2Brake fluidCoolant
For normal replenishing, use water (pota-
ble water quality). For more information,
see “Coolant level” (
page 244) and see
“Fuels, coolants, lubricants, etc.”
(
page 374).
Brake fluidEngine oil level
For more information on engine oil, see
“Engine oil” (
page 239).
Tire inflation pressure
For more information, see “Checking tire
inflation pressure” (
page 259).
Vehicle lighting
Check function and cleanliness. For infor-
mation on replacing light bulbs, see “Re-
placing bulbs” (
page 333).
For more information, see “Exterior lamp
switch” (
page 110).
Windshield/rear window washer sys-
tem and headlamp cleaning system
For more information on refilling the reser-
voir, see “Windshield/rear window washer
system and headlamp cleaning system”
(
page 245).
iOpening the hood, see (
page 238).
!If you find that the brake fluid in the
brake fluid reservoir has fallen to the
minimum mark or below, have the
brake system checked for brake pad
thickness and leaks immediately. Noti-
fy an authorized Mercedes-Benz Light
Truck Center immediately. Do not add
brake fluid as this will not solve the
problem. For more information, see
“Practical hints” (
page 290).

240 OperationEngine compartmentChecking engine oil level with the
control system
When checking the oil level

the vehicle must be parked on level
ground


with the engine at operating tempera-
ture, the vehicle must have been sta-
tionary for at least five minutes with the
engine turned off


with the engine not at operating tem-
perature yet, the vehicle must have
been stationary for at least 30 minutes
with the engine turned off
To check the engine oil level via the
multifunction display, do the following:

Switch on the ignition (
page 35).
The standard display (
page 123) should
appear in the multifunction display.

Press buttonk orj on the
steering wheel until the following
message is seen in the multifunction
display:ENGINE OIL LEVEL
MEASURING NOW
MEASURE. CORRECT
ONLY IF VEH. LEVELOne of the following messages will
subsequently appear in the indicator:

ENGINE OIL LEVEL
OK


ADD 1.0 Qt. TO
REACH MAX. OIL LEVEL!(Canada:
1.0 LITER
)


ADD 1.5 Qts. TO
REACH MAX. OIL LEVEL!(Canada:
1.5 LITERS
)


ADD 2.0 Qts. TO
REACH MAX. OIL LEVEL!(Canada:
2.0 LITERS
)

If necessary, add engine oil.
For adding engine oil see (
page 243).
For more information on engine oil, see the
“Technical data” section (
page 374) and
(
page 375).iIf you want to interrupt the checking
procedure, press thek orj
button on the multifunction steering
wheel.

241 Operation
Engine compartment
Other display messages
If the SmartKey is not turned to position2
in the starter switch, the following
message will appear:FOR ENGINE OIL LEVEL
SWITCH ON IGNITION!
Switch on the ignition (
page 35).
If you see the message:
OBSERVE WAITING PERIOD
If engine is at operating temperature,
wait five minutes before repeating
check procedure.

If engine is not at operating tempera-
ture yet, wait 30 minutes before re-
peating check procedure.If you see the message:
ENGINE OIL LEVEL
NOT WHEN ENGINE ON!
Turn off the engine.

If the engine is at operating tempera-
ture, wait five minutes before checking
oil.

If the engine is not at operating temper-
ature yet, you must wait 30 minutes
before checking oil.
If there is excess engine oil with the engine
at normal operating temperature, the
following message will appear:
ENGINE OIL LEVEL
REDUCE OIL LEVEL
Have excess oil siphoned or drained
off. Contact an authorized
Mercedes-Benz Light Truck Center.For more information on messages in the
multifunction display concerning engine
oil, see the “Practical hints” section
(
page 296). !Excess oil must be siphoned or drained
off. It could cause damage to the
engine and catalytic converter not
covered by the Mercedes-Benz Limited
Warranty.iPerform the engine oil level check with
the dipstick if it cannot be completed
with the control system (
page 242).
In this case we recommend that you
have the system checked at a
Mercedes-Benz Light Truck Center.

242 OperationEngine compartmentChecking engine oil level with the oil
dipstick
When checking the oil level the vehicle
must

be parked on level ground


be at normal operating temperature


have been stationary for at least five
minutes with the engine turned offTo check the engine oil level with the oil
dipstick, do the following:

Open the hood (
page 238).

Pull out oil dipstick1 (
page 243).

Wipe oil dipstick1 clean.

Fully insert oil dipstick1 into the
dipstick guide tube.

Pull out oil dipstick1 again after
approximately three seconds to obtain
accurate reading.
Oil dipstickThe oil level is correct when it is between
the lower (min) and upper (max) mark of
the oil dipstick.

If necessary, add engine oil.
For adding engine oil see (
page 243).
For more information on engine oil, see the
“Technical data” section (
page 374) and
(
page 375).
For more information on messages in the
multifunction display concerning engine
oil, see the “Practical hints” section
(page 309).
iThe engine oil level can be checked by
either the oil dipstick or via the multi-
function display in the instrument
cluster (
page 240). The amount of
engine oil needed is shown more
precisely in the multifunction display.
iThe filling quantity between the upper
and lower marks on the oil dipstick is
approximately 2.1 US qt. (2.0 l).

244 OperationEngine compartment
Screw oil filler cap2 back on filler
neck.
For more information on engine oil, see the
“Technical data” section (
page 374) and
(
page 375).
Transmission fluid level
The transmission fluid level does not need
to be checked. The transmission has a per-
manent supply of automatic transmission
fluid.
If you notice transmission fluid loss or gear
shifting malfunctions, have an authorized
Mercedes-Benz Light Truck Center check
the automatic transmission.Coolant level
The engine coolant is a mixture of water
and anticorrosion/antifreeze.
When checking the coolant level,

the vehicle must be parked on level
ground.


the engine must be cool. The coolant
level should reach the COLD LEVEL
mark in the reservoir.
!Excess oil must be siphoned or drained
off. It could cause damage to the
engine and catalytic converter not
covered by the Mercedes-Benz Limited
Warranty.
Warning!
G
In order to avoid any possibly serious burns:

Use extreme caution when opening the
hood if there are any signs of steam or
coolant leaking from the cooling system,
or if the coolant temperature display in-
dicates that the coolant is overheated.


Do not remove pressure cap on coolant
reservoir if coolant temperature is
above 158°F (70°C). Allow engine to
cool down before removing cap. The
coolant reservoir contains hot fluid and
is under pressure.


Using a rag, slowly open the cap approx-
imately
1/2turn to relieve excess pres-
sure. If opened immediately, scalding
hot fluid and steam will be blown out un-
der pressure.


Do not spill antifreeze on hot engine
parts. Antifreeze contains ethylene gly-
col which may burn if it comes into con-
tact with hot engine parts.


390 IndexCentigrade
Setting temperature units 135
Central locking
From inside 99
Switch 99
Switching on/off (control
system) 141
Unlocking from inside 99
Certification label 366
Changing
Key setting 142
Charging
Vehicle battery 351
Checking
Coolant level 237, 244
Oil level 237, 239
Checklist
Off-road driving 225
Child safety 72
Infant and child restraint systems 62,
68, 72
LATCH child seat anchors 77
Child safety switch see Blocking of rear
door window operation
Cigarette lighter 195Cleaning
Cup holders 284
Gear selector lever 284
Hard plastic trim items 284
Headlamps 162
Headliner 284
Illuminated door sill panels 285
Instrument cluster 284
Leather upholstery 285
Light alloy wheels 284
MB Tex upholstery 285
Plastic and rubber parts 285
Rear Parking Assist sensors* 283
Seat belts 284
Steering wheel 284
Windows 283
Windshield 54
Wiper blades 283
Wood trims 285
Cleaning tires 250
Climate control 164
Adjusting 167
Defogging windshield 167
Defrosting 168
Rear window defroster 163
Setting the temperature 166Clock 25
Closing
Glove box 190
Hood 239
Side windows 171
Tailgate 98
Tilt/sliding sunroof 173, 328
Tilt/sliding sunroof with
SmartKey 175
Windows 171
Windows with SmartKey 172
Closing tilt/sliding sunroof
In an emergency 328
Cockpit 22, 381
Cockpit management and data system
(COMAND) 382
Cold tire inflation pressure 271
COMAND 382
COMAND see separate operating
instructions
Combination switch 23, 114
High beam flasher 52, 114
High beam headlamps 114
Turn signals 52
Windshield wipers 53

393 Index
Driving
General instructions 43, 216
In winter 221
Problems 55
Safety systems 80
Through standing water 222
Driving abroad 232
Driving and safety systems
4-ETS 83
ABS 80
BAS 82
EBB 84
ESP 84
Driving instructions 216
Passenger compartment 223
Driving off 218
Driving systems 176
Cruise control 176
Driving safety systems 80
Driving through water 227E
Easy-entry/exit feature 100
Activating 142
EBB 80, 84
Electrical fuses 360
Electrical outlet 196
Electrical system
Technical data 372
Electronic Brake Booster (EBB) 84
Electronic Stability Program see ESP
Electronic Traction System (ETS) 83
Emergency call system 198
Emergency calls
Initiating an emergency call 201
With Tele Aid 199
Emergency operation (Limp Home
Mode) 153
Emergency operations
Closing tilt/sliding sunroof 328
Locking the vehicle 326
Opening tilt/sliding sunroof 328
Remote door unlock 205
Unlocking the tailgate 325
Unlocking the vehicle 325
Emergency tensioning device see ETD
Emission control 233Emission control information label 366
Ending
A call (telephone) 146
Engine
Compartment 238
Message in display 292
Starting with SmartKey 49
Technical data 368
Turning off with SmartKey 58
Engine air filter
Messages in display 308
Engine cleaning 282
Engine compartment 238
Hood 238
Engine malfunction indicator
lamp 25, 292
Engine number 382
Engine oil 239, 375
Adding 243
Additives 376
Checking level 239
Consumption 239
Display messages 310
Messages in display 241, 309
Oil dipstick 243
Viscosity 382