2005 MERCEDES-BENZ E320CDI Air condition

463 Technical data
Fuels, coolants, lubricants etc.
Model
Capacity
Fuels, coolants, lubricants etc.
Air conditioning system
R-134a refrigerant and special PAG lubricant oil
(never R-12)
Windshield washer
4.8 US qt (4.5 l)
MB Windshield Washer Concentrate
1
1Use MB Windshield Washer Concentrate “S” and water for temperatures above freezing or MB Windshield Washer Concentrate “S” and commercially available pre-
mixed windshield washer solvent/antifreeze for temperatures below freezing point. Follow suggested mixing ratios (page 469).Windshield washer and head-
lamp cleaning system
7.4 US qt (7.0 l)
MB Windshield Washer Concentrate
1

464 Technical dataFuels, coolants, lubricants etc.Engine oils
Engine oils are specifically tested for their
suitability in our engines and durability for
our service intervals. Therefore, only use
approved engine oils and oil filters re-
quired for vehicles with Maintenance Sys-
tem (U.S. vehicles) or FSS PLUS (Canada
vehicles). For a listing of approved engine
oils and oil filters, refer to the Factory Ap-
proved Service Products pamphlet, or con-
tact an authorized Mercedes-Benz Center.
Using engine oils and oil filters of specifica-
tion other than those expressly required
for the Maintenance System (U.S. vehi-
cles) or FSS PLUS (Canada vehicles), or
changing of oil and oil filter at change inter-
vals longer than those called for by the
Maintenance System (U.S. vehicles) or
FSS PLUS (Canada vehicles) will result in
engine damage not covered by the
Mercedes-Benz Limited Warranty.Please follow Maintenance System (U.S.
vehicles) or FSS PLUS (Canada vehicles)
recommendations for scheduled oil
changes. Failure to do so could result in
engine damage not covered by the
Mercedes-Benz Limited Warranty.
Engine oil additives
Do not blend oil additives with engine oil.
They may damage the engine.
Damage or malfunctions resulting from
blending oil additives are not covered by
the Mercedes-Benz Limited Warranty.Air conditioning refrigerant
R-134a (HFC) refrigerant and special PAG
lubricating oil are used in the air condition-
ing system.
Never use R-12 (CFC) or mineral-based lu-
bricating oil. Otherwise damage to the
system will occur.
Brake fluid
During vehicle operation, the boiling point
of the brake fluid is continuously reduced
through the absorption of moisture from
the atmosphere. Under extremely strenu-
ous operating conditions, this moisture
content can lead to the formation of bub-
bles in the system, thus reducing the sys-
tem’s efficiency.Therefore, the brake fluid
must be replaced every two years, prefera-
bly in the spring.Only brake fluid approved
by Mercedes-Benz is recommended. Your
authorized Mercedes-Benz Center will pro-
vide you with additional information.

471 Technical terms
ABS
(A
ntilock B
rake S
ystem)
Prevents the wheels from locking up
during braking so that the vehicle can
continue to be steered.
ADS
(A
daptive D
amping S
ystem)
Automatically adapts the optimum sus-
pension damping to prevailing driving
conditions.
Airmatic DC
(A
irmatic D
ual C
ontrol)
Automatically selects the optimum sus-
pension tuning and ride height for your
vehicle. Airmatic consists of two com-
ponents:


Adaptive Damping System


Vehicle level control
Alignment bolt
Metal pin with thread. The centering
pin is an aid used when changing a tire
to align the wheel with the wheel hub.BAS
(B
rake A
ssist S
ystem)
System for potentially reducing braking
distances in emergency braking situa-
tions. The system is activated when it
senses an emergency based on how
fast the brake is applied.
Bi-Xenon headlamps*
Headlamps which use an electric arc as
a light source and produce a more in-
tense light than filament headlamps.
Bi-Xenon headlamps produce low
beam and high beam.
CAC
(C
ustomer A
ssistance C
enter)
Mercedes-Benz customer service cen-
ter which can help you with any ques-
tions about your vehicle and provide
assistance in the event of a break-
down.CAN system
(C
ontroller A
rea N
etwork)
Data bus network serving to control ve-
hicle functions such as door locking or
windshield wiping.
CDI
(C
ommon-Rail D
irect I
njection)
Diesel fuel injection technology where
all cylinders share a common diesel
fuel supply line. Fine injection nozzles
provide for highly accurate metering
that reduces diesel fuel consumption.
Cockpit
All instruments, switches, buttons and
indicator/warning lamps in the passen-
ger compartment needed for vehicle
operation and monitoring.

477 Index
A
ABS 85, 471
ABS control 86
Malfunction indicator lamp 356
Messages in display 369
Warning lamp 356
Accelerator position, automatic
transmission* 180
Accessory weight 337
Accident
In case of 54
Activating
Air conditioning (cooling) 201, 214
Air recirculation mode 199, 212
Anti-theft alarm system 94
Automatic climate control
(Dual-zone) 194, 195
Central locking (control system) 166
Defrosting 199
Distance warning function* 244
Distronic* 240
Easy-entry/exit feature* 167ESP 90
Exterior headlamps 50
Exterior lamps 134
Front fog lamps 136
Hazard warning flasher 138
Headlamps 50
High beams 137
Ignition 34
Ignition with KEYLESS-GO* 36
Immobilizer 56, 94
Rear fog lamp 136
Rear window defroster 191
Residual heat 202, 215
Seat heater* 128
Tow-away alarm 95
Windshield wipers 52
Adding
Engine oil 306
Additional turn signal 418
Adjustable air vents, rear passenger
compartment 216Adjusting 37
Air distribution 198, 210
Air volume 198, 211
Backrest tilt 38
Drive-dynamic seat* with multicontour
features 126
Exterior rear view mirror 41
Head restraint height 39
Head restraint tilt 39
Instrument cluster illumination 142
Interior rear view mirror 41
Mirrors 40
Seat cushion tilt 38
Seat fore and aft adjustment 38
Seat height 38
Seats 37
Steering column height 40
Steering wheel 39
Adjusting steering column in or out 40
Adjusting steering column up or down 40
Adjusting the dynamic seat 169

478 IndexAir conditioning (cooling)
Turning off 201, 214
Turning on 201, 214
Air distribution
Adjusting 198, 210
Air pressure 337
Air pressure see Tire inflation
pressure 322
Air pump, electric 430
Air recirculation mode 199, 212
Activating 199, 212
Deactivating 200, 213
Air vents, rear passenger compartment
Adjustable 216
Air volume
Adjusting 198, 211
Airbags 61
Children 62
Front 65
Passenger 65
Safety guidelines 64
Side impact 66
Window curtain 66Airmatic DC (Dual Control)* 247
Alarm
Audible 84, 95
Canceling 95
Visual 94
Alarm system
Anti-theft 94
Alignment bolt (vehicle tool kit) 409,
427, 471
Antilock brake system (ABS) 471
Anti-theft alarm system
Arming 94
Canceling alarm 95
Disarming 95
Anti-theft systems 94
Anti-theft alarm system 94
Immobilizer 94
Tow-away alarm 95
Aquaplaning see Hydroplaning 291Ashtray 268
Aspect ratio 337
At the gas station 299
AUDIO menu 150
Selecting radio station 150
Selecting satellite radio* station 151
Audio system
CD mode 151
Auto-dimming
Automatic 186
Auto-dimming for rear view mirrors 186
Automatic central locking
Activating/deactivating (control
system) 166
Automatic climate control
4-zone automatic climate
control* 204
Dual-zone automatic climate
control 192
Temperature sensor 29

479 Index
Automatic climate control (4-zone*) 204
Adjusting air distribution 210
Adjusting air volume 211
Air conditioning 214
Air recirculation mode 212
Deactivating 209
Defrosting 211
Maximum cooling MAX COOL 212
Rear air conditioning 216
Residual heat and ventilation 215
Setting the temperature 210
Automatic climate control (Dual-zone)
Adjusting air distribution 198
Adjusting air volume 198
Air conditioning 201
Air recirculation mode 199
Defrosting 199
Heater booster system 203
Residual ventilation 202
Setting the temperature 197
Automatic climate control*
Rear window defroster 191
Automatic headlamp mode 134Automatic lighting control
Activating 139
Automatic locking when driving 118
Automatic transmission 174
Emergency operation (Limp Home
Mode) 185
Gear ranges 177
Gear selector lever position 178
Gear shifting malfunctions 185
Manual shift program mode
(E 55 AMG) 183
Manual shifting 176
One-touch gearshifting 176
Program mode selector switch 179
Selector lever position 174
Starting the engine 46
Winter program mode 179
Automatic transmission*
Accelerator position 180
Kickdown 180
Kickdown, manual shift program (E 55
AMG only) 185B
Backrest
Folding forward 257
Folding rearward 258
Bar 337
BAS 87, 471
Batteries, SmartKey
Changing 415, 416
Check lamp 100, 106
Checking 101, 107
Batteries, SmartKey with KEYLESS-GO*
Changing 415, 416
Checking 101, 107
Batteries, vehicle
Charging 435
Disconnecting 434
Messages in display 370, 378, 379
Reconnecting 435
Removing 435
Service 433

482 IndexConvenience submenu 167
Activating easy-entry/exit
feature* 167
Setting parking position for exterior
rear view mirror 168
Setting SmartKey-dependency 168
Coolant
Checking level 308
Messages in display 383, 384, 385
Temperature gauge 143
Warning lamp 361
Coolant temperature 298
Cruise control 231, 472
Canceling 233
Driving downhill 232
Driving uphill 232
Fine adjustment 234
Lever 239
Saving current speed 232
Setting speeds 234Cruise control lever 231
Cup holder in the center console 265
Cup holders 265
Curb weight 337
Customer Assistance Center (CAC) 471
D
Daytime running lamp mode 134
Setting 162
Deactivating
Air conditioning 201
Air recirculation mode 200, 213
Alarm 95
Anti-theft alarm system 95
Automatic climate control
(Dual-zone) 194, 195, 197
Central locking (control system) 166
Cruise control 233
Defrost 199, 211, 212
Distance warning function* 244
Distronic* 242
Engine with KEYLESS-GO* 57ESP 89
Exterior lamps 134
Hazard warning flasher 138
Headlamps 56
Immobilizer 94
Interior lighting delayed
switch-off 165
Manual shift program (E 55 AMG
only) 185
Rear window defroster 191
Residual heat 202
Seat heater* 127
Seat ventilation* 128
SmartKey
Turning off the engine 56
Tow-away alarm 96
Deceleration
With Distronic* 238
Defogging
Windshield 198, 211
Defrosting 199, 211