2005 MERCEDES-BENZ E320CDI transmission operation

356 Practical hintsWhat to do if …Lamps in instrument clusterGeneral information:
If any of the following lamps in the instru-
ment cluster fails to come on during thebulb self-check when switching on the igni-
tion, have the respective bulb checked and
replaced if necessary.Problem
Possible cause
Suggested solution
-
The yellow ABS malfunction indi-
cator lamp comes on while driv-
ing.
The ABS has detected a malfunction and has
switched off. The BAS and the ESP are also
switched off (see messages in display).
The SBC brake system is still functioning nor-
mally but without the ABS available.
If the ABS control unit is malfunctioning, oth-
er systems such as the Parktronic system*,
Distronic*, or the automatic transmission
may also be malfunctioning.

Continue driving with added caution.
Wheels may lock during hard braking,
reducing steering capability.

Read and observe messages in the
display (
page 367).

Have the system checked at an autho-
rized Mercedes-Benz Center as soon
as possible.
Failure to follow these instructions in-
creases the risk of an accident.
The charging voltage has fallen below
10 volts. The ABS has switched off.
The battery may not be sufficiently charged.

Switch off electrical consumers that
are currently not needed, e.g. seat
heating.

If necessary, have the generator and
battery checked.
When the voltage is above this value
again, the ABS is operational again.

474 Technical termsMemory function*
Used to store three individual seat,
steering wheel and exterior mirror posi-
tions for each SmartKey.
MON
(M
otor O
ctane N
umber)
The Motor Octane Number for gasoline
as determined by a standardized meth-
od. It is an indication of a gasoline's
ability to resist undesired detonation
(knocking). The average of both the
MON (Motor Octane Number) and
->RON (Research Octane Number) is
posted at the pump, also known as
ANTI-KNOCK INDEX.
Multifunction display
The display field in the instrument clus-
ter used to present information provid-
ed by the control system.
Multifunction steering wheel
Steering wheel with buttons for operat-
ing the control system.Overspeed range
Engine speeds within the red marking
on the tachometer dial. Avoid this en-
gine speed range, as it may result in se-
rious engine damage that is not
covered by the Mercedes-Benz Limited
Warranty.
Parktronic (Parking assist)*
System which uses visual and acoustic
signals to assist the driver during park-
ing maneuvers.
Poly-V-belt drive
Drives engine-components (alternator,
AC compressor, etc.) from the engine.Power train
Collective term designating all compo-
nents used to generate and transmit
motive power to the drive axles, includ-
ing:


Engine


Clutch/torque converter


Transmission


Transfer case*


Drive shaft


Axle shafts/axles
Program mode selector switch
Used to switch the automatic transmis-
sion between standard operationS and
operationC.
E 55 AMG with steering wheel gearshift
control and manual shift program: in
addition to S and C (for sporty S or
comfortable C operation), you can use
M for manual shift program.

475 Technical terms
PTC heating element
(P
ositive T
emperature C
oefficient)
Electronic component that warms up
quickly as electricity is supplied to it
and is used as a ->heater booster sys-
tem in diesel vehicles.
Restraint systems
Seat belts, belt tensioners, air bags and
child restraint systems. As indepen-
dent systems, their protective func-
tions complement one another.
RON
(R
esearch O
ctane N
umber)
The Research Octane Number for gaso-
line as determined by a standardized
method. It is an indication of a gaso-
line's ability to resist undesired detona-
tion (knocking). The average of both
the ->MON (Motor Octane Number)
and RON (Research Octane Number) is
posted at the pump, also known as
ANTI-KNOCK INDEX.SBC
(S
ensotronic B
rake C
ontrol)
Electronically controlled hydraulic
braking system for increased braking
safety and comfort.
Shift lock
When the vehicle is parked, this lock
prevents the transmission selector le-
ver from being moved out of positionP
without the ignition or engine on and
brake pedal depressed.
SRS
(S
upplemental R
estraint S
ystem)
Seat belts, emergency tensioning de-
vice and air bags. Though independent
systems, they are closely interfaced to
provide effective occupant protection.Tele Aid System
(T
elematic A
larm I
dentification on D
e-
mand)
The Tele Aid system consists of three
types of response: automatic and man-
ual emergency, roadside assistance
and information. Tele Aid is initially ac-
tivated by completing a subscriber
agreement and placing an acquain-
tance call.
The Tele Aid system is operational pro-
vided that the vehicle’s battery is
charged, properly connected, not dam-
aged and cellular and GPS coverage is
available.
Telematics*
A combination of the terms “telecom-
munications” and “informatics”.
Tightening torque
Force times lever arm (e.g. a lug
wrench) with which threaded fasteners
such as wheel bolts are tightened.

479 Index
Automatic climate control (4-zone*) 204
Adjusting air distribution 210
Adjusting air volume 211
Air conditioning 214
Air recirculation mode 212
Deactivating 209
Defrosting 211
Maximum cooling MAX COOL 212
Rear air conditioning 216
Residual heat and ventilation 215
Setting the temperature 210
Automatic climate control (Dual-zone)
Adjusting air distribution 198
Adjusting air volume 198
Air conditioning 201
Air recirculation mode 199
Defrosting 199
Heater booster system 203
Residual ventilation 202
Setting the temperature 197
Automatic climate control*
Rear window defroster 191
Automatic headlamp mode 134Automatic lighting control
Activating 139
Automatic locking when driving 118
Automatic transmission 174
Emergency operation (Limp Home
Mode) 185
Gear ranges 177
Gear selector lever position 178
Gear shifting malfunctions 185
Manual shift program mode
(E 55 AMG) 183
Manual shifting 176
One-touch gearshifting 176
Program mode selector switch 179
Selector lever position 174
Starting the engine 46
Winter program mode 179
Automatic transmission*
Accelerator position 180
Kickdown 180
Kickdown, manual shift program (E 55
AMG only) 185B
Backrest
Folding forward 257
Folding rearward 258
Bar 337
BAS 87, 471
Batteries, SmartKey
Changing 415, 416
Check lamp 100, 106
Checking 101, 107
Batteries, SmartKey with KEYLESS-GO*
Changing 415, 416
Checking 101, 107
Batteries, vehicle
Charging 435
Disconnecting 434
Messages in display 370, 378, 379
Reconnecting 435
Removing 435
Service 433

490 IndexMaintenance service
Calling up the maintenance service
indicator 345
Maintenance service data
information 347
Overdue 343, 344
Resetting maintenance service
indicator 345
Service type A - H 343
Types 343
When due 343
Maintenance service indicator 343
Calling up 345
Clearing 344
Resetting 345
Maintenance Service System 343
Maintenance System (U.S. vehicles) 473
Malfunction
Displaying 153
MANUAL
Shift program mode (E 55 AMG) 183
Manual headlamp mode 134
Manual operations
Fuel filler flap 412
Sliding/pop-up roof* or panorama slid-
ing/pop-up roof* 414Unlocking the driver’s door 410
Unlocking the transmission lever 412
Unlocking the trunk lid 411
Manual shift program (E 55 AMG only)
Deactivating 185
Massage function 127
MAXCOOL maximum cooling 212
Maximum inflation pressure 338
Maximum load rating 338
Maximum loaded vehicle weight 338
Mechanical key 410
Memory function 130, 474
Recalling positions from
memory 131
Storing exterior rear view mirror park-
ing positions 132
Storing SmartKey dependent
settings 131
Menus 148
AUDIO 150
Distronic* 152, 238
In control system 148, 149
Settings menu 154
Standard display 150
Submenus 147
TEL* 171Trip computer 170
Vehicle status message memory 153
Miles/kilometers in speedometer
Setting 157
Mirrors
Adjusting 40
Auto-dimming for rear view
mirrors 186
Exterior rear view mirror 41
Exterior rear view mirror parking
positions 168, 187
Interior rear view mirror 41
Storing exterior mirror parking
position 132
MON 300
MON (Motor Octane Number) 474
Mph or km/h in speedometer 157
Multifunction display 145, 474
Selecting language 158
Standard display 149

493 Index
Power windows 218
Blocking of rear window operation 83
Convenience closing feature 221
Side windows 218
Summer opening feature 220
Synchronizing 220
Practical hints
First aid kit 407
Jump starting 436
Lamp in center console 365
Lamps in instrument cluster 356
Messages in the display 367
Spare wheel 407
Vehicle tool kit 409
Problems
While driving 53
With vehicle 17
Product information 9
Production options weight 338
Program mode selector switch 474
Automatic transmission 179
PSI 338PTC heating element 475
PULSE function (Massage function) 127
Q
Quick search
Phone book* 173
R
Radio
Selecting stations 150
Selecting stations (satellite*) 151
Radio transmitters, control and
operation 295
Range (distance to empty)
Calling up 171
Rear bench seat
Foldable 257
Rear fog lamp
Switching on 137
Rear lamp bulbs 418
Rear lamps see Tail lamps
Rear passenger compartment
Adjustable air vents 216Rear seat head restraints
Installing 125
Removing 125
Rear view mirrors auto-dimming 186
Rear view mirrors see Mirrors 186
Rear window
Blocking operation 83
Rear window defroster 191
Activating 191
Deactivating 191
Rear window sunshade* 189, 190
Recommended inflation pressure 338
Reconnecting
Vehicle battery 435
Regular checks 301
Reinstalling the battery 435
Remote controls
Integrated 281
SmartKey 98, 102
SmartKey with KEYLESS-GO* 102

496 IndexSettings
Calling up Distronic* 152, 238
Convenience functions 167
Factory, KEYLESS-GO* 105
Factory, SmartKey 99
Individual 168
Lighting (control system) 162
Menus and submenus 147
Resetting all (control system) 154
Resetting in the submenu 155
Selective 100, 106
Settings menu
Functions in 154
Individual vehicle settings 154
Submenus 155
Shift lock 475
Shifting
Gear selector lever positions 178
Into optimal gear range (automatic
transmission) 176
Side impact airbags 66
Side marker lamps 418, 422Side windows
Automatic opening 219
Cleaning 352
Closing 218, 219
Opening 218
Opening fully (Express-open) 219
Stopping 220
Synchronizing power windows 220
Sidewall 338
Simultaneous wiping and washing
Windshield wipers 52
Single wipe 52
Ski sack* 254
Removing 257
Unfolding and loading 254
Unloading and folding 256
Sliding/pop-up roof* 223
Closing 223
Opening 223
Stopping 225, 229
Synchronizing 225
Sliding/pop-up roof* or panorama slid-
ing/pop-up roof*
Emergency operations 414SmartKey 98
Battery check lamp 100, 106
Checking the batteries 101, 107
Factory setting 99
Global locking 100
Global locking and unlocking 99
Global unlocking 99
Locking and unlocking 98
Loss of 102
positions in starter switch 33
Remote controls 98, 102
Restoring to factory setting 100, 106
Selective setting 100, 106
Starting the engine 46, 47
Unlocking with 32
SmartKey with KEYLESS-GO* 102
Global locking and unlocking 105
Loss of 108
Messages in display 391
Remote controls 102
Turning off the engine 57
Unlocking with 33
SmartKey-dependent memory
Settings 168