2005 MERCEDES-BENZ C320 air condition

309 Practical hints
What to do if …
Vehicle status messages in the multifunction display
Warning and malfunction messages
appear in the multifunction display located
in the instrument cluster.
Certain warning and malfunction messag-
es are accompanied by an audible signal.
Address these messages accordingly and
follow the additional instructions given in
this Operator’s Manual.
Selecting the vehicle status message
memory menu in the control system
(page 130) displays both cleared and
uncleared messages.
High-priority messages appear in the
multifunction display in red color.
Certain messages of high priority cannot
be cleared from the multifunction display
using the reset button (
page 117).Other messages of high priority and
messages of less immediate priority can
be cleared from the multifunction display
using the reset button (
page 117). They
are then stored in the vehicle status mes-
sage memory (
page 130). Remember
that clearing a message will only make the
message disappear. Clearing a message
will not correct the condition that caused
the message to appear.
On the pages that follow, you will find a
compilation of the most important warning
and malfunction messages that may
appear in the multifunction display. High
priority messages appear in red color.
Warning!
G
All categories of messages contain
important information which should be
taken note of and, where a malfunction is
indicated, addressed as soon as possible at
an authorized Mercedes-Benz Center.
Failure to repair condition noted may cause
damage not covered by the Mercedes-Benz
Limited Warranty, or result in property
damage or personal injury.
Warning!
G
No messages will be displayed if either the
instrument cluster or the multifunction
display is inoperative.
Contact your nearest authorized
Mercedes-Benz Center.iSwitching on ignition, causes all lamps
as well as the multifunction display to
come on. Make sure that they are all in
working order before starting your jour-
ney.

353 Practical hints
Flat tire
Flat tire
Preparing the vehicle
Park the vehicle as far as possible from
moving traffic on a hard surface.

Turn on the hazard warning flasher
(page 114).

Turn the steering wheel so that the
front wheels are in a straight ahead
position.

Set the parking brake (
page 54).

Move the gear selector lever toP
(manual transmission to first or reverse
gear).

Turn off the engine (
page 56).

Remove the SmartKey from the starter
switch.

Have any passenger exit the vehicle at
a safe distance from the roadway.
Mounting the spare wheel
Preparing the vehicle
Prepare the vehicle as described
(page 353).
Vehicles with Minispare wheel:

Take the wheel wrench, the wheel
bolts, and the jack out of the trunk
(page 329).

Take the Minispare wheel out of the
trunk (
page 333).
Vehicles with collapsible tire
(C 55 AMG only):

Take the collapsible tire, wheel wrench,
wheel bolts, jack, and electric air pump
out of the trunk (
page 330).
Warning!
G
The dimensions of the spare wheel
(Minispare or collapsible tire) are different
from those of the road wheels. As a result,
the vehicle handling characteristics change
when driving with a spare wheel mounted.
Adapt your driving style accordingly.
The spare wheel is for temporary use only.
When driving with spare wheel mounted,
ensure proper tire pressure and do not ex-
ceed a vehicle speed of 50 mph (80 km/h).
Drive to the nearest Mercedes-Benz Center
as soon as possible to have the spare wheel
replaced with a regular road wheel.
Never operate the vehicle with more than
one spare wheel mounted.
iOpen doors only when conditions are
safe to do so.

377 Technical data
Layout of poly-V-belt drive
Layout of poly-V-belt drive
C 230 Kompressor (all models)
1Power steering pump
2Idler pulley
3Supercharger
4Automatic belt tensioner
5Air conditioning compressor
6Crankshaft
7Coolant pump
8Generator (alternator)C 240 (all models)/C 320 (all models)/
C55AMG
1Automatic belt tensioner
2Power steering pump
3Air conditioning compressor
4Crankshaft
5Coolant pump
6Generator (alternator)
7Idler pulley

389 Technical data
Fuels, coolants, lubricants, etc.
Model
Capacity
Fuels, coolants, lubricants, etc.
Air conditioning system
R-134a refrigerant and special PAG lubricant oil
(never R-12)
Windshield washer
3.2 US qt (3.0 l)
MB Windshield Washer Concentrate
1
Windshield washer and
headlamp cleaning system*
6.4 US qt (6.0 l)
1Use MB Windshield Washer Concentrate “S” and water for temperatures above freezing point or MB Windshield Washer Concentrate “S” and commercially available
premixed windshield washer solvent/antifreeze for temperatures below freezing point. Follow suggested mixing ratios (page 396).

390 Technical dataFuels, coolants, lubricants, etc.Engine oils
Engine oils are specifically tested for their
suitability in our engines and durability for
our service intervals. Therefore, only use
approved engine oils and oil filters
required for vehicles with Maintenance
System (U.S. vehicles) or FSS (Canada
vehicles). For a listing of approved engine
oils and oil filters, refer to the Factory
Approved Service Products pamphlet, or
contact an authorized Mercedes-Benz
Center.
Using engine oils and oil filters of
specification other than those expressly
required for the Maintenance System
(U.S. vehicles) or FSS (Canada vehicles), or
changing of oil and oil filter at change
intervals longer than those called for by
the Maintenance System (U.S. vehicles) or
FSS (Canada Vehicles) will result in engine
damage not covered by the
Mercedes-Benz Limited Warranty.Please follow Maintenance System
(U.S. vehicles) or FSS (Canada vehicles)
recommendations for scheduled oil
changes. Failure to do so will result in
engine damage not covered by the
Mercedes-Benz Limited Warranty.
Engine oil additives
Do not blend oil additives with engine oil.
They may damage the engine.
Damage or malfunctions resulting from
blending oil additives are not covered by
the Mercedes-Benz Limited Warranty.Air conditioning refrigerant
R-134a (HFC) refrigerant and special PAG
lubricating oil is used in the air
conditioning system.
Never use R-12 (CFC) or mineral-based
lubricating oil. Otherwise damage to the
system will occur.
Brake fluid
During vehicle operation, the boiling point
of the brake fluid is continuously reduced
through the absorption of moisture from
the atmosphere. Under extremely strenu-
ous operating conditions, this moisture
content can lead to the formation of
bubbles in the system, thus reducing the
system’s efficiency.
Therefore, the brake fluid must be
replaced every two years, preferably in the
spring.
Only brake fluid approved by
Mercedes-Benz is recommended. Your
authorized Mercedes-Benz Center will
provide you with additional information.

399 Technical terms
ABS
(A
ntilock B
rake S
ystem)
Prevents the wheels from locking up
during braking so that the vehicle can
continue to be steered.
Alignment bolt
Metal pin with thread. The centering
pin is an aid used when changing a tire
to align the wheel with the wheel hub.
BabySmart
TM1
air bag deactivation
system
This system detects if a special system
compatible child restraint seat is
installed on the front passenger seat.
The system will automatically
deactivate the passenger front air bag
when such a seat is properly installed
(the56indicator lamp located
in the center console comes on). See
an authorized Mercedes-Benz Center
for availability. BabySmart
TM compatible child seats
Special restraint system for children.
The sensor system for the passenger
seat prevents deployment of the
passenger front air bag if a
BabySmartTM compatible child seat is
installed.
BAS
(B
rake A
ssist S
ystem)
System for potentially reducing braking
distances in emergency braking
situations. The system is activated
when it senses an emergency based on
how fast the brake is applied.
Bi-Xenon headlamps*
Headlamps which use an electric arc as
the light source and produce a more
intense light than filament headlamps.
Bi-Xenon headlamps produce low
beam and high beam.CAC
(C
ustomer A
ssistance C
enter)
Mercedes-Benz customer service
center, which can help you with any
questions about your vehicle and
provide assistance in the event of a
breakdown.
CAN system
(C
ontroller A
rea N
etwork)
Data bus network serving to control
vehicle functions such as door locking
or windshield wiping depending on
vehicle settings and/or ambient
conditions.
Cockpit
All instruments, switches, buttons and
indicator/warning lamps in the
passenger compartment needed for
vehicle operation and monitoring.
1BabySmart
TM is a trademark of Siemens
Automotive Corp.

405 Index
A
ABS 77, 399
ABS control 77
Indicator lamp 25
Malfunction indicator lamp 302
Messages in display 310
Accelerator position,
automatic transmission* 163
Accident
In case of 53
Activating
Air conditioning (cooling) 181
Air recirculation mode 179
Anti-theft alarm system* 84
Central locking (control system) 145
Climate control 175
Climate control system 177
Defrosting 178
Easy-entry/exit feature* 146
Electric air pump 358
ESP 81Exterior headlamps 49
Exterior lamps 110
Exterior rear view mirror
parking position* 170
Hazard warning flasher 114
Headlamps 49
High beam headlamps 50
High beams 113
Ignition 33
Immobilizer 56, 83
Low beam headlamps 49
Manual shift program
(C 55 AMG only) 166
Rear window defroster 173
Seat heating* 105
Tow-away alarm* 85
Windshield wipers 51
Adding
Coolant 283
Engine oil 281
Additional turn signals 345
Adjustable air vents,
rear passenger compartment 182Adjusting 35
Air distribution 178
Air volume 178
Backrest contour 104
Backrest side bolsters 104
Backrest tilt, manual seat 36
Backrest tilt, power seat* 38
Exterior rear view mirrors 41
Folding back rear seat
head restraints, electrical 102
Folding back rear seat
head restraints, manual 102
Head restraint height,
manual seat 37
Head restraint height,
power seat* 38
Head restraint height, rear seats 101
Head restraint tilt, manual seat 37
Head restraint tilt, power seat* 39
Head restraint tilt, rear seats 103
Instrument cluster illumination 117
Interior rear view mirror 41
Manual seat 36
Mirrors 41

406 Index
Multicontour seat* 104
Placing upright rear seat
head restraints 102
Power seat* 38
Rear seat head restraints 101
Seat belt height 45
Seat cushion depth 104
Seat cushion tilt, manual seat 36
Seat cushion tilt, power seat* 38
Seat fore and aft adjustment,
manual seat 36
Seat fore and aft adjustment,
power seat* 38
Seat height, manual seat 36
Seat height, power seat* 38
Seats 35
Steering column height,
electrical* 41
Steering column height,
manual 40
Steering column length,
electrical* 41
Steering column length,
manual 40
Steering wheel 39Adjusting air distribution
and volume 178
Adjusting sound functions 187
Adjusting the volume 187
Aids for changing fuses 369
Air bags 59
BabySmart
TM deactivation
system 70, 399
Children 60
Front 63
Passenger 63
Safety guidelines 62
Side impact 64
Window curtain 64
Air conditioning (cooling) 181
Turning off 181
Turning on 181
Air conditioning refrigerant 390
Air distribution
Adjusting 178
Air pressure see Tire inflation pressure
Air pump, electric
Turning on 358Air recirculation mode 179
Activating 179
Deactivating 180
Air vents, rear passenger compartment
Adjustable 182
Air volume
Adjusting 178
Alarm
Audible 76, 83
Canceling 84, 86
Visual 83
Alarm system
Anti-theft* 83
Tow-away* 85
Alignment bolt (vehicle tool kit) 355, 399
Anticorrosion/antifreeze 395
Antiglare
Automatic* 169
Manual 168
Antilock Brake System see ABS
Anti-theft alarm system*
Arming 84
Canceling alarm 84
Disarming 84