2005 MERCEDES-BENZ C240 fluid

363 Practical hints
Jump starting
Jump starting
If the battery is discharged, the engine can
be started with jumper cables and the
battery of another vehicle. Observe the
following:

Jump starting should only be performed
when the engine and catalytic con-
verter are cold.


Do not start the engine if the battery is
frozen. Let the battery thaw out first.


Only jump start from batteries with the
same voltage rating (12 V). Jump
starting with a more powerful battery
could damage the vehicle’s electrical
system, which will not be covered by
the Mercedes-Benz Limited Warranty.


Only use jumper cables with sufficient
cross-section and insulated terminal
clamps.


Always make sure the jumper cables
are not on or near pulleys, fans, or oth-
er parts that move when an engine is
started or running.
Warning!
G
Failure to follow these directions will cause
damage to the electronic components, and
can lead to a battery explosion and severe
injury or death.
Never lean over batteries while connecting
or jump starting, you might get injured.
Battery fluid contains sulfuric acid. Do not
allow this fluid to come in contact with eyes,
skin or clothing. In case it does, immediately
flush affected area with water, and seek
medical help if necessary.
A battery will also produce hydrogen gas,
which is flammable and very explosive. Keep
flames or sparks away from battery, avoid
improper connection of jumper cables,
smoking, etc.
Attempting to jump start a frozen battery
can result in it exploding, causing personal
injury.
Read all instructions before proceeding.
!Jump starting may only be performed
on the battery installed in the engine
compartment.
Avoid repeated and lengthy starting
attempts.
Do not attempt to start the engine
using a battery quick charge unit.
If engine does not run after several
unsuccessful starting attempts, have it
checked at the nearest authorized
Mercedes-Benz Center.
Excessive unburned fuel generated by
repeated failed starting attempts may
damage the catalytic converter and
may present a fire risk.
Make sure the jumper cables do not
have loose or missing insulation.
Make sure the cable clamps do not
touch any other metal part while the
other end is still attached to a battery.

387 Technical data
Fuels, coolants, lubricants, etc.
Fuels, coolants, lubricants, etc.
Capacities
Vehicle components and their respectivelubricants must match. Therefore only use
brands tested and approved by
Mercedes-Benz. Please refer to the Factory Approved
Service Products pamphlet, or inquire at
your Mercedes-Benz Center.
Model
Capacity
Fuels, coolants, lubricants, etc.
Engine with oil filter
C 230 Kompressor (all models)
C240
C2404MATIC
C320
C3204MATIC
C320Sport
C55AMG
5.8 US qt (5.5 l)
7.9 US qt (7.5 l)
7.4 US qt (7.0 l)
7.9 US qt (7.5 l)
7.4 US qt (7.0 l)
7.9 US qt (7.5 l)
9.0 US qt (8.5 l)
Approved engine oils
Automatic transmission
C 230 Kompressor (all models)
C240 (all models)
C320 (all models)
C55AMG
8.5 US qt (8.0 l)
8.5 US qt (8.0 l)
8.5 US qt (8.0 l)
9.3 US qt (8.7 l)
MB Automatic Transmission Fluid
Manual transmission
1.3 US qt (1.2 l)
MB Manual Transmission Oil
Rear axle
C 230 Kompressor (all models)
C240 (all models)
C320 (all models)
C55AMG
1.2 US qt (1.1 l)
1.2 US qt (1.1 l)
1.2 US qt (1.1 l)
1.5 US qt (1.4 l)
Hypoid gear oil SAE 85 W 90

388 Technical dataFuels, coolants, lubricants, etc.
Model
Capacity
Fuels, coolants, lubricants, etc.
Front axle
C2404MATIC
C3204MATIC
0.5 US qt (0.46 l)
Hypoid gear oil SAE 85 W 90
Transfer case
C2404MATIC
C3204MATIC
approx. 0.62 US qt (0.59 l)
MB Transfer case fluid
Power steering
approx. 1.1 US qt (1.0 l)
MB Power Steering Fluid (Pentosin CHF 11S)
Front wheel hubs
approx. 2.1 oz (60 g) each
High temperature roller bearing grease
Brake system
0.5 US qt (0.5 l)
MB Brake Fluid (DOT 4+)
Cooling system
C 230 Kompressor (all models)
C240 (all models)
C320 (all models)
C55AMG
approx. 5.9 US qt (5.6 l)
approx. 6.8 US qt (6.4 l)
approx. 6.8 US qt (6.4 l)
approx. 12.8 US qt (12.0 l)
MB 325.0 Anticorrosion/antifreeze agent
Fuel tank
including
a reserve of
16.4 US gal (62.0 l)
2.1 US gal (8.0 l)
Premium unleaded gasoline:
Minimum Posted Octane 91
(Avg. of 96 RON/86 MON)Flexible Fuel Vehicle (identified by a label
reading Premium gasoline or E85 only! on
fuel filler flap):
Alternative fuel: Ethanol fuel (E85)

390 Technical dataFuels, coolants, lubricants, etc.Engine oils
Engine oils are specifically tested for their
suitability in our engines and durability for
our service intervals. Therefore, only use
approved engine oils and oil filters
required for vehicles with Maintenance
System (U.S. vehicles) or FSS (Canada
vehicles). For a listing of approved engine
oils and oil filters, refer to the Factory
Approved Service Products pamphlet, or
contact an authorized Mercedes-Benz
Center.
Using engine oils and oil filters of
specification other than those expressly
required for the Maintenance System
(U.S. vehicles) or FSS (Canada vehicles), or
changing of oil and oil filter at change
intervals longer than those called for by
the Maintenance System (U.S. vehicles) or
FSS (Canada Vehicles) will result in engine
damage not covered by the
Mercedes-Benz Limited Warranty.Please follow Maintenance System
(U.S. vehicles) or FSS (Canada vehicles)
recommendations for scheduled oil
changes. Failure to do so will result in
engine damage not covered by the
Mercedes-Benz Limited Warranty.
Engine oil additives
Do not blend oil additives with engine oil.
They may damage the engine.
Damage or malfunctions resulting from
blending oil additives are not covered by
the Mercedes-Benz Limited Warranty.Air conditioning refrigerant
R-134a (HFC) refrigerant and special PAG
lubricating oil is used in the air
conditioning system.
Never use R-12 (CFC) or mineral-based
lubricating oil. Otherwise damage to the
system will occur.
Brake fluid
During vehicle operation, the boiling point
of the brake fluid is continuously reduced
through the absorption of moisture from
the atmosphere. Under extremely strenu-
ous operating conditions, this moisture
content can lead to the formation of
bubbles in the system, thus reducing the
system’s efficiency.
Therefore, the brake fluid must be
replaced every two years, preferably in the
spring.
Only brake fluid approved by
Mercedes-Benz is recommended. Your
authorized Mercedes-Benz Center will
provide you with additional information.

396 Technical dataFuels, coolants, lubricants, etc.Windshield washer and headlamp cleaning system*
Both the windshield washer and headlamp
cleaning system* are supplied from the
windshield washer fluid reservoir.
The washer fluid reservoir has a capacity of
approx.:

3.2 US qt (3.0 l) in vehicles without
headlamp cleaning system*


6.4 US qt (6.0 l) in vehicles with
headlamp cleaning system*

Refill the reservoir with MB Windshield
Washer Concentrate “S” and water
(or concentrate and commercially
available premixed windshield washer
solvent/antifreeze, depending on
ambient temperatures).Windshield and headlamp washer fluid
mixing ratio
For temperatures above freezing point, use
MB Windshield Washer Concentrate “S”
and water:


1 part “S” to 100 parts water
(1.34floz [40ml]“S” to 1gallon [4.0l]
water)
For temperatures below freezing point, use
MB Windshield Washer Concentrate “S”
and commercially available premixed
windshield washer solvent/antifreeze:


1 part “S” to 100 parts solvent
(1.34floz [40ml]“S” to 1gallon [4.0l]
solvent)
Warning!
G
Washer solvent/antifreeze is highly flamma-
ble. Do not spill washer solvent/antifreeze
on hot engine parts, because it may ignite
and burn. You could be seriously burned.

407 Index
Anti-theft systems 83
Anti-theft alarm system* 83
Immobilizer 83
Tow-away alarm* 85
Aquaplaning see Hydroplaning
Armrest
Changing inclination of 242
Storage spaces 242
Armrest in rear passenger
compartment 243
Ashtrays 245
ATF 282
AUDIO menu 127
Selecting radio station 128
Selecting satellite radio* station 128
Audio system 183
Audio and telephone, operation 183
Button and soft key operation 186
CD* operation 201
Operating and display elements 184
Operating safety 183Operation 186
Radio operation 191
Switching off 187
Switching on 186
Telephone* operation 208
Automatic antiglare* for rear view
mirror 169
Automatic central locking
Activating/deactivating (control
system) 145
Automatic headlamp mode 110
Automatic lighting control
Activating 115
Deactivating 115
Automatic locking when driving 96
Automatic shift program
Automatic transmission* 162
Automatic time change (Daylight Saving
Time (DST) summer/winter) 139
Automatic Transmission Fluid see ATFAutomatic transmission* 156
Accelerator position 163
Automatic shift program 162
Emergency operation
(Limp Home Mode) 167
Fluid level 282
Gear ranges 159
Gear selector lever 47, 156
Gear selector lever position 156, 160
Gear shifting malfunctions 167
Kickdown 163
Kickdown, manual shift program
(C 55 AMG only) 167
Manual shift program
(C 55 AMG only) 165
Manual shifting 158
One-touch gearshifting 158
Program mode selector switch,
automatic shift program 162
Program mode selector switch,
manual shift program
(C 55 AMG only) 166

408 Index
Starting with 47
Steering wheel gearshift control
(C 55 AMG only) 164
Transmission fluid 282
B
BabySmart
TM
Air bag deactivation system 70, 399
Compatible child seats 70, 399
Self-test 70
Backrest
Folding forward 238
Folding rearward 238
Backrest contour
Adjusting 104
Backrest side bolsters
Adjusting 104
Backrest tilt
Manual seat 36
Power seat* 38
Backup lamps
Messages in display 323
Replacing bulbs 345BAS 78, 399
Messages in display 311
Batteries, SmartKey
Changing 343
Check lamp 90
Checking 91
Battery discharged
Jump starting 363
Battery, vehicle 284, 360
Charging 361
Disconnecting 361
Reconnecting 362
Reinstalling 361
Removing 361
Bi-Xenon headlamps* 399
Bi-Xenon type*
Front lamp bulbs 349
Block heater (Canada only) 291
Blocking
Rear door window operation 75
Bolts
For spare wheel 336Brake Assist System see BAS
Brake fluid 390
Checking 277
Message in display 315
Brake lamp bulbs 345
Brake lamp, high mounted 345
Brake lamps
Messages in display 323
Brake pads
Message in display 315
Brakes 266
Warning lamp 25, 303
Break-in period 264
Bulbs, replacing 344
Additional turn signals 345
Backup lamps 345, 351
Brake lamps 345, 351
Fog lamp, rear 345, 351
Fog lamps, front 345
Front lamps 345
High beam flasher 345
High beam headlamps 345

410 IndexCharging
Vehicle battery 361
Checking
Brake fluid 277
Coolant level 277, 283
Engine oil level 277, 280
Tire inflation pressure 277
Vehicle lighting 277
Washer reservoir level 277
Child safety 67
Air bags 60
Infant and child restraint
systems 64, 67
LATCH-type child seat anchors 73
Child safety switch see
Blocking of rear door window operation
Child seat anchors see
LATCH-type child seat anchors
Cigarette lighter 246
Cleaning
Cloth upholstery 300
Cup holders 299
Gear selector lever 299Hard plastic trim items 299
Headlamps 168
Headliner and shelf below
rear window 299
Instrument cluster 298
Leather upholstery 299
Light alloy wheels 298
MB Tex upholstery 300
Plastic and rubber parts 300
Seat belts 299
Steering wheel 299
Upholstery 299
Windows 298
Windshield 52
Wiper blades 298
Wood trims 300
Climate control 174
Clock 25, 121, 137, 138
Closing
Cup holder, in rear seat armrest 245
Glove box 241
Hood 279Tilt/sliding sunroof* 227
Tilt/sliding sunroof*
in an emergency 341
Tilt/sliding sunroof*
with SmartKey 229
Trunk lid 94
Windows 223, 224
Windows with SmartKey 225
Cloth upholstery
Cleaning 300
Cockpit 22, 399
Cockpit Management and
Data System see COMAND*
Collapsible tire 383
Collapsible tire (C 55 AMG only) 334
Collapsible wheel chock 332
COMAND* 400
COMAND* see separate
operating instructions
Combination switch 113
High beam flasher 50
Turn signals 50
Windshield wipers 51