2005 MAZDA MODEL RX 8 overheating

Black plate (216,1)
14. Install the compressor hose to the tire
valve.
Valve
Compressor hose
15. Insert the compressor plug into the
interior accessory socket and turn the
ignition switch to the ACC position
(page 6-50).
Compressor
Center console Compressor
plug
CAUTION
lBefore pulling out the compressor
plug from the electrical socket, make
sure the compressor power switch is
off.
lThe compressor turns on and off
with the push-button switch.16. Turn the compressor switch on and
inflate the tire carefully to the correct
inflation pressure.
WARNING
Operating the Compressor:
Operating the compressor above 300
kPa (3.1 kgf/cm
2, 3 bar, 43.5 psi) is
dangerous. When the inflation
pressure rises above 300 kPa (3.1 kgf/
cm
2, 3 bar, 43.5 psi), heated air will be
exhausted from the back of the
compressor and you could be burned.
Never operate the compressor above
300 kPa (3.1 kgf/cm
2, 3 bar, 43.5 psi).
CAUTION
If the compressor operates slowly or
becomes hot, it indicates overheating.
Turn the compressor off immediately
and leave it turned off for 30 minutes or
longer.
7-10
In Case of an Emergency
Flat Tire
RX-8_8T69-EA-04G_Edition1 Page216
Wednesday, June 9 2004 2:12 PM
Form No.8T69-EA-04G

Black plate (224,1)
Overheating
If the temperature gauge indicates
overheating, the vehicle loses power, or
you hear a loud knocking or pinging
noise, the engine is probably too hot.
WARNING
Electrical Fan and Engine
Inspection:
Working near the electrical cooling
fan when it is running is dangerous.
You could be hit by the fan and
seriously injured. Turn off the ignition
switch and make sure the fan is not
running before attempting to work
near the electrical cooling fan.
Cooling System Cap:
When the engine and radiator are hot,
scalding coolant and steam may shoot
out under pressure and cause serious
injury. Don't remove the cooling
system cap when the engine and
radiator are hot.
Steam from Overheated Engine:
Steam from an overheated engine is
dangerous. The escaping steam could
seriously burn you. Open the hood
ONLY after steam is no longer
escaping from the engine.
NOTE
Once the engine coolant exceeds a
preset temperature, an electrical cooling
fan turns on. It will continue running
for about 10 minutes after the ignition
switch is turned to off.
If the temperature gauge indicates
overheating:
1. Drive safely to the side of the road and
park off the right-of-way.
2. Put a vehicle with an automatic
transmission in park (P), a manual
transmission in neutral.
Apply the parking brake.
3. Turn off the air conditioner.
4. Check whether coolant or steam is
escaping from under the hood or from
the engine compartment.
If steam is coming from the engine
compartment:
Don't go near the front of the vehicle.
Stop the engine.
Wait until the steam dissipates, then
open the hood and start the engine.
If neither coolant nor steam is
escaping:
Open the hood and idle the engine until
it cools.
CAUTION
If the cooling fan does not operate
while the engine is running, the engine
temperature will increase. Stop the
engine and call an Authorized Mazda
Dealer.
7-18
In Case of an Emergency
Overheating
RX-8_8T69-EA-04G_Edition1 Page224
Wednesday, June 9 2004 2:12 PM
Form No.8T69-EA-04G

Black plate (225,1)
5. Make sure the cooling fan is operating,
then turn off the engine after the
temperature has decreased.
6. When cool, check the coolant level.
If it's low, look for coolant leaks from
the radiator and hoses.
If you find a leak or other damage, or if
coolant is still leaking:
Stop the engine and call an Authorized
Mazda Dealer.
If you find no problems, the engine is
cool, and no leaks are obvious:
Carefully add coolant as required (page
8-15).
CAUTION
If the engine continues to overheat or
frequently overheats, have the cooling
system inspected. The engine could be
seriously damaged unless repairs are
made. Consult an Authorized Mazda
Dealer.
In Case of an Emergency
Overheating
7-19
RX-8_8T69-EA-04G_Edition1 Page225
Wednesday, June 9 2004 2:12 PM
Form No.8T69-EA-04G

Black plate (317,1)
D
Dashboard Illumination .................... 5-35
Daytime Running Lights ................... 5-50
Defroster
Rear window .............................. 5-54
Dimensions ....................................... 10-5
Door Locks ......................................... 3-8
Driving In Flooded Area ................... 4-11
Driving Tips ........................................ 4-7
Automatic transmission .............. 5-16
Break-in period ............................ 4-7
Driving in flooded area .............. 4-11
Hazardous driving ........................ 4-8
Money-saving suggestions ........... 4-7
Rocking the vehicle ...................... 4-8
Winter driving .............................. 4-9
Dynamic Stability Control (DSC) ..... 5-22
DSC OFF indicator light ............ 5-23
DSC OFF switch ........................ 5-24
TCS/DSC Indicator light ............ 5-23
E
Emergency Starting ........................... 7-20
Flooded engine ........................... 7-20
Jump-starting .............................. 7-21
Push-starting .............................. 7-24
Emergency Towing ........................... 7-25
Emission Control System .................... 4-3
Engine
Coolant ....................................... 8-15
Exhaust gas .................................. 4-5
Hood release .............................. 3-21
Oil .............................................. 8-12
Overheating ................................ 7-18
Starting ......................................... 5-3
Engine Compartment Overview ........ 8-11
Engine Coolant
Overheating ................................ 7-18
E
Engine Coolant Temperature
Gauge ................................................ 5-33
Exhaust Gas ........................................ 4-5
Exterior Care ..................................... 8-47
F
Flasher
Hazard warning .......................... 5-56
Headlights .................................. 5-49
Flat Tire ............................................... 7-3
Changing .................................... 7-12
Instant Mobility System
(IMS) Emergency Flat Tire Repair
Kit ................................................ 7-5
Spare tire and tool storage ............ 7-3
Fluids
Classification .............................. 10-4
Owner maintenance ..................... 8-8
Fog Lights ......................................... 5-51
Foot Brake .......................................... 5-4
Front Seats
(Electrically Operated Seats) ............... 2-5
Front Seats
(Manually Operated Seats) ................. 2-2
Fuel
Filler lid and cap ........................ 3-19
Gauge ......................................... 5-34
Requirements ............................... 4-2
Tank capacity ............................. 10-5
Fuses ................................................. 8-40
Panel description ........................ 8-42
Replacement ............................... 8-40
G
Gauges .............................................. 5-30
Glove Box ......................................... 6-47
Index
11-3
RX-8_8T69-EA-04G_Edition1 Page317
Wednesday, June 9 2004 2:13 PM
Form No.8T69-EA-04G

Black plate (319,1)
M
Manual Transmission Operation ......... 5-8
Recommendations for shifting ..... 5-9
Map Lights ........................................ 6-40
Meters and Gauges ........................... 5-30
Mirrors
Outside mirrors .......................... 3-29
Rearview mirror ......................... 3-30
Money-Saving Suggestions ................ 4-7
Moonroof .......................................... 3-22
O
Odometer and Trip Meter .................. 5-31
Outside Mirrors ................................. 3-29
Overhead Console ............................. 6-47
Overhead Lights ................................ 6-40
Overheating ....................................... 7-18
Overloading ...................................... 4-11
P
Paint Damage .................................... 8-45
Parking Brake ..................................... 5-5
Parking in an Emergency .................... 7-2
Power Door Locks .............................. 3-9
Power Steering .................................. 5-16
Power steering malfunction indicator
light ............................................ 5-16
Power Windows ................................ 3-16
Push-Starting ..................................... 7-24
R
Rear Quarter Windows ..................... 3-18
Rear Seat ............................................. 2-8
Rear Window Defroster .................... 5-54
Rearview Mirror ................................ 3-30
Recreational Towing ......................... 7-27
R
Registering Your Vehicle in A Foreign
Country ............................................. 9-12
Rocking the Vehicle ............................ 4-8
S
Safety Defects, Reporting ................. 9-18
Seat Belt System
3-point type ................................ 2-14
Automatic locking ...................... 2-12
Emergency locking .................... 2-12
Extender ..................................... 2-17
Location of seat belt ................... 2-13
Pregnant women ........................ 2-12
Pretensioner and load limiting .... 2-15
Seat belt precautions .................. 2-10
Warning beep ............................. 2-19
Warning light ............................. 2-18
Seats
Front seat
(Electrically operated seats) ......... 2-5
Front seat
(Manually operated seats) ............ 2-2
Rear seat ....................................... 2-8
Security System
Immobilizer system .................... 3-24
Theft-deterrent system ............... 3-27
Service Publications .......................... 9-19
Spare Tire and Tool Storage ................ 7-3
Specifications .................................... 10-4
Speed Unit Selector ........................... 5-31
Speedometer ...................................... 5-31
SRS Air Bags
Air bag system description ......... 2-34
Supplemental restraint systems
precautions ................................. 2-29
Warning light ............................. 2-38
Starting the Engine .............................. 5-3
Index
11-5
RX-8_8T69-EA-04G_Edition1 Page319
Wednesday, June 9 2004 2:13 PM
Form No.8T69-EA-04G