2005 MAZDA MODEL MX-5 run flat

Black plate (40,1)
lRear-ending or running under a truck's
tail gate may not provide the stopping
force necessary for air bag deployment.
Non-activation of air bags
Air bags will not normally inflate in the
following cases:
lCollision from the rear.
lImpact to the side.
lVehicle roll-over.
qConstant Monitoring
The following components of the air bag
systems are monitored by a diagnostic
system:
lSAS unit
lCrash sensor
lAir bag modules
lSeat belt pretensioners
lRelated wiring
lPassenger air bag deactivation switch
A diagnostic module continuously
monitors the systems' readiness. This
begins when the ignition switch is turned
to the ON position and continues while
the vehicle is being driven.
qAir Bag/Seat Belt Pretensioner
System Warning Light
If the air bag/seat belt pretensioner system
is normal, the warning light illuminates
when the ignition switch is turned to the
ON position or after the engine is cranked.
After about 6 seconds it goes out.
2-28
Essential Safety Equipment
SRS Air Bags
MX-5 Miata_8T72-EA-04G_Edition1 Page40
Wednesday, June 9 2004 3:4 PM
Form No.8T72-EA-04G

Black plate (86,1)
Break-In Period
No special break-in is necessary, but a few
precautions in the first 1,000 km (600
miles) may add to the performance,
economy, and life of your Mazda.
lDon't race the engine.
lDon't maintain one constant speed,
either slow or fast, for a long period of
time.
lDon't drive constantly at full-throttle or
high engine rpm for extended periods
of time.
lAvoid unnecessary hard stops.
lAvoid full-throttle starts.
Money-Saving Suggestions
How you operate your Mazda determines
how far it will travel on a tank of fuel. Use
these suggestions to help save money on
fuel and repairs.
lAvoid long warm-ups. Once the engine
runs smoothly, begin driving.
lAvoid fast starts.
lKeep the engine tuned. Follow the
maintenance schedule (page 8-3) and
have an Authorized Mazda Dealer
perform inspections and servicing.
lUse the air conditioner only when
necessary.
lSlow down on rough roads.
lKeep the tires properly inflated.
lDon't carry unnecessary weight.
lDon't rest your foot on the brake pedal
while driving.
lKeep the wheels in correct alignment.
lKeep windows closed at high speeds.
lSlow down when driving in crosswinds
and headwinds.
WARNING
Coasting:
Stopping the engine when going down
a hill is dangerous. This causes the
loss of power steering and power
brake control, and may cause damage
to the drivetrain. Any loss of steering
or braking control could cause an
accident. Never stop the engine when
going down a hill.
4-8
Before Driving Your Mazda
Driving Tips
MX-5 Miata_8T72-EA-04G_Edition1 Page86
Wednesday, June 9 2004 3:4 PM
Form No.8T72-EA-04G

Black plate (208,1)
WARNING
Metric Studs and Lug Nuts:
Because the wheel studs and lug nuts
on your Mazda have metric threads,
using a non-metric nut is dangerous.
On a metric stud, it would not secure
the wheel and would damage the stud,
which could cause the wheel to slip off
and cause an accident. Be sure to
reinstall the same nuts you removed or
replace them with metric nuts of the
same configuration.
Incorrect Tire Air Pressure:
Driving on tires with incorrect air
pressure is dangerous. Tires with
incorrect pressure could affect
handling and result in an accident.
Don't drive with any tires that have
incorrect air pressure. When you
check the regular tires' air pressure,
check the spare tire, too.
5. Store the damaged tire in the trunk.
Have the damaged tire repaired as soon
as possible.
NOTE
To prevent the jack and tool from
rattling, store them properly.
7-10
In Case of an Emergency
Flat Tire
MX-5 Miata_8T72-EA-04G_Edition1 Page208
Wednesday, June 9 2004 3:6 PM
Form No.8T72-EA-04G

Black plate (245,1)
The battery is in the trunk.
qBattery Maintenance
To get the best service from a battery:
lKeep it securely mounted.
lKeep the top clean and dry.
lKeep terminals and connections clean,
tight, and coated with petroleum jelly
or terminal grease.
lRinse off spilled electrolyte
immediately with a solution of water
and baking soda.
lIf the vehicle will not be used for an
extended time, disconnect the battery
cables.
Tires
For reasons of proper performance, safety,
and better fuel economy, always maintain
recommended tire inflation pressures and
stay within the recommended load limits
and weight distribution.
WARNING
Using Different Tire Types:
Driving your vehicle with different
types of tires is dangerous. It could
cause poor handling and poor
braking; leading to loss of control.
Except for the limited use of the
temporary spare tire, use only the
same type tires (radial, bias-belted,
bias-type) on all four wheels.
Using Wrong-Sized Tires:
Using any other tire size than what is
specified for your Mazda (page 10-6)
is dangerous. It could seriously affect
ride, handling, ground clearance, tire
clearance, and speedometer
calibration. This could cause you to
have an accident. Use only tires that
are the correct size specified for your
Mazda.
Maintenance and Care
Owner Maintenance
8-29
MX-5 Miata_8T72-EA-04G_Edition1 Page245
Wednesday, June 9 2004 3:6 PM
Form No.8T72-EA-04G

Black plate (252,1)
2. Remove the bulb by pushing it in
slightly and turning it
counterclockwise.
3. Install the new bulb in the reverse order
of removal.
License plate lights/Trunk lights
1. Slide the unit as shown in the figure to
remove it.
2. Turn the socket and bulb assembly
counterclockwise and remove it.
3. Disconnect the bulb from the socket.
4. Install the new bulb in the reverse order
of removal.
qReplacing Interior Light Bulbs
Overhead light
1. Wrap a flathead screwdriver with a soft
cloth to prevent damage to the trim and
gently insert it in the overhead light as
shown in the figure, and then remove
the cover.
2. Disconnect the bulb by pulling it out.
Edge
3. Install the new bulb in the reverse order
of removal.
8-36
Maintenance and Care
Owner Maintenance
MX-5 Miata_8T72-EA-04G_Edition1 Page252
Wednesday, June 9 2004 3:6 PM
Form No.8T72-EA-04G

Black plate (288,1)
qLight Bulbs
Exterior light
Light bulbCategory
Wattage ECE R SAE
HeadlightsHigh beam 60 HB3―
Low beam 51 HB4―
Front turn signal lights/Parking lights 27/8―#1157NA
Fog lights
í55 H11―
Side-marker lights 3.8―#194
Rear turn signal lights 21 WY21W―
Brake lights/Taillights 21/5 W21/5W #7443
High-mount brake light 21 P21W―
Reverse lights 21 W21W #7440
License plate lights/Trunk lights 5 W5W―
Interior light
Light bulb Wattage
Overhead light 8
qTires
NOTE
The tires have been optimally matched with the chassis of your vehicle.
When replacing tires, Mazda recommends that you replace tires of the same type
originally fitted to your vehicle. For details, contact an Authorized Mazda Dealer.
Check the tire pressure label for tire size and inflation pressure. Refer to Tire Inflation
Pressure on page 8-30.
Standard tire
Tire sizeInflation pressure
Front Rear
195/50 R15 82V
180 kPa (1.8 kgf/cm
2, 26 psi) 180 kPa (1.8 kgf/cm2, 26 psi)
205/45 R16 83W
205/40 R17 80W 200 kPa (2.0 kgf/cm
2, 29 psi) 220 kPa (2.2 kgf/cm2, 32 psi)
Temporary spare tire
Tire size Inflation pressure
T115/70 D14 88M
420 kPa (4.2 kgf/cm
2, 60 psi)
T105/70 D15 85M
10-6íSome models.
Specifications
MX-5 Miata_8T72-EA-04G_Edition1 Page288
Wednesday, June 9 2004 3:6 PM
Form No.8T72-EA-04G

Black plate (295,1)
R
Rocking the Vehicle ............................ 4-9
S
Safety Defects, Reporting ................. 9-16
Seat Belt System
3-point type .................................. 2-7
Automatic locking ........................ 2-6
Emergency locking ...................... 2-5
Extender ..................................... 2-10
Pregnant women .......................... 2-5
Pretensioner and load limiting ..... 2-8
Seat belt precautions .................... 2-4
Warning beep ............................. 2-12
Warning light .............................. 2-11
Seats
Front seat ...................................... 2-2
Security System
Immobilizer system .................... 3-31
Service Publications .......................... 9-17
Spare Tire and Tool Storage ................ 7-3
Specifications .................................... 10-4
Speedometer ...................................... 5-19
SRS Air Bags
Air bag system description ......... 2-26
Supplemental restraint systems
precautions ................................. 2-20
Warning light ............................. 2-28
Starting the Engine .............................. 5-3
Steering Wheel
Horn ........................................... 5-33
Storage Compartments ...................... 6-70
Center console ............................ 6-70
Glove box ................................... 6-70
Mesh pocket ............................... 6-71
Sunvisors .......................................... 6-67
T
Tachometer ........................................ 5-20
Temporary Spare Tire ....................... 8-31
Tiedown
Hook .......................................... 7-17
Tires
Flat tire ......................................... 7-3
Inflation pressure ........................ 8-30
Replacement ............................... 8-31
Rotation ...................................... 8-30
Snow tires .................................. 4-10
Spare tire and tool storage ............ 7-3
Specifications ............................. 10-6
Tire chains .................................. 4-11
Uniform tire quality grading system
(UTQGS) ................................... 9-14
Tool ..................................................... 7-3
Towing
Description ................................. 7-16
Emergency towing ..................... 7-16
Recreational towing ................... 7-17
Trailer towing ............................. 4-14
Trailer Towing .................................. 4-14
Trip Meter ......................................... 5-19
Trunk Lid .......................................... 3-11
Trunk Light ....................................... 3-13
Trunk Release Handle ....................... 3-14
Turn and Lane-Change Signals ......... 5-30
V
Vanity Mirrors ................................... 6-67
Vehicle Information Labels ............... 10-2
Index
11-5
MX-5 Miata_8T72-EA-04G_Edition1 Page295
Wednesday, June 9 2004 3:6 PM
Form No.8T72-EA-04G