2005 LOTUS ELISE check

What Is Not CoveredLotus may deny an emission per formance warranty
claim on the basis of an uncertified replacement part used in the maintenance or repair of a car if Lotus presents evidence that the uncertified replacement part is either
defective in materials or workmanship, or not equivalent
from an emission standpoint to the original equipment part, and the owner is unable to rebut the evidence. A part not required to be replaced at a definite service
interval (see Maintenance Schedule) shall be warranted for
the applicable warranty period. Instructions to replace a
component only if checked and found to be operating below specification shall have no bearing on warranty coverage
unless the owner did not follow such an instruction prior to
the short test failure and non compliance with that instruc
-
tion caused the failure of another car component relevant
to the non- conformity.
This warranty does not cover failures caused by abuse,
neglect, collision, accidents, improper maintenance, un
-
authorised modification; nor does it cover loss of time, inconvenience, loss of use of the car or incidental or con
-
sequential damages.
ANY IMPLIED WARRANTY OF MERCHANTABILITY OR
FITNESS FOR A PARTICULAR PURPOSE, APPLICABLE
TO A Car OR PART IS LIMITED IN DURATION TO THE TIME PERIODS SET FORTH IN THIS WARRANTY. LOTUS SHALL
NOT BE LIABLE FOR INCIDENTAL OR CONSEQUENTIAL
DAMAGE RESULTING FROM THE BREACH OF ANY WAR
-
RANTY. S O M E S TAT E S D O N OT A L LO W L I M I TAT I O N S O N
HOW LONG AN IMPLIED WARR ANT Y L ASTS, OR THE
EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSE
-
QUENTIAL DAMAGES, SO THE ABOVE LIMITATIONS OR EXCLUSIONS MAY NOT APPLY TO YOU.
Federal Emission Warranty
174

oh_croft_InD.indd 17420/05/2004 07:59:23ProCarManuals.com

CALIFORNIA EMISSION CONTROL WARRANTY STATEMENT
YOUR WARRANTY RIGHTS AND OBLIGATIONS The California Air Resources Board and Lotus Cars
Limited are pleased to explain the emission control system
warranty on your new, USA specification, Lotus Elise. In
California, new motor cars must be designed, built and equipped to meet the State’s stringent anti-smog standards.
Lotus must warrant the emission control system on your
Elise for the periods of time listed below provided there has been no abuse, neglect or improper maintenance of
your car. Your emission control system may include parts such as the carburettor or fuel injection system, the igni
-
tion system, catalytic conver tor, and engine computer.
Also included may be hoses, belts, connectors and other
emission-related assemblies. Where a warrantable condition exists, Lotus will repair
your car at no cost to you including diagnosis, parts and labour.
MANUFACTURER’S WARRANTY COVERAGE
- For
3 years or 50,000 miles (whichever first occurs):
1) If your car fails a Smog Check inspection, all necessary repairs and adjustments will be made by Lotus to ensure that
your car passes the inspection. This is your emission control
system PERFORMANCE WARRANTY.
2 ) I f a n y e m i s s i o n r e l a t e d p a r t o n y o u r c a r i s d e f e c-
t i v e , t h e p a r t w i l l b e r e p a i r e d o r r e p l a c e d b y L o t u s .

This is your short-term emission control system
DEFECTS
WARRANTY.
- For
7 years or 70,000 miles (whichever first occurs):
1) If an emission related part listed in this warranty booklet specially noted with coverage for 7 years or 70,000 miles
is defective, the part will be repaired or replaced by Lotus.

This is your long term emission control system DEFECTS
WARRANTY.
California Emission Warranty
180

oh_croft_InD.indd 18020/05/2004 07:59:24ProCarManuals.com

CALIFORNIA EMISSIONS PERFORMANCE WARRANTYLotus Cars Ltd. (Lotus) warrants to the owner of any new, USA
specification, Lotus Elise, that if, during a period of 3 years or
50,000 miles, whichever first occurs, the car should fail to pass an Inspection/Maintenance test, for reasons other than those detailed on page 167 (‘What is not covered by the Emission
Warranty’), then the car will be repaired at no cost to the owner.
The car is to be repaired so that it will pass the I/M test, and these repairs shall include diagnosis, replacement, repair, and adjustment of those defective parts affecting emissions. The warranty period shall begin on the date the car is deliv
-
ered to the first retail purchaser, or, if the car is first placed in
service as a demonstrator or company car prior to sale at retail,
on the date the car is first placed in such service. If your car fails a Smog Check test or a Federal Emissions
Short test, you may choose to have diagnosis of the failure and repairs made at a Lotus dealer or at another service facility. You
may take your car to a Lotus dealer for warranty repairs and diagnosis without charge. You will have to pay for diagnostic
costs and repairs if performed at another service facility except in the case of emergency repairs (see page 164). If your car fails
a Smog Check test or a Federal Emissions Short test after the
3 year/50,000 mile performance warranty period has expired, but before 7 years/70,000 miles is reached, those parts listed
on page 168 are still covered by the defects warranty. If the warranty station demonstrates that the test failure was
caused by one or more of the conditions excluded from war
-
ranty coverage (see below), the car owner shall be liable for all
diagnostic and repair expenses. Such expenses shall not exceed
the maximum repair costs permissible under the California Car
Inspection Programme. Failure to notify the owner within 30 days that a performance warranty claim is invalid, shall render
Lotus liable for the repair costs. If the warranty station identifies
that the test failure was caused by one or more defects covered under warranty, and in combination with one or more of the conditions excluded from warranty coverage (see below), then
the car owner shall be responsible only for that proportion of the diagnostic and repair costs that is not covered by warranty.
Califo rnia Emission Warranty
185

oh_croft_InD.indd 18520/05/2004 07:59:25ProCarManuals.com

Headlamp Flasher .................................................................58
Heating & Ventilation .............................................................. 61
Horn ...................................................................................... 60
Idle Speed ............................................................................. 73
Ignition Switch ....................................................................... 44
Immobiliser, engine ................................................................ 31
Inertia Switch ...................................................................... 135
Instrument Illumination .......................................................... 56
Interior Lamp .......................................................................... 41
Jacking Points, lifting you car .............................................. 148
‘Jump’ Starting ..................................................................... 133
Keys ...................................................................................... 29
Lighting Switches .................................................................. 54
Lights On Buzzer .............................................................. 40,55
Lubrication - Dipstick, engine oil level check ....................................... 99
- Engine Oil Change ........................................................ 100
- Oil Filter ......................................................................... 102
- Recommended Lubricants ............................................ 153
- Tran smission Oil ............................................................ 103
Mirrors ................................................................................... 40
Odometer .............................................................................. 53
Parking Brake ........................................................................ 70
Pedals ................................................................................... 66
Queen’s Award ..................................................................... 191
Roof, Hard Top ...................................................................... 85
Roof, Soft Top ....................................................................... 82
Safety Information ....................................................................
7
Seat Be lts .............................................................................. 18
Seats ...................................................................................... 17
Servicing ............... see separate Maintenance Record booklet
Sparking Plugs ..................................................................... 114
Speedometer .......................................................................... 51
Start Button, engine .............................................................. 45
Starting Procedure ................................................................ 72
Index
189

oh_croft_InD.indd 18920/05/2004 07:59:26ProCarManuals.com