2005 LOTUS ELISE fuel

RECOMMENDED LUBRICANTS
EngineIn order to enhance the longevity and reliability of the car, it
is most important that only the specified lubricants are used. It
is an entirely false economy to try to save money by using lower quality oils, which may break down before the next change in
-
terval and provide inadequate protection before the end of the
term. High oil consumption may also result.
For topping up purposes during the running-in period prior to
the First After Sales Service, a top quality mineral or semi-syn
-
thetic 5W/40 oil should be used. At the First After Sales Service and completion of the running-in period, a fully synthetic 5W/40
oil such as Texaco Havoline Synthetic should be used. This oil
has been tested in all climatic conditions likely to be encountered,
and offers advantages in ease of cranking, smooth cold running
and fuel economy at low temperatures, in combination with good
wear protection at elevated temperatures and at high engine speeds. If Texaco/Havoline products are not available, an oil meeting the following specification should be used.
NOTICE: Note that Lotus does not recommend the use of any oil additives and use of such additives may invalidate the terms
of your car’s warranty.
Viscosity: 5W/40
Quality Standard: API SJEC; ILSAC; ACEA A3
Capacity - refill inc. filter 4.4 litre
(Cars fitted with front mounted oil coolers contain an additional
3.5 litres, but this oil is not drained during routine servicing) Difference between high & low dipstick marks
1.5 litre
Oil change interval Refer to Maintenance Schedule
‘Severe Service’ Conditions Certain operating conditions can cause rapid degradation of
the oil quality, either by the accumulation of dirt particles, or by
the absorption of water from condensation. If any of the ‘severe
service’ conditions described below apply, it is recommended
that the oil and filter be changed twice as frequently as is listed in the Maintenance Schedule.
Recommended Lubricants
153

oh_croft_InD.indd 15320/05/2004 07:59:19ProCarManuals.com

Unladen weight - total 912 kg ) inc.
(heaviest) - front 344 kg ) full fuel
- rear 568 kg ) tank
Max. weight - total 1162 kg > incl.
- front 441 kg > occupants
- rear 721 kg > & luggage
Trailer towing Not permissible
Capacities Engine oil (refill inc. filter) 4.7 U.S. qt. (4.4 litre)
(+3.7 U.S. qt (3.5) litre if front mounted oil coolers are drained) High/low dipstick mark difference 1.6 U.S. qt. (1.5 litre)
Transmission oil 2.4 U.S. qt. (2.3 litre)
Fuel tank 10.6 U.S. gall. (40 litre)
Cooling system 12.7 U.S. qt. (12 litre)
A.C. refrigerant (R134a) 1.2 lb (0.55 kg)
Front Suspension

T ype Independent. Upper and
lower wishbone co-axial
coil spring/telescopic
damper unit; anti-roll bar
Steering axis inclination 12° nominal
Geometry specification - Standard: Mid-laden ride height (reference height for geometry check)
- front 135 mm below front end
of chassis siderail
- rear 135 mm below rear end
of chassis siderail
Castor - optimum + 3.8°
- tolerance range + 3.5° to + 4.1°;
max. side/side 0.35°
Camber - optimum - 0.1°
- tolerance range + 0.1° to - 0.3°
max. side/side 0.2°
Alignment - optimum Zero - tolerance range 0.5 mm toe-out, to
0.7mm toe-in overall
Technical Data
156

oh_croft_InD.indd 15620/05/2004 07:59:19ProCarManuals.com

Spark plugs NGK IFR6A11
DensoSK20R11
Spark plug gap 1.1 mm
Max. continuous engine speed 8000 rpm (8500 transient)
Fuel requirement Unleaded
Minimum octane 91 (RON+MON)/2
Fuel system Multi-point fully sequential
fuel injection with Lotus T4
controller.
Peak power (SAE DIN 70020) 190 bhp (141.7 kW) @
7,800 rpm
Peak torque (SAE DIN 70020) 138 lbf.ft (187 Nm) @
6,800 rpm
Transmission
Type 6 speed manual transaxle.
Bevel gear differential.
Gear Ratio Final Drive mph/1000 rpm First 3.17:1 ) 5.1
Second 2.05:1 ) 7.7
Third 1.48:1 ) 4.53:1 10.7
Fourth 1.17:1 ) 13.6
Fifth 0.92:1 ) 17.3
Sixth 0.81:1 ) 19.4
Reverse 3.25:1 )
Brakes
Type Front and rear discs with
curved vane ventilation
and cross drilling.
AP Racing aluminium op
posed piston front calipers.
Single piston sliding rear
calipers.
Disc Size - front and rear 288mm
Operation Tandem master cylinder
with vacuum servo and
ABS
Parking Brake Cable operation of rear
calipers, self adjusting for
pad wear.
Technical Data
159

oh_croft_InD.indd 15920/05/2004 07:59:20ProCarManuals.com

FURTHER INFORMATIONFu r t h e r i nf o r m a t i o n c o n c e r n i n g t h e e m i s si o n p e r
-
formance warranty is available from the Director Field Operation & Suppor t Division (6406 J), Environmental
Protection Agency, 401 ‘M’ Street, SW, Washington DC
20460 (attention: Warranty Claim). Violations of the Emis
-
sion Performance Warranty may also be reported to this
office. Also contact Lotus Cars U.S.A. Inc., 2236 Northmont
Parkway, Duluth, Georgia 30096.
EMISSIONS WARRANTY PARTS LIST
Air Induction System
- air inlet trunking
- intake manifold
Fuel Injection System
- fuel pressure regulator
- fuel injectors
- fuel delivery line
- throttle body
Ignition System
- spark plugs
- direct ignition coils
Positive Crankcase Ventilation System
- non return valve
- oil filler cap
Evaporative Emissions Control System (EECS)
- charcoal canister assembly
- fuel tank
- fuel level sender and seal
- fuel filler neck and hose
- fuel filler cap
- roll over valve assembly
- fuel lines
- fill level vent valve & pipe assy.
- canister close valve
- vapour management valve (VMV)
Federal Emission Warranty
178

oh_croft_InD.indd 17820/05/2004 07:59:24ProCarManuals.com

- fuel vapour pressure sensor
Exhaust System
- exhaust manifold
- catalytic converter, heat shields, gaskets and fasteners*
Engine Emission Control System Sensors
- electronic control module (ECM)*
- engine coolant temperature sensor (ECTS)
- air flow meter
- crankshaft sensor
- idle air control valve (IACV)
- wheel speed sensors
- throttle position sensor (TPS)
- knock sensor
- oxygen sensors
- oil control valves for VVTL-i
- oil pressure switch for VVTL-i
- camshaft position sensor
- coolant thermostat
On Board Diagnostics (OBD)
- malfunction indicator lamp (MIL)
- data link connector and harness
Miscellaneous Parts used in the Above Systems
- hoses
- switches, sensors and solenoids
- gaskets and seals
- wires, harnesses and connectors
* major emission control components - see page 171
Federal Emission Warranty
179

oh_croft_InD.indd 17920/05/2004 07:59:24ProCarManuals.com

CALIFORNIA EMISSION CONTROL WARRANTY STATEMENT
YOUR WARRANTY RIGHTS AND OBLIGATIONS The California Air Resources Board and Lotus Cars
Limited are pleased to explain the emission control system
warranty on your new, USA specification, Lotus Elise. In
California, new motor cars must be designed, built and equipped to meet the State’s stringent anti-smog standards.
Lotus must warrant the emission control system on your
Elise for the periods of time listed below provided there has been no abuse, neglect or improper maintenance of
your car. Your emission control system may include parts such as the carburettor or fuel injection system, the igni
-
tion system, catalytic conver tor, and engine computer.
Also included may be hoses, belts, connectors and other
emission-related assemblies. Where a warrantable condition exists, Lotus will repair
your car at no cost to you including diagnosis, parts and labour.
MANUFACTURER’S WARRANTY COVERAGE
- For
3 years or 50,000 miles (whichever first occurs):
1) If your car fails a Smog Check inspection, all necessary repairs and adjustments will be made by Lotus to ensure that
your car passes the inspection. This is your emission control
system PERFORMANCE WARRANTY.
2 ) I f a n y e m i s s i o n r e l a t e d p a r t o n y o u r c a r i s d e f e c-
t i v e , t h e p a r t w i l l b e r e p a i r e d o r r e p l a c e d b y L o t u s .

This is your short-term emission control system
DEFECTS
WARRANTY.
- For
7 years or 70,000 miles (whichever first occurs):
1) If an emission related part listed in this warranty booklet specially noted with coverage for 7 years or 70,000 miles
is defective, the part will be repaired or replaced by Lotus.

This is your long term emission control system DEFECTS
WARRANTY.
California Emission Warranty
180

oh_croft_InD.indd 18020/05/2004 07:59:24ProCarManuals.com

CUSTOMER ASSISTANCELotus Cars Ltd. wishes to help assure that the Emission
Control Systems Warranty is properly administered. In the event that you do not receive the warranty service to which you believe
you are entitled under the Emission Control Systems Warranty, or if you need additional assistance or information concerning
this warranty, you should contact: Lotus Cars U.S.A. Inc., 2236 Northmont Parkway, Duluth, Georgia 30096. If you cannot obtain satisfaction, you may contact: Air Re
-
sources Board, Mobile Source Division, 9528 Telstar Avenue, El Monte, CA. 91731.
7 YEAR/70,000 MILE EMISSIONS DEFECTS WARRANTY PARTS LIST
- Catalytic Converter
- Engine Management Electronic Control Module
- Throttle Body
- Exhaust Manifold
- Fuel Tank
- Fuel Level Sender and Seal
- IAC Valve
- Knock Sensor
- Intake Manifold and Gasket
- Fuel Pressure Regulator Valve
- Fuel Level Vent Valve
- Roll Over Valve
- Instrument Pack
- Main Harness
Califo rnia Emission Warranty
187

oh_croft_InD.indd 18720/05/2004 07:59:26ProCarManuals.com

INDEX
Access Panels, front service ................................................. 78
Accessories & Modifications, warnings .............................. 150
Air Cleaner Element ............................................................. 113
Air Conditioning ...................................................................... 61
Airbag Safety System ............................................................. 21
Alarm, car security ................................................................ 30
Alternator Belt ...................................................................... 114
Anti-freeze/Corrosion Inhibitor ............................................. 107
Anti-Lock Brake System (ABS) .............................................. 67
Audio Equipment ................................................................... 60
Auxiliary Power Socket .......................................................... 57
Battery ................................................................................. 129
Bodycare ............................................................................... 93
Brake Fluid Reservoir .......................................................... 110
Brake Pads ........................................................................... 111
Break-In, running-in .............................................................. 73
Bulb Replacement ............................................................... 142
Central Door Locking ............................................................. 37
Child Restraints ..................................................................... 26
Cleaning, bodycare ............................................................... 93
Coolant Temperature Display ................................................ 53
Cooling System ................................................................... 106
Dipswitch ............................................................................... 58
Doors, keys ............................................................................ 37
Engine Cover/Trunk Lid ........................................................ 79
Environment, care of ............................................................. 14
Fuel Level Display ................................................................. 52
Fuel Filling ............................................................................. 76
Fuel Requirement .................................................................. 75
Fuses ................................................................................... 135
Gear Lever ............................................................................. 71
Hazard Warning Lamps Switch ............................................ 55
Headlamp Alignment ........................................................... 139
Index
188

oh_croft_InD.indd 18820/05/2004 07:59:26ProCarManuals.com