2005 LOTUS ELISE set

WARNING:Inexper t modifications or additions to the electrical
system could jeopardise safety.
Inertia Switch The safety inertia switch is designed to operate on impact,
typified by car collision, to switch off the fuel pump, and thus
minimise any fire hazard. The central door locking will also be
triggered to unlock the doors. The inertia switch is mounted at the left hand bottom of the
engine bay, on the inboard face of the rear subframe, and is ac
-
cessible from between the coolant header tank and windscreen
washer reservoir. The switch is reset by pressing the rubber
diaphragm button on the top of the unit.
Fuses The main fusebox is located in the front services compartment,
on the passenger side, and is protected by a plastic cover. For
access, remove the passenger side front body access panel,
and unclip the fusebox lid. Twenty two slots are provided for ‘Littel’ type fuses which are
numbered, and coloured according to their amperage rating, and
may be pulled out from their slots using the fuse extractor tool provided on the fusebox lid.

ohs137
INERTIA SWITCH
Electrical
135

oh_croft_InD.indd 13520/05/2004 07:59:14ProCarManuals.com

Headlamp AlignmentThe headlamps of your Elise were correctly adjusted during
the manufacture of the car, and should only require subsequent
adjustment if the headlamp assembly or front body is disturbed.
Simply replacing the bulb will not affect alignment. Incorrectly adjusted headlamps can cause poor lighting performance or dazzle to oncoming traf fic. Special headlamp setting equip
-
ment is required to correctly set the headlamps, such that only
qualified technicians using appropriate equipment should be
entrusted with this procedure:
1. Using beam setting equipment compatible with local regu
-
lations, position the machine between 300 and 700mm in
front of the LH headlamp, and parallel with the two headlamp
units using the sight bar or similar device dependent on the machine design, to ensure cross car match. Use the guides provided on the machine to ensure the correct height and
lateral setting.
2. Switch on the headlamp low beams (uppermost lamps) and check the lateral beam alignment. The ‘knee point’ of the beam cut off line must lie within a tolerance of 2% to the pas
-
senger side, and 0%. Check the vertical alignment of the low beam which must lie within a tolerance of - 0.5% and -2%.
Electrical
139

oh_croft_InD.indd 13920/05/2004 07:59:15ProCarManuals.com

3. If adjustment is required, the clear cover and mask must be removed from the body. From within the wheelarch, remove
the access panel from the wheelarch liner to expose the
headlamp cover retaining screws. Use the hexagonal key provided in the toolkit (in the rear pocket on the batter y
cover) to release the three socket head retaining screws and washers, and withdraw the cover assembly complete
with rubber edge seal from the body. When refitting, do not overtighten the fixings.
4. To adjust the low beam laterally, adjust the dome headed screw at the upper inboard side of the low beam (uppermost)
lamp, accessed from the front of the lamp. Turn clockwise to
adjust the beam to the right. Optimum setting is 0%. To adjust
the vertical aim of the low beam, adjust the dome headed screw at the lower outboard side of the lamp, accessed
from the front of the lamp. Turn clockwise to raise the beam.
Optimum setting is -1.5%.
5. Repeat for the RH lamp. 6. Centralise the machine on the LH high beam (lowermost) lamp, and switch on the high beams. Check the high beam
alignment which should be centralised with the marker dot on
the machine screen or slightly below the horizontal. Optimum
setting is 0%.
ohs105a
HEADLAMP COVER UNIT SOCKET BOLTS
Electrical
140

oh_croft_InD.indd 14020/05/2004 07:59:16ProCarManuals.com

LIMITED WARRANTYLotus Cars U.S.A. Inc.; 2236 Northmont Parkway, Duluth,
Georgia 30096.
LOTUS CARS U.S.A. Inc., (the Company) warrants each new
Lotus motor car sold by the Company or an authorised Lotus
dealer* in the U.S.A., and each Lotus replacement part supplied by the Company or an authorised Lotus dealer* in the U.S.A., to
be free from defects in material and workmanship under normal
use and service, and subject to the terms and conditions in this Limited Warranty, for the applicable Warranty Period set forth
in Paragraph 1. (*Authorised Lotus dealers are not owned by, or are agents of, the Company) The paragraphs below are the only and exclusive rem
-
edies under the terms of the warranty. The Limited Warranty excludes cer tain par ts and sets of
circumstances which are set out in section 4 below.
1. WARRANTY PERIODS
(a) LIMITED WARRANTY - Cars.
The Company warrants each new car to be free from defects
in material and workmanship for a period of thirty six (36) months or 36,000 miles, whichever first occurs, after the first
occurring of the following dates:
i) date of delivery of the car to the retail original owner;
ii) registration as a dealer demonstrator.
CONSULT YOUR SALES DOCUMENTS TO DETERMINE
THE WARR ANT Y START DATE ON YOUR CAR; SPE AK
TO YOUR DEALER OR LOTUS CARS USA IF YOU ARE IN DOUBT.
(b) LIMITED WARRANTY - Replacement Parts.
Genuine Lotus replacement parts are warranted to be free
from defects in materials and workmanship for 12 months
from the date of their installation or until the expiration of the
car’s limited warranty term, whichever occurs last.

Limited Warranty
162

oh_croft_InD.indd 16220/05/2004 07:59:20ProCarManuals.com

(c) LIMITED WARRANTY - Corrosion Perforation.
The Company’s Limited Corrosion Perforation Warranty (as
set forth in Paragraph 4 (c)) runs for a period of 8 years from
the commencement of the Car Limited Warranty as specified
in paragraph 1(a).
2. LIMITATIONS THE COMPANY DOES NOT AUTHORIZE ANY PERSON
TO CREATE ANY OTHER OBLIGATION IN CONNECTION WITH ITS CARS. ANY IMPLIED WARRANTY OF MERCHANT
-
ABILITY OR FITNESS FOR A PARTICULAR PURPOSE, AP
-
PLICABLE TO A CAR OR PART IS LIMITED IN DURATION
TO THE TIME PERIODS SET FORTH IN PARAGRAPH 1.
3. EXCLUSIVE REMEDIES THE PERFORMANCE OF REPAIRS AND NEEDED AD
-
JUSTMENTS ARE THE EXCLUSIVE REMEDIES UNDER
THIS WRITTEN WARRANTY OR ANY IMPLIED WARRANTY.
THE COMPANY SHALL NOT BE LIABLE FOR INCIDENTAL OR CONSEQUENTIAL DAMAGE RESULTING FROM THE BREACH OF ANY WARRANTY. S O M E S TAT E S D O N OT A L LO W L I M I TAT I O N S O N
HOW LONG AN IMPLIED WARR ANT Y L ASTS, OR THE
EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSE
-
QUENTIAL DAMAGES, SO THE ABOVE LIMITATIONS OR EXCLUSIONS MAY NOT APPLY TO YOU.
4. EXTENT OF COMPANY OBLIGATIONS
(a) LIMITED WARRANTY - Car. This warranty extends to
each original and subsequent owner of a Lotus motor car
within the warranty period expressed in Paragraph 1(a). The
obligations of the Company under this warranty are limited
to the repair or, at its option, the replacement with a new or remanufactured unit without charge for labour or part, of any
part or assembly or component determined to be defective
in material or workmanship during the applicable warranty period. All items which are replaced become the property of
the Company to the fullest extent allowed under applicable
law. All Service under this warranty must be performed by a
Lotus Dealer at its place of business.
Limited Warranty
163

oh_croft_InD.indd 16320/05/2004 07:59:21ProCarManuals.com

(b) LIMITED WARRANTY - Replacement Parts.
The obligations of the Company during the warranty term
are limited to the repair or, at its option, the replacement of
any genuine Lotus part determined to be defective in mate
-
rial or workmanship during the warranty period expressed in
paragraph 1(b). All replaced parts shall become the property
of the Company.
(c) LIMITED WARRANTY - Corrosion Perforation.
The Company warrants to the original owner and each subse-
quent owner during the warranty period set forth in Paragraph
1(c), that if corrosion perforation occurs on the chassis or com
-
posite body structure of a Lotus motor car, within the warranty
period expressed in Paragraph 1(c), the parts or components
affected by such perforation shall be repaired or replaced,
without charge for labour or parts. Provided, however, that:
a) the Lotus car must be brought to an authorised Lotus dealer
for inspection at least one time each year; and
b) the Lotus car has been used and maintained in a normal and reasonable manner.
c) corrosion perforation is not due to any or all of the follow
-
ing: an accident; abuse; damage; installation of an accessory;
chemical substance; an act of nature; fire; or salvaged car.
(d) OBTAINING REPAIRS.
All warranted repairs will be effected at Lotus Dealers upon
presentation of suitable evidence of eligibility. A reasonable
time must be allowed for the dealership to perform necessary
repairs, and customers are requested to allow such a reason
-
able amount of time. It is not Lotus Cars USA’s responsibility to
provide the customer with a loan car during these repairs. The
provision of a loan car should be discussed with the dealer.
5. EXCLUSIONS FROM WARRANTY COVERAGE (see also section 6)
(a) TIRES. The only provided warranty for tires is the written
warranty issued by the tire supplier and included with the owner literature supplied with your car.
(b) CAR SPECIFICATION. The obligations of the Company
under this Limited Warranty apply only to cars built by the manufacturer to USA specification for road use (i.e. not to
Limited Warranty
164

oh_croft_InD.indd 16420/05/2004 07:59:21ProCarManuals.com

When contacting Lotus Cars USA, please have the following
information available:
- year and model of your Lotus;
- your car’s vehicle identification number (viewable through
bottom edge of windscreen, driver’s side);
- date of purchase of your Lotus;
- name of dealer(s) from whom you purchased your Lotus and
where you have it serviced.
State Repair - Replace-Refund Statutes Each state has a law providing new car purchasers with
certain rights for repair, replacement of the car, or refund of
the purchase price, under certain circumstances (these laws are commonly called “lemon laws”). These laws var y from
state to state.
To the extent permitted by an applicable
state law, Lotus Cars USA requires that, before you seek
a remedy, you provide Lotus Cars USA (at the address
set forth above) with written notification of the defect or
nonconformity. In this way, Lotus Cars USA will be afforded an opportunity to perform any necessary repairs. Where ap
-
propriate, an additional lemon law information sheet is provided with this owner’s manual.
Arbitration Programs Some states have state-run arbitration programs that you can
use to pursue lemon law remedies. These programs are oper
-
ated by state agencies, and such agencies may be contacted
for additional information.
In some states that do not have state-run programs, Lotus
Cars USA may participate in private arbitration or mediation programs. In these states, additional information will be provided
to you separately.
Where either a state-run or private arbitration program is in
effect, to the extent allowed be law, Lotus Cars USA requires
that your lemon law claim first be brought before such program before you pursue other remedies.
THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS AND YOU MAY ALSO HAVE OTHER RIGHTS WHICH VARY FROM STATE TO STATE.
Limited Warranty
169

oh_croft_InD.indd 16920/05/2004 07:59:22ProCarManuals.com

PERIODS SET FORTH IN THIS WARRANTY. LOTUS SHALL
NOT BE LIABLE FOR INCIDENTAL OR CONSEQUENTIAL
DAMAGE RESULTING FROM THE BREACH OF ANY WAR
-
RANTY.
S O M E S TAT E S D O N OT A L LO W L I M I TAT I O N S O N
HOW LONG AN IMPLIED WARR ANT Y L ASTS, OR THE
EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSE
-
QUENTIAL DAMAGES, SO THE ABOVE LIMITATIONS OR EXCLUSIONS MAY NOT APPLY TO YOU.
EMISSIONS PERFORMANCE WARRANTY
Some state or local governments require periodic in
-
spection and maintenance programs to ensure that your car’s emissions control system functions properly. If an
EPA approved program is in force where you are, you are eligible for Performance Warranty coverage.
Lotus warrants to the owner of any new, USA specifica
-
tion, Lotus Elise that if:-
1) the car is maintained and operated in accordance with the written instructions for proper maintenance and use;
2) the car fails to conform to the applicable emission standards as judged by an EPA approved emission test; and
3) such non-conformity results or will result in the car owner having to bear any penalty or other sanction (including denial or the right to use the car) under local, State or Federal law,
then Lotus shall remedy the non conformity at no cost to the owner by adjusting, repairing or replacing emissions related
components as is necessary in order for the car to conform to
the applicable emission standard. This warranty is for a period
of 2 years or 24,000 miles, whichever first occurs. However,
specified Major Emission Control Components are covered for
8 years or 80,000 miles, whichever first occurs. Covered parts are listed on page 159 to 160 and specified Major Emission
Control Components are followed by an asterisk.
Federal Emission Warranty
172

oh_croft_InD.indd 17220/05/2004 07:59:22ProCarManuals.com