2005 KIA Rio brakes

Brakes and ClutchChecking Brake/Clutch Fluid LevelBrake Fluid Reservoir
Before adding fluid, thoroughly clean the area around
the reservoir cap to prevent brake fluid contamination.
If you add brake/clutch fluid, fill the brake/clutch fluid
reservoir to the MAX line. The brake/clutch fluid level
will drop with accumulated mileage. This is a normal
condition associated with brake/clutch lining wear.
Check the fluid level in the reservoir periodically; it
should be between MAX and MIN on the side of the
reservoir.
If the fluid level is excessively low, have the
brake/clutch system checked by an Authorized Kia
Dealer.
Use only the specified brake/clutch fluid. (Refer to
“Recommended Lubricants’’ later in this section.)
Do not mix different types of fluid.
Maintenance7-20
✻ ✻
NOTICE
In the event the brake/clutch system requires
frequent additions of fluid, the vehicle should be
inspected by an Authorized Kia Dealer.
0MSA5016
RIO ENG CNA 7-1.qxd 7/29/05 5:16 PM Page 20

7-49
Exterior CareExterior General CautionIt is very important to follow the manufacturer’s
directions when using any chemical cleaner or polish.
Read all warning and caution statements that appear on
the label.Finish MaintenanceWashing
To help protect your vehicle’s finish from rust and
deterioration, wash it thoroughly and frequently
at least once a month with lukewarm or cold
water. Pay special attention to the removal of any
accumulation of salt, dirt, mud, or other foreign
materials. Make sure the drain holes in the lower edges
of the doors and rocker panels are kept clear and clean.
Insects, tar, tree sap, bird droppings, industrial fallout
and similar deposits can damage your vehicle’s finish
if not removed immediately. Even prompt washing with plain water may not
completely remove all these deposits. A mild soap,
safe for use on painted surfaces, can be used.
After washing, rinse the vehicle thoroughly with
lukewarm or cold water. Do not allow soap to dry on
the finish.
✻ ✻
NOTICE
Do not use strong soap, chemical detergents or
hot water, and do not wash the vehicle in direct
sunlight or when the body of the vehicle is warm.
CAUTION
After washing the vehicle, test the brakes while
driving slowly to see if they have been affected by
water. If braking performance is impaired, dry the
brakes by applying them lightly while maintaining
a slow forward speed.
RIO ENG CNA 7-2.qxd 7/29/05 5:18 PM Page 49

Maintenance7-52
Interior CareInterior General PrecautionsPrevent caustic solutions such as perfume and cosmetic
oil from contacting the dashboard; they may cause
damage or discoloration. If they do contact the
dashboard, wipe them off immediately.
Upholstery and Interior Trim Cleaning
Vinyl
First, remove dust and loose dirt from vinyl with a
whisk broom or vacuum cleaner. Then, clean vinyl
surfaces with a vinyl cleaner.
Fabric
First, remove dust and loose dirt from fabric with a
whisk broom or vacuum cleaner. Then, clean with a
mild soap solution recommended for upholstery or
carpets. Remove fresh spots immediately with a fabric
spot cleaner. If a fresh spot do not receive immediate
attention, the fabric may be stained and its color can be
affected. Also, its fire-resistant properties may be
reduced if the material is not properly maintained.
Aluminum Wheel MaintenanceThe aluminum wheels are coated with a clear
protective finish.
 Do not use any abrasive cleaner, polishing
compound, solvent, or wire brushes on aluminum
wheels. They may scratch or damage the finish.
 Use only a mild soap or neutral detergent, and rinse
thoroughly with water. Also, be sure to clean the
wheels after driving on salted roads. This helps
prevent corrosion.
 Avoid washing the wheels with high-speed car wash
brushes.
CAUTION
After washing the vehicle, test the brakes while
driving slowly to see if they have been affected
by water.
RIO ENG CNA 7-2.qxd 7/29/05 5:18 PM Page 52

Index
9-1
A
ir Bag - Supplemental Restraint System.....................3-46
Air Cleaner ......................................................................7-27
Automatic Transaxle................................................4-9, 7-23
Battery ............................................................................7-31
Before Driving ..................................................................5-4
Brake System ..................................................................4-15
Brakes and Clutch ...........................................................7-20
Bulb Replacement ...........................................................7-42C
limate Control System ................................................4-44
Connection Jumper Cables ...............................................6-5
Cup Holders and Console Storage Compartment ...........3-66
D
aytime Running Lights(DRL) .....................................4-35
Door Locks........................................................................3-5
Electrical Circuit Protection ............................................6-7
Emergency Starting ...........................................................6-4Emission Control System..................................................5-3
Engine Compartment ......................................................7-13
Engine Cooling System ..................................................7-16
Engine Oil and Oil Filter ................................................7-14
Exterior Care ...................................................................7-49
Fuel Filler Door .............................................................3-59
Fuel Requirements ............................................................5-2G
auges ...........................................................................4-25
H
ood ..............................................................................3-57
How To Use This Manual .................................................1-2
If You Have a Flat Tire ..................................................6-16
Ignition Switch ..................................................................4-2
Instrument Cluster...........................................................4-23
Instrument Panel Overview ..............................................2-4
Interior and Exterior Overview .........................................2-2
9
RIO ENG CNA 9.qxd 7/29/05 5:19 PM Page 9-1