2005 JEEP WRANGLER overheating

Defrost
Outside air comes from the windshield outlets
with a small amount being directed through the
floor outlets. Use this setting when necessary to defrost
your windshield.
NOTE:For improved safety, the A/C compressor is
activated when “Mix” or “Defrost” modes are selected.
This is done to assist in drying the air and it will help in
keeping the windshield from fogging.
Operating Tips
Summer Operation
The engine cooling system in air conditioned vehicles
must be protected with a high-quality antifreeze coolant
to provide proper corrosion protection and to protect
against engine overheating. A 50% solution of ethylene
glycol antifreeze coolant in water is recommended.
Winter Operation
The air from the heater system will heat faster in cold
weather if you use lower blower speeds until the engine
warms up. When operating the system during the winter
months, make sure the air intake, located directly in front
of the windshield, is free of ice, slush, snow, or other
obstructions.
Window Fogging
In mild but rainy or humid weather, the windows might
fog on the inside. To clear the fog off all of the windows,
turn the mode control knob to the “Panel” position (with
snowflake). Adjust the temperature control and blower
speed to maintain comfort. Direct the panel outlets
toward the side windows. Interior fogging on the wind-
shield can be quickly removed by selecting the “Defrost”
position.
174 UNDERSTANDING YOUR INSTRUMENT PANEL

•Be sure to remove the key.
CAUTION!
To avoid fuel spillage and overfilling, do not “top
off” the fuel tank after filling.
NOTE:When the fuel nozzle “clicks” or shuts off, the
fuel tank is full.
TRAILER TOWING
In this section you will find information on limits to the
type of towing you can reasonably do with your vehicle.
Before towing a trailer, carefully review this information
to tow your load as efficiently and safely as possible.
To maintain warranty coverage, follow the requirements
and recommendations in this manual concerning ve-
hicles used for trailer towing.Perform maintenance services as prescribed in the
“Maintenance Schedules” section. When your vehicle is
used for trailer towing, never exceed the gross axle
weight rating (GAWR) by the addition of:
•The tongue weight of the trailer.
•The weight of any other type of cargo or equipment
put in or on your vehicle.
Remember that everything put in or on the trailer adds to
the load on your vehicle.
The “D” Overdrive range can be selected when towing.
However, if frequent shifting occurs move the shift lever
to the next lower position to eliminate excessive auto-
matic transmission shifting. This action will also reduce
the possibility of transmission overheating and provide
better engine braking. Refer to “Transmission Shifting” in
this section for additional information.
STARTING AND OPERATING 229
5

Do not use this emergency warning system when the
vehicle is in motion. Use it when your vehicle is disabled
and is creating a safety hazard for other motorists.
If it is necessary to leave the vehicle to go for service, the
flasher system will continue to operate with the ignition
key removed and the vehicle locked.
NOTE:With extended use, the flasher may wear down
your battery.
IF YOUR ENGINE OVERHEATS
In any of the following situations, you can reduce the
potential for overheating by taking the appropriate ac-
tion.
•On the highways — Slow down.
•In city traffic — While stopped, put transmission in N
(Neutral), but do not increase engine idle speed.NOTE:There are steps that you can take to slow down
an impending overheat condition. If your air conditioner
is on, turn it off. The air conditioning system adds heat to
the engine cooling system and turning off the A/C
removes this heat. You can also turn the Temperature
Control to maximum heat, the Mode Control to floor, and
the Fan Control to High. This allows the heater core to act
as a supplement to the radiator and aids in removing heat
from the engine cooling system.
CAUTION!
Driving with a hot cooling system could damage
your vehicle. If the temperature gauge reads “H”,
pull over and stop the vehicle. Idle the vehicle with
the air conditioner turned off until the pointer drops
back into the normal range. If the pointer remains on
the “H”, and you hear continuous chimes, turn the
engine off immediately, and call for service.
WHAT TO DO IN EMERGENCIES 237
6

WARNING!
A hot exhaust system can start a fire if you park over
materials that can burn. Such materials might be
grass or leaves coming into contact with your ex-
haust system. Do not park or operate your vehicle in
areas where your exhaust system can contact any-
thing that can burn.
In unusual situations involving grossly malfunctioning
engine operation, a scorching odor may suggest severe
and abnormal catalyst overheating. If this occurs, stop
the vehicle, turn off the engine and allow it to cool.
Service, including a tune up to manufacturer’s specifica-
tions, should be obtained immediately.
To minimize the possibility of catalytic converter dam-
age:
•Do not shut off the engine or interrupt the ignition
when the transmission is in gear and the vehicle is in
motion.
•Do not try to start the engine by pushing or towing the
vehicle.
•Do not idle the engine with any spark plug wires
disconnected or removed, such as when diagnostic
testing.
•Do not idle the engine for prolonged periods during
very rough idle or malfunctioning operating condi-
tions.
•Do not allow vehicle to run out of fuel.
NOTE:Intentional tampering with emissions control
systems can result in civil penalties being assessed
against you.
MAINTAINING YOUR VEHICLE 259
7

Oil Filter............................ 257
Oil Pressure Gauge..................... 145
Oil Selection.......................... 295
Overheating.......................... 237
Starting............................. 178
Temperature Gauge..................... 145
Engine Oil Viscosity...................... 256
Engine Oil Viscosity Chart................. 256
Entry System, Illuminated.................. 17
Exhaust Gas Caution...................44,225
Exhaust System......................... 266
Extender, Seat Belt........................ 26
Exterior Finish Care...................... 280
Fabric Care.........................280,283
Fabric Top............................. 280
Filters
Air Cleaner.......................... 260
Engine Fuel.......................... 260Engine Oil........................... 257
Finish Care............................ 280
Flashers
Hazard Warning....................... 236
Turn Signal.....................143,292,294
Flooded Engine Starting................... 179
Fluid Capacities......................... 295
Fluid Level Checks...................... 278
Automatic Transmission................. 274
Engine Oil........................... 253
Manual Transmission................... 276
Power Steering........................ 263
Fog Light Service........................ 292
Fog Lights...........................63,292
Folding Rear Seat........................ 57
Folding Windshield...................... 130
Four Wheel Drive....................... 190
Shifting............................. 192
Four Wheel Drive Operation.............190,191
336 INDEX

Filter............................... 257
Identification Logo..................... 255
Materials Added to..................... 257
Recommendation...................255,295
Viscosity..........................256,295
Onboard Diagnostic System..............250,251
Outside Rearview Mirrors.................. 54
Overheating, Engine...................... 237
Owner’s Manual........................ 328
Paint Care............................. 279
Paint Damage.......................... 279
Parking Brake.......................... 196
Passing Light........................... 63
PCV Valve............................ 260
Pets.................................. 43
Pets, Transporting........................ 43
Placard, Tire and Loading Information......... 211
Polishing and Waxing..................... 280Power
Distribution Center..................... 288
Steering............................. 263
Pregnant Women and Seat Belts.............. 26
Preparation for Jacking.................... 239
Pressure Gauge, Oil...................... 145
Radial Ply Tires......................... 218
Radio Broadcast Signals................... 149
Radio Operation......................150,169
Radio, Satellite.......................... 163
Radio (Sound Systems).................150,156
Rear Axle............................. 278
Rear Window Defroster................... 137
Rear Window Features.................... 137
Rear Wiper/Washer...................... 138
Rearview Mirrors........................ 50
Reclining Front Seats...................... 56
INDEX 341
10