2005 JEEP WRANGLER transmission fluid

(cross-hatched area) on the oil level indicator. The fluid
level indicator should be in the COLD region at 70° F (21°
C) fluid temperature.
If the fluid level is low, add sufficient fluid to bring to the
proper level. Refer to Recommended Fluids, Lubricants
and Genuine Parts for correct fluid type.
Fluid is added through the dipstick tube.
NOTE:To prevent dirt and water from entering the
transmission after checking or replenishing fluid, make
certain that the dipstick cap is properly reseated.
Special Additives
The manufacturer strongly recommends against the ad-
dition of any additives to the transmission. The only
exception to this policy is the use of special dyes to aid in
detecting fluid leaks. The use of transmission sealers
should be avoided as they may adversely affect seals.
Hydraulic Clutch Fluid — Manual Transmission
The clutch hydraulic system is a sealed maintenance free
system. In the event of leakage or other malfunction, the
system must be replaced.
Manual Transmission
Selection of Lubricant
Use only manufacturer’s recommended manual trans-
mission fluid, refer to Recommended Fluids, Lubricants,
and Genuine Parts for correct fluid type.
Fluid Level Check
Check the fluid level by removing the fill plug. The fluid
level should be between the bottom of the fill hole and a
point not more than 3/16” (4.76 mm) below the bottom of
the hole.
Add fluid, if necessary, to maintain the proper level.
276 MAINTAINING YOUR VEHICLE

Chassis
Component Fluid, Lubricant, or Genuine Part
Automatic Transmission MoparATF+4 Automatic Transmission Fluid or equivalent.
Manual Transmission MoparManual Transmission Lubricant or equivalent (meeting the require-
ments of DaimlerChrysler Material Standard MS-9224)
Transfer Case MoparATF+4 Automatic Transmission Fluid or equivalent.
Axle Differential (Front) MoparGear & Axle Lubricant (SAE 80W-90) (API GL-5) or equivalent. For
trailer towing, use MoparSynthetic Gear & Axle Lubricant (SAE 75W-140)
or equivalent.
Axle Differential (Rear)194 RBI (Model 35) and 216 RBI (Model 44)- MoparGear & Axle Lubri-
cant (SAE 80W-90) (API GL-5) or equivalent. For trailer towing, use Mopar
Synthetic Gear & Axle Lubricant (SAE 75W-140) or equivalent. Models
equipped with Trac-Lok require an additive.194 RBI (Model 35) 4.56 Ratio
(2.4L Engine with 42RLE Automatic Transmission) and Rubicon 216 RBI
(Model 44)- MoparSynthetic Gear & Axle Lubricant (SAE 75W-140) or
equivalent. Models equipped with Trac-Lok require an additive.
MAINTAINING YOUR VEHICLE 297
7

Component Fluid, Lubricant, or Genuine Part
Brake Master Cylinder MoparDOT 3 Brake Fluid, SAE J1703 should be used. If DOT 3, SAE J1703
brake fluid is not available, then DOT 4 is acceptable. Use only recom-
mended brake fluids.
Power Steering Reservoir MoparATF+4 Automatic Transmission Fluid or equivalent.
Steering Gear & Linkage, Ball
Joints, Prop Shafts & Yokes, Wheel
BearingsMoparMulti-Purpose Grease NLGI Grade 2 EP, GC-LB or equivalent.
298 MAINTAINING YOUR VEHICLE

Once a Month
•Check the tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of the coolant reservoir, brake
master cylinder, and transmission, and add as needed.
•Check all lights and all other electrical items for correct
operation.
At Each Oil Change
•Change the engine oil filter.
•Inspect the exhaust system.
•Inspect brake hoses.
•Check the coolant level, hoses, and clamps.
•Inspect manual transmission fluid level — if
equipped.
•After completion of off-road operation, the underside
of the vehicle should be thoroughly inspected. Exam-
ine threaded fasteners for looseness.
302 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 48,000 51,000 54,000 57,000 60,000
(Kilometers) (77 000) (82 000) (86 000) (91 000) (96 000)
Change the engine oil and engine oil filter, if not
replaced at 3 months.X X XXX
Rotate the tires. X X X
Inspect the engine air filter element, replace if
necessary.X
Inspect the PCV Valve, and replace if necessary.X
Inspect the ignition cables, and replace if neces-
sary (2.4L Only).X
Replace the spark plugs.X
Lubricate the steering linkage tie rod ends. X X X X X
Lubricate the steering and suspension ball joints. X X X
Inspect the brake linings. X X
Drain and refill the front and rear axle fluid‡ X X
Drain and refill the automatic transmission fluid,
and change filter.†X
SCHEDULE “B” 307
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 108,000 111,000 114,000 117,000 120,000
(Kilometers) (173 000) (178 000) (182 000) (187 000) (192 000)
Change the engine oil and engine oil filter, if not
replaced at 3 months.X X XXX
Rotate the tires. X X X
Inspect the engine air filter element, replace if
necessary.X
Inspect the PCV Valve, and replace if necessary.X
Replace the spark plugs.X
Inspect the ignition cables, and replace if neces-
sary (2.4L Only).X
Lubricate the steering linkage tie rod ends. X X X X X
Lubricate the steering and suspension ball joints. X X X
Inspect the brake linings. X X
Drain and refill the front and rear axle fluid‡ X X
Drain and refill the automatic transmission fluid,
and replace main sump filter.†X
312 SCHEDULE “B”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

About Your Brakes....................... 198
ABS (Anti-Lock Brake) System............147,200
Add-A-Trunk........................... 72
Adding Washer Fluid..................... 138
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 260
Air Conditioner Maintenance............... 262
Air Conditioning........................ 171
Air Conditioning Controls................. 172
Air Conditioning, Operating Tips............ 174
Air Conditioning Refrigerant............... 263
Air Filter.............................. 260
Air Pressure, Tires....................... 216
Airbag................................ 27
Airbag Deployment....................... 31
Airbag Light.........................33,145
Airbag Maintenance....................... 33
Alignment and Balance................... 220
Alterations/Modifications, Vehicle............. 9
Antenna, Satellite Radio................... 167Antifreeze (Engine Coolant)................ 295
Anti-Lock Brake System (ABS).............. 200
Anti-Lock Warning Light.................. 147
Appearance Care........................ 279
Automatic Dimming Mirror................. 50
Automatic Transmission................184,274
Adding Fluid......................... 276
Fluid and Filter Changes................. 274
Fluid Level Check...................... 275
Fluid Type........................... 274
Gear Ranges.......................... 185
Shifting............................. 184
Special Additives...................... 276
Torque Converter...................... 190
Auxiliary Electrical Outlet.................. 69
Auxiliary Power Outlet.................... 69
Battery............................... 261
Emergency Starting..................... 242
332 INDEX

Voltmeter............................ 143
Belts, Drive............................ 257
Belts, Seat.............................. 20
Body Mechanism Lubrication............... 264
B-Pillar Location........................ 211
Brake System........................... 272
Anti-Lock........................... 200
Hoses.............................. 272
Master Cylinder....................... 273
Parking............................. 196
Warning Light........................ 147
Brakes............................... 198
Brake/Transmission Interlock............... 185
Break-In Recommendations, New Vehicle........ 44
Bulb Replacement.....................290,291
Calibration, Compass...................... 52
Capacities, Fluid........................ 295Caps, Filler
Fuel................................ 226
Power Steering........................ 263
Car Washes............................ 280
Carbon Monoxide Warning................. 225
Carpeting............................. 283
Cassette Tape and Player Maintenance......... 167
Catalytic Converter...................... 258
Caution, Exhaust Gas...................... 44
CD Changer........................... 154
CD Player....................150,152,156,159
CD Player Maintenance................... 168
Cellular Phone.......................... 169
Center High Mounted Stop Light............ 294
Chains, Tire............................ 221
Changing A Flat Tire..................... 238
Chart, Tire Sizing........................ 208
Check Engine Light
(Malfunction Indicator Light)...........145,251
INDEX 333
10