2005 JEEP WRANGLER clutch

▫Air Conditioner Maintenance.............262
▫Power Steering Fluid Check..............263
▫Driveline And Steering Component
Lubrication..........................264
▫Body Lubrication.....................264
▫Windshield Wiper Blades................265
▫Windshield Washers...................265
▫Exhaust System......................266
▫Cooling System.......................266
▫Hoses And Vacuum/Vapor Harnesses.......271
▫Brake System........................272
▫Automatic Transmission................274
▫Hydraulic Clutch Fluid — Manual
Transmission........................276▫Manual Transmission..................276
▫Transfer Case........................277
▫Front/Rear Axle Fluid..................278
▫Appearance Care And Protection From
Corrosion...........................279

Fuse Panel...........................286
▫Interior Fuses........................286
▫Underhood Fuses
(Power Distribution Center)..............288

Vehicle Storage........................290

Replacement Bulbs — If Equipped...........290

Bulb Replacement......................291
▫Head Light..........................291
▫Front Park/Turn Signal.................292
246 MAINTAINING YOUR VEHICLE

(cross-hatched area) on the oil level indicator. The fluid
level indicator should be in the COLD region at 70° F (21°
C) fluid temperature.
If the fluid level is low, add sufficient fluid to bring to the
proper level. Refer to Recommended Fluids, Lubricants
and Genuine Parts for correct fluid type.
Fluid is added through the dipstick tube.
NOTE:To prevent dirt and water from entering the
transmission after checking or replenishing fluid, make
certain that the dipstick cap is properly reseated.
Special Additives
The manufacturer strongly recommends against the ad-
dition of any additives to the transmission. The only
exception to this policy is the use of special dyes to aid in
detecting fluid leaks. The use of transmission sealers
should be avoided as they may adversely affect seals.
Hydraulic Clutch Fluid — Manual Transmission
The clutch hydraulic system is a sealed maintenance free
system. In the event of leakage or other malfunction, the
system must be replaced.
Manual Transmission
Selection of Lubricant
Use only manufacturer’s recommended manual trans-
mission fluid, refer to Recommended Fluids, Lubricants,
and Genuine Parts for correct fluid type.
Fluid Level Check
Check the fluid level by removing the fill plug. The fluid
level should be between the bottom of the fill hole and a
point not more than 3/16” (4.76 mm) below the bottom of
the hole.
Add fluid, if necessary, to maintain the proper level.
276 MAINTAINING YOUR VEHICLE

Cavity Fuse/Color Description
13 40 Amp Green Accessories
14 Open
15 50 Amp Red IOD
16 Open
17 20 Amp Yellow Power
18 20 Amp Yellow Horn
19 20 Amp Yellow Fog Lights
20 15 Amp Lt. Blue Radio
21 10 Amp Red A/C Clutch
22 25 Amp Natural Ignition Switch
23 20 Amp Yellow Fuel
24 20 Amp Yellow Off Road
25 Open
26 10 Amp Red Accessories
27 20 Amp Yellow MFSW
28 10 Amp Red Clutch OverrideCavity Fuse/Color Description
29 Relay ASD
30 Relay A/C Clutch
31 Relay Transmission
32 Relay Starter
33 Relay ABS
34 Open
35 Relay Fog Lamp
36 Relay Horn
37 Relay Fuel Pump
38 Relay HBL (Rear Window De-
froster)
39 Relay Front Differential Locker
(Rubicon) or High Speed
Fan (2.4L Engines)
40 Relay Rear Differential Locker
(Rubicon) or Low Speed
Fan (2.4L Engines)
MAINTAINING YOUR VEHICLE 289
7

Child Restraint......................34,38,41
Child Restraint Tether Anchors.............37,38
Climate Control......................... 169
Clock................................ 148
Clutch Interlocking Ignition System........178,183
Compact Disc Maintenance................. 168
Compass.............................. 50
Compass Calibration...................... 52
Compass Variance........................ 53
Console............................... 72
Console, Floor........................... 72
Contract, Service........................ 324
Converter, Catalytic...................... 258
Cooling System......................... 266
Adding Coolant (Antifreeze).............. 268
Coolant Capacity...................... 295
Coolant Level......................... 270
Disposal of Used Coolant................ 269
Drain, Flush, and Refill.................. 267Inspection........................... 266
Points to Remember.................... 270
Pressure Cap......................... 269
Selection of Coolant..................267,295
Temperature Gauge..................... 145
Corrosion Protection..................... 279
Crankcase Emission Control System.......... 260
Cruise Control (Speed Control)............... 66
Cruise Light........................... 143
Cup Holder............................ 70
Customer Assistance..................... 322
Daytime Running Lights................... 64
Dealer Service.......................... 252
Defroster, Rear Window................... 137
Defroster, Windshield..................171,173
Delay (Intermittent) Wipers................. 64
Deploying, Airbag........................ 31
Diagnostic System, Onboard................ 250
334 INDEX

Heater, Engine Block..................... 180
High Beam Indicator..................... 144
Holder, Cup............................ 70
Hood Release........................... 60
Hoses.............................271,272
Hydraulic Clutch Fluid.................... 276
Ignition
Key ................................. 13
Illuminated Entry........................ 17
Infant Restraint.......................... 34
Inflation Pressure Tires.................... 216
Inside Rearview Mirror.................... 50
Instrument Cluster....................... 142
Instrument Panel and Controls.............. 141
Interior Appearance Care.................. 283
Interior Fuses.......................... 286
Interior Lights........................... 61
Intermittent Wipers....................... 64Introduction............................. 4
Jack Location........................... 238
Jack Operation.......................238,240
Jacking Instructions...................... 240
Jump Starting.......................... 242
Key, Programming........................ 16
Key Release Button....................... 14
Key, Replacement........................ 16
Key, Sentry............................. 14
Key-In Reminder......................... 14
Keys................................. 13
Lane Change and Turn Signals.............. 143
Lap Belts.............................. 20
Lap/Shoulder Belts....................... 20
LATCH
(Lower Anchors and Tether for CHildren)....37,38
338 INDEX

Storage, Vehicle......................... 290
Storing Your Vehicle...................... 290
Supplemental Restraint System - Airbag........ 27
Tachometer............................ 143
Temperature Gauge, Engine Coolant.......... 145
Tether Anchor, Child Restraint............... 37
Tilt Steering Column...................... 66
Tire and Loading Information Placard......... 211
Tire Identification Number (TIN)............. 210
Tire Markings.......................... 207
Tire Safety Information.................... 207
Tires ................................. 215
Air Pressure.......................... 216
Alignment and Balance.................. 220
Chains.............................. 221
Changing............................ 238
General Information.................... 215
High Speed.......................... 217Inflation Pressures..................... 216
Jacking...........................238,240
Load Capacity...................... 211,212
Radial.............................. 218
Replacement......................... 219
Rotation............................. 221
Safety.............................. 207
Sizes............................... 208
Spare Tire........................... 239
Spinning............................ 218
Tread Wear Indicators................... 218
To Open Hood.......................... 60
Torque Converter Clutch.................. 190
Towing............................229,244
Disabled Vehicle....................... 244
Recreational.......................... 232
Trailering............................ 229
Trac-Lok Rear Axle...................... 194
Trailer Towing.......................... 229
344 INDEX