2005 HONDA CIVIC HYBRID fuel pump

Help assure your vehicle’s f uture
reliability and perf ormance by paying
extra attention to how you drive
during the f irst 600 miles (1,000 km).
During this period:Avoid full-throttle starts and rapid
acceleration.
You should also f ollow these
recommendations with an
overhauled or exchanged engine, or
when the brakes are replaced. Your vehicle is designed to operate
on unleaded gasoline with a pump
octane number of 86 or higher. Use
of a lower octane gasoline can cause
a persistent, heavy metallic rapping
noise that can lead to engine damage.
Do not change the oil until the
scheduled maintenance time.
Avoidhardbrakingforthefirst
200 miles (300 km). We recommend quality gasoline
containing detergent additives that
help prevent f uel system and engine
deposits.
Using gasoline containing lead will
damage your vehicle’s emissions
controls. This contributes to air
pollution.
In addition, in order to maintain good
perf ormance, f uel economy, and
emissions control, we strongly
recommend, in areas where it is
available, the use of gasoline that
does NOT contain manganese-based
f uel additives such as MMT. Some gasoline today is blended with
oxygenates such as ethanol or
MTBE. Your vehicle is designed to
operate on oxygenated gasoline
containing up to 10 percent ethanol
by volume and up to 15 percent
MTBE by volume. Do not use
gasoline containing methanol.
If you notice any undesirable
operating symptoms, try another
service station or switch to another
brand of gasoline.
For f urther important f uel-related
inf ormation, please ref er to your
.
Use of gasoline with these additives
may adversely af f ect perf ormance,
and cause the Malfunction Indicator
Lamp on your instrument panel to
come on. If this happens, contact
your dealer f or service.
Break-in Period
Fuel Recommendation
Quick Start Guide
Break-in Period, Fuel Recommendation
112

Open the f uel f ill door by pushing
onthehandletotheleftof the
driver’s seat. Park with the driver’s side closest
to the service station pump.Remove the f uel f ill cap slowly.
You may hear a hissing sound as
pressure inside the tank escapes. The fuel fill cap is attached to the
f uel f iller with a tether. Put the
attachment on the fuel fill cap into
the slit on the fuel fill door.
1.
2. 3.
CONT INUED
AT-PZEV
Service Station Procedures
Ref ueling
Bef ore Driving
113
Push
FUEL FILL CAPTETHER
ATTACHMENT
Gasoline is highly flammable
and explosive. You can be
burned or seriously injured
when handling fuel.
Stop the engine and keep
heat, sparks, and flame away.
Handle fuel only outdoors.
Wipe up spills immediately.

Place the cap in the holder on the
fuel fill door.Stop f illing the tank af ter the f uel
nozzle automatically clicks of f . Do
not try to ‘‘top of f ’’ the tank. Leave
some room f or the f uel to expand
with temperature changes.
even though the tank is not f ull,
there may be a problem with your
vehicle’s fuel vapor recovery
system. The system helps keep
f uel vapors f rom going into the
atmosphere. Try f illing at another
pump. If this does not f ix the
problem, consult your dealer.
Screw the f uel f ill cap back on
until it clicks at least three times.
If you do not properly tighten the
cap, the Malf unction Indicator
Lampmaycomeon(seepage
).
Push the f uel f ill door closed until
it latches.
4.
5.
6.190
If the f uel nozzle keeps clicking of f
ULEV
Service Station Procedures
114
HOLDER
FUEL FILL CAP

µµ
Î Î
Î
Î
Î
No. Amps. Circuits Protected No. Amps. Circuits Protected
1
2
3
4
5
15 A
20 A
(10 A) 10 A Ignition Coil IN
LAF Heater
(Daytime running lights )
FI-ECU
Not Used 6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26 7.5 A
7.5 A
15 A
7.5 A
7.5 A
(7.5 A) 10 A
10 A
(10 A) 7.5 A 15 A
15 A
7.5 A 20 A
7.5 A 20 A
20 A
20 A
20 A
7.5 A Power Window Relay
Not Used
Accessory, Radio
Ignition Coil EX
Meter
ABS
(Daytime running lights )
SRS
Remote Control Mirrors
(SCTY )
IMA
Fuel Pump
Accessory Power Socket
Turn Signal Lights
Front Wiper
STS (Steering Switch)
Front Right Power Window
Front Left Power Window
Rear Lef t Power Window
Rear Right Power Window
Cooling Fan Relay
1 : On Canadian models
2 : Optional Security System
1 1
2
Fuse Locations
196
INTERIOR FUSE BOX

Service Inf ormat ion Summary
Gasoline:
Fuel Tank Capacity:
Recommended Engine Oil:Brake Fluid:
Tire Pressure (measured cold):
Automatic Transmission Fluid
(CVT):
Manual Transmission Fluid:
30 psi (210 kPa , 2.1 kgf/cm
)
60 psi (420 kPa , 4.2 kgf/cm
)
13.2 US gal (50
)
3.4 US qt (3.2
)
11.9 US gal (45
)
Unleaded gasoline, pump octane
number of 86 or higher.
API Premium grade 0W-20
detergent oil (see page ).
Oil change capacity (including
filter): Honda Heavy Duty Brake Fluid
DOT 3 preferred, or a DOT 3 or
DOT 4 brake fluid as a temporary
replacement (see page ).
Use Honda ATF-Z1 (Automatic
Transmission Fluid) only
3.4 US qt (3.2
)
Capacity:
Front/Rear:
Spare Tire:
Honda Manual Transmission
Fluid preferred, or an SAE 10W-30
or 10W-40 motor oil as a
temporary replacement (see page
).
Capacity (including differential): 1.6 US qt (1.5
)
150 158
157
ULEV AT-PZEV