Page 3 of 272
Maintenance and specifications 162
Hood 169
Engine oil 170
Battery 180
Fuel information 189
Lubricant specifications 213
Refill capacities 222
General maintenance information 227
Index 263
All rights reserved. Reproduction by any means, electronic or mechanical
including photocopying, recording or by any information storage and retrieval
system or translation in whole or part is not permitted without written
authorization from Ford Motor Company. Ford may change the contents without
notice and without incurring obligation.
Copyright © 2004 Ford Motor Company
Table of Contents
3
2005 F650/750(f67)
Supplement
USA English(fus)
Page 42 of 272

16.Scan:Press for a brief sampling
of radio stations or CD tracks. Press
again to stop.
17.Disc tune:Radio: Press
orto manually tune down or up
the radio frequency band.
CD:Press
to select the previous track orto select the next track
on the CD.
RADIO FREQUENCIES
AM and FM frequencies are established by the Federal Communications
Commission (FCC) and the Canadian Radio and Telecommunications
Commission (CRTC). Those frequencies are:
AM - 530, 540–1700, 1710 kHz
FM- 87.7, 87.9–107.7, 107.9 MHz
RADIO RECEPTION FACTORS
There are three factors that can effect radio reception:
•Distance/strength: The further you travel from an FM station, the
weaker the signal and the weaker the reception.
•Terrain: Hills, mountains, tall buildings, power lines, electric fences,
traffic lights and thunderstorms can interfere with your reception.
•Station overload: When you pass a broadcast tower, a stronger signal
may overtake a weaker one and play while the weak station frequency
is displayed.
CASSETTE/PLAYER CARE
Do:
•Use only cassettes that are 90 minutes long or less.
•Tighten very loose tapes by inserting a finger or pencil into the hole
and turning the hub.
•Remove loose labels before inserting tapes.
•Allow tapes which have been subjected to extreme heat, humidity or
cold to reach a moderate temperature before playing.
•Clean the cassette player head with a cassette cleaning cartridge after
10–12 hours of play to maintain good sound/operation.
Entertainment systems
42
Page 170 of 272

4. Tilt the hood forward until
stopped by the retaining cables.
To lower the hood:
1. Push the hood rearward at the top center of the hood above the grille
until closed.
2. Engage the latch on each fender.
3. Push down on the bottom of each latch until locked.
To reduce the risk of the possibility of personal injury, never
stand beneath the hood when it is being raised or lowered.
ENGINE OIL
Checking engine oil level - Cummins B and Caterpillar engines
Refer to the appropriate engine operator’s manual for information on the
engine oil.
Checking engine oil level–6.0L Power Stroke engine
Refer to the general maintenance information section for the appropriate
intervals for checking the engine oil.
Check the engine oil level consistently and accurately. The following
procedure is recommended:
1. Start the engine and let it run until it reaches normal operating
temperature (the engine coolant temperature gauge indicator will be
near the center of the normal area between H and C).
2. Park the vehicle on level ground.
2005 F650/750(f67)
Supplement
USA English(fus)
Maintenance and specifications
170
Page 222 of 272

REFILL CAPACITIES
Rear axle
Axle codeWeight capacity -
lbs. (kg)DescriptionFluid capacity -
pints (liters)1,2
S135–S 13500 (6123) Single rear axle,
single reduction24.5 (11.6)
4S150–S 15500 (7031) Single rear axle,
single reduction24.5 (11.6)
17060S 17500 (7938) Single rear axle,
single reduction28.0 (13.2)
19055T 17500 (7938) Single rear axle,
two-speed28.0 (13.2)
M190–T 19000 (8618) Single rear axle,
two-speed35.0 (17.0)
19060S 19000 (8618) Single rear axle,
single reduction28.0 (13.2)
21060S 21000 (9525) Single rear axle,
single reduction28.0 (13.2)
21060D 21000 (9525) Single rear axle,
single reduction28.0 (13.2)
M210T 21000 (9525) Single rear axle,
two-speed16.0 (33.0)
23090S 23000 (10432) Single rear axle,
single reduction39.0 (18.5)
23090D 23000 (10432) Single rear axle,
single reduction
with
driver-controlled
locking differential39.0 (18.5)
23082T 23000 (10432) Single rear axle,
two-speed37.0 (17.5)
1Quantities listed are approximate. Fill axle until the lubricant level is at
the bottom of the filler hole, with the vehicle on level ground.
2If hubs are removed, add an additional 1.6 pints (0.75L) of axle
lubricant. Add lubricant through the axle vent.
2005 F650/750(f67)
Supplement
USA English(fus)
Maintenance and specifications
222
Page 224 of 272

Air conditioner refrigerant - r134a
Lbs. (Kg) Oz.
1.87 (.85) 30
Note:This system uses PAG-type refrigerant oil.
Refrigerant fitting torque
Captured washer nut: 170–190 inch lbs. (19–21 N•m)
Note:This system uses mineral based refrigerant oil to lubricate o-rings
and fittings.
Fuel tanks
Standard tanks are listed as such; all other tanks available for your
vehicle are optional equipment.
Vehicle Tank type Gallsons Liters
F-650 Low Profile
(standard), F-650
Dock HeightSingle, steel
rectangular35 132
F-650 Low Profile,
F-650 Dock Height
(standard), F-750
Pick-up and
Delivery
(standard), F-750
Severe Service
(standard)Single, steel
rectangular45 170
F-650 Dock Height,
F-750 Pick-up and
Delivery, F-750
Severe ServiceSingle, steel
rectangular50 189
F-650–Low Profile,
F-650 Dock Height,
F-750 Pick-up and
Delivery, F-750
Severe ServiceSingle, steel
rectangular65 246
F-650 Dock Height,
F-750 Pick-up and
Delivery, F-750
Severe ServiceSingle, steel D-style 65 246
2005 F650/750(f67)
Supplement
USA English(fus)
Maintenance and specifications
224
Page 225 of 272

Vehicle Tank type Gallsons Liters
F-650 Dock Height,
F-750 Pick-up and
Delivery, F-750
Severe ServiceSingle, steel D-style 80 302
F-650 Low Profile,
F-650 Dock Height,
F-750 Pick-up and
Delivery, F-750
Severe ServiceDual, steel
rectangular30 (LH)/45
(RH)114 (LH)/170
(RH)
F-650 Low Profile,
F-650 Dock HeightDual, steel
rectangular35 (RH)/45
(LH)132 (RH)/170
(LH)
F-650 Low Profile,
F-650 Dock Height,
F-750 Pick-up and
Delivery, F-750
Severe ServiceDual, steel
rectangular45/45 170/170
F-650 Dock Height,
F-750 Pick-up and
Delivery, F-750
Severe ServiceDual, steel D-style 50/50 189/189
F-650 Low Profile,
F-650 Dock Height,
F-750 Pick-up and
Delivery, F-750
Severe ServiceDual, steel
rectangular45 (RH)/65
(LH)170 (RH)/246
(LH)
F-650 Low Profile,
F-650 Dock Height,
F-750 Pick-up and
Delivery, F-750
Severe ServiceDual, steel
rectangular45 (LH)/65
(RH)170 (LH)/246
(RH)
F-650 Low Profile,
F-650 Dock Height,
F-750 Pick-up and
Delivery, F-750
Severe ServiceDual, steel
rectangular65/65 246/246
F-650 Dock Height,
F-750 Pick-up and
Delivery, F-750
Severe ServiceDual, steel D-style 65/65 246/246
2005 F650/750(f67)
Supplement
USA English(fus)
Maintenance and specifications
225
Page 248 of 272

ComponentLUBRICATION MAINTENANCE LEVEL CHART - CITY
City - 59,000 Miles or Less Annually - Miles, Kilometers or Months - Whichever Occurs First
Miles (000) 110 120 130 140 150 160 170 180 190 200
Kilometers (000) 176 192 208 224 240 256 272 288 304 320
Months 33 36 39 42 45 48 51 54 57 60
Non-driving front axle
Wheel bearing - oil type - check level••••••••••
Wheel bearing - oil type - change oil•••
Wheel bearing - grease type - repack•••
Tie rode ends - lubricate••••••••••
Drag link - lubricate••••••••••
King pin and bushing - lubricate••••••••••
Brake system - hydraulic
Master cylinder - check fluid level••••••••••
Park brake relay lever / linkage - lubricate•••
Steering
Power steering fluid - check level••••••••••
Power steering fluid - change fluid•••
Power steering filter - replacement Five years or 50,000 miles (80,000 km)
Steering gear Ross TAS - output seal - lubricate•••
Steering column u-joints / slip joint - lubricate••••••••••
Propeller shaft SPL
U-joint - lubricate•••••
Propeller shaft non-SPL
U-joint and slip joint - lubricate••••••••••
2005 F650/750(f67)
Supplement
USA English(fus)
General maintenance information
248
Page 249 of 272

ComponentLUBRICATION MAINTENANCE LEVEL CHART - CITY (Continued)
City - 59,000 Miles or Less Annually - Miles, Kilometers or Months - Whichever Occurs First
Miles (000) 110 120 130 140 150 160 170 180 190 200
Kilometers (000) 176 192 208 224 240 256 272 288 304 320
Months 33 36 39 42 45 48 51 54 57 60
Brake system - air
Slack adjusters - lubricate•••
S-cam - lubricate••••••••••
Clutch
Release bearing / shafts / fork - lubricate••••••••••
Cooling system
Coolant - check level••••••••••
Coolant - check freeze protection••••••••••
Extended life coolant - add extender See engine manufacturer’s recommendation
Extended life coolant - replace See engine manufacturer’s recommendation
Engine - refer to engine manual for Caterpillar and Cummins. 6.0L Power Stroke, see 6.0L engine section at
end of charts
Transmission
Automatic and Auto-shift transmission Refer to transmission operator’s manual
Manual transmission - check fluid level••••••••••
Eaton Fuller manual transmission - petroleum oil
change••
Eaton Fuller manual transmission - synthetic oil
change•
2005 F650/750(f67)
Supplement
USA English(fus)
General maintenance information
249