2005 FORD F650 service

ComponentLUBRICATION MAINTENANCE LEVEL CHART - SEVERE SERVICE (Continued)
Severe Service - On/Off Road in Dirty Conditions, 20,000 Miles or Less Annually - Miles, Km or Months -
Whichever Occurs First
Miles (000) 5 10 15 20 25 30 35 40 45 50
Kilometers (000) 8 16 24 32 40 48 56 64 72 80
Months 3 6 9 12 15 18 21 24 27 30
Propeller shaft - non-SPL
U-joint and slip joint - lubricate••••••••••
Brake system - air
Slack adjusters - lubricate••
S-cam - lubricate••••••••••
Clutch
Release bearing / shafts / forks••••••••••
Cooling system
Coolant - check level••••••••••
Coolant - check freeze protection••••••••••
Extended life coolant - add extender See engine manufacturer’s recommendation
Extended life coolant - replace See engine manufacturer’s recommendation
Engine - refer to engine manual for Caterpillar and Cummins. 6.0L Power Stroke see 6.0L engine section at
end of charts
Transmission
Automatic and Auto-shift transmissions Refer to transmission operator’s manual
Manual transmission - check fluid level••••••••••
Eaton Fuller manual transmission - petroleum oil
change••
2005 F650/750(f67)
Supplement
USA English(fus)
General maintenance information
252

ComponentLUBRICATION MAINTENANCE LEVEL CHART - SEVERE SERVICE (Continued)
Severe Service - On/Off Road in Dirty Conditions, 20,000 Miles or Less Annually - Miles, Km or Months -
Whichever Occurs First
Miles (000) 5 10 15 20 25 30 35 40 45 50
Kilometers (000) 8 16 24 32 40 48 56 64 72 80
Months 3 6 9 12 15 18 21 24 27 30
Rear axle
Fluid level - check••••••••••
Eaton / Dana / Spicer - petroleum oil change•••
Eaton / Dana / Spicer - synthetic oil change••
Cab components
Door hinges / latches / strikers - lubricate, check link••
Door lock cylinders - lubricate••
Seat adjuster slides - lubricate••
2005 F650/750(f67)
Supplement
USA English(fus)
General maintenance information
253

ComponentLUBRICATION MAINTENANCE LEVEL CHART - SEVERE SERVICE
Severe Service - On/Off Road in Dirty Conditions, 20,000 Miles or Less Annually - Miles, Km or Months -
Whichever Occurs First
Miles (000) 55 60 65 70 75 80 85 90 95 100
Kilometers (000) 88 96 104 112 120 128 136 144 152 160
Months 33 36 39 42 45 48 51 54 57 60
Non-driving front axle
Wheel bearing - oil type - check level••••••••••
Wheel bearing - oil type - change oil•••
Wheel bearing - grease type - repack•••
Tie rod ends - lubricate••••••••••
Drag link - lubricate••••••••••
King pin and bushing - lubricate••••••••••
Brake system - hydraulic
Master cylinder - check fluid level••••••••••
Park brake relay lever / linkage - lubricate•••
Steering
Power steering fluid - check level••••••••••
Power steering fluid - change fluid•••
Power steering filter - replacement•
Steering gear Ross TAS - output seal - lubricate•••
Steering column u-joints / slip joint - lubricate••••••••••
Propeller shaft SPL
Slip joint - inspect boot••••••••••
U-joint - lubricate••••••••••
2005 F650/750(f67)
Supplement
USA English(fus)
General maintenance information
254

ComponentLUBRICATION MAINTENANCE LEVEL CHART - SEVERE SERVICE (Continued)
Severe Service - On/Off Road in Dirty Conditions, 20,000 Miles or Less Annually - Miles, Km or Months -
Whichever Occurs First
Miles (000) 55 60 65 70 75 80 85 90 95 100
Kilometers (000) 88 96 104 112 120 128 136 144 152 160
Months 33 36 39 42 45 48 51 54 57 60
Propeller shaft non-SPL
U-joint and slip joint - lubricate••••••••••
Brake system - air
Slack adjusters - lubricate•••
S-cam - lubricate••••••••••
Clutch
Release bearing / shafts / fork - lubricate••••••••••
Cooling system
Coolant - check level••••••••••
Coolant - check freeze protection••••••••••
Extended life coolant - add extender See engine manufacturer’s recommendation
Extended life coolant - replace See engine manufacturer’s recommendation
Engine - refer to engine manual for Caterpillar and Cummins. 6.0L Power Stroke see 6.0L engine section at
end of charts
Transmission
Automatic and Auto-shift transmissions Refer to transmission operator’s manual
Manual transmission - check fluid level••••••••••
Eaton Fuller manual transmission - petroleum oil
change•••
2005 F650/750(f67)
Supplement
USA English(fus)
General maintenance information
255

ComponentLUBRICATION MAINTENANCE LEVEL CHART - SEVERE SERVICE (Continued)
Severe Service - On/Off Road in Dirty Conditions, 20,000 Miles or Less Annually - Miles, Km or Months -
Whichever Occurs First
Miles (000) 55 60 65 70 75 80 85 90 95 100
Kilometers (000) 88 96 104 112 120 128 136 144 152 160
Months 33 36 39 42 45 48 51 54 57 60
Eaton Fuller manual transmission - synthetic oil
change••
Rear axle
Fluid level - check••••••••••
Eaton / Dana / Spicer petroleum oil - change•••
Eaton / Dana / Spicer synthetic oil - change••
Cab components
Door hinges / latches / strikers - lubricate, check link•••
Door lock cylinders - lubricate•••
Seat adjuster slides - lubricate•••
Daily inspections
Check oil level•
Check coolant level
1
•
Drain water separator for fuel system•
Inspect for external leakage all systems•
Inspect air restriction indicator
3
•
2005 F650/750(f67)
Supplement
USA English(fus)
General maintenance information
256

6.0 Power Stroke Engine
ComponentMiles (000) 10 20 30 40 50 60 70 80 90 100 110 120
Hours 350 700 1050 1400 1750 2100 2450 2800 3150 3500 3850 4200
Kilometers (000) 16 32 48 64 80 96 112 128 144 160 176 192
Months 6 12 18 24 30 36 42 48 54 60 66 72
Change engine oil and filter
2
••••••••••••
Inspect belt••••••••••••
Clean fuel filter pre-strainer
1
••••••••••••
Change fuel filter
1,5
••••••
Measure air intake restriction
3,4
••••••
Service the cooling system•
Inspect electrical system (A) (Every 12
months, 160,000 km [100,000 miles] or 3,800
hours)•••••(A)•
Pressurize air induction system (every 12
months)••••••
2005 F650/750(f67)
Supplement
USA English(fus)
General maintenance information
257

6.0 Power Stroke Engine
ComponentMiles (000) 130 140 150 160 170 180 190 200 210 220 230 250
Hours 4550 4900 5250 5600 5950 6300 6650 7000 7350 7700 8050 8400
Kilometers (000) 208 224 240 256 272 288 304 320 336 352 368 384
Months 78 84 90 96 102 108 114 120 126 132 138 144
Change engine oil and filter
2
••••••••••••
Inspect belt••••••••••••
Clean fuel filter pre-strainer
1
••••••••••••
Change fuel filter
1,5
••••••
Measure air intake restriction
3,4
••••••
Service the cooling system•••
Inspect electrical system (A) (Every 12
months, 160,000 km [100,000 miles] or 3,800
hours)•••••(A)•
Pressurize air induction system (every 12
months)••••••
1If refueling source is prone to water contamination, also clean the fuel filter pre-strainer.2If fuel is more than 0.05% but less than 1.0% sulfur, change oil at 75% of regular interval. If 1.0%
or higher, change oil at 50% of scheduled interval.3Service air cleaner element as required.4Refer to PCED manual for specification.5Change according to transfer pump minimum specifications.
2005 F650/750(f67)
Supplement
USA English(fus)
General maintenance information
258

Maintenance Intervals/
Service PerformedService Shop
Name and Address Date
Service
PerformedMileage Maintenance Record
2005 F650/750(f67)
Supplement
USA English(fus)
General maintenance information
259