2005 FORD E-350 brakes

•If the vehicle goes from one type of surface to another (i.e., from
concrete to gravel) there will be a change in the way the vehicle
responds to a maneuver (steering, acceleration or braking). Again,
avoid these abrupt inputs.
AUTOMATIC TRANSMISSION OPERATION
Brake-shift interlock
This vehicle is equipped with a brake-shift interlock feature that prevents
the gearshift lever from being moved from P (Park) when the ignition is
in the ON position unless brake pedal is depressed.
If you cannot move the gearshift lever out of P (Park) with ignition in
the ON position and the brake pedal depressed:
1. Apply the parking brake, turn ignition key to LOCK, then remove the
key.
2. Insert the key and turn it to OFF.Apply the brake pedal and shift
to N (Neutral).
When the key is in the ignition and in the OFF position, the
automatic transmission shift lever can be moved from the P
(Park) position without the brake pedal depressed. To avoid unwanted
vehicle movement, always set the parking brake.
3. Start the vehicle.
If it is necessary to use the above procedure to move the gearshift lever,
it is possible that a fuse has blown or the vehicle’s brakelamps are not
operating properly. Refer toFuses and relaysin theRoadside
Emergencieschapter.
Do not drive your vehicle until you verify that the brakelamps
are working.
Always set the parking brake fully and make sure the gearshift is
latched in P (Park). Turn the ignition to the LOCK position and
remove the key whenever you leave your vehicle.
If the parking brake is fully released, but the brake warning lamp
remains illuminated, the brakes may not be working properly.
See your dealer or a qualified service technician as soon as possible.
2005 Econoline(eco)
Owners Guide (post-2002-fmt)
USA(fus)
Driving
153
ProCarManuals.com

A more complete description of PTO operation is discussed in the Ford
Truck Body Builders Layout Book, found at
www.fleet.ford.com/truckbbas.
DRIVING THROUGH WATER
If driving through deep or standing water is unavoidable, proceed very
slowly especially when the depth is not known. Never drive through
water that is higher than the bottom of the hubs (for trucks) or the
bottom of the wheel rims (for cars). When driving through water,
traction or brake capability may be limited. Also, water may enter your
engine’s air intake and severely damage your engine or your vehicle may
stall.Driving through deep water where the transmission vent
tube is submerged may allow water into the transmission and
cause internal transmission damage.
Once through the water, always dry the brakes by moving your
vehicle slowly while applying light pressure on the brake pedal.
Wet brakes do not stop the vehicle as quickly as dry brakes.
2005 Econoline(eco)
Owners Guide (post-2002-fmt)
USA(fus)
Driving
162
ProCarManuals.com

For E-450 and E-550 vehicles with the Hydro-Boost Brake
System, do not press the brake pedal after the engine has been
turned off.
5. Recheck the fluid level on the dipstick. Do not add fluid if the level is
between the arrows in the FULL COLD range.
6. If the fluid is low, add fluid in small amounts, continuously checking
the level until it reaches the FULL COLD range. Be sure to put the
dipstick back in the reservoir.
BRAKE FLUID
The fluid level will drop slowly as
the brakes wear, and will rise when
the brake components are replaced.
Fluid levels below the “MAX” line
that do not trigger the brake system
warning lamp are within the normal
operating range, there is no need to
add fluid. If the fluid levels are outside of the normal operating range,
the performance of your brake system could be compromised, seek
service from your dealer immediately.
DRIVELINE UNIVERSAL JOINT AND SLIP YOKE
Your vehicle may be equipped with universal joints that require
lubrication. Refer to thescheduled maintenance informationfor
maintenance intervals. If the original universal joints are replaced with
universal joints equipped with grease fittings, lubrication will also be
necessary.
TRANSMISSION FLUID
Checking automatic transmission fluid (if equipped)
Refer to yourscheduled maintenance informationfor scheduled
intervals for fluid checks and changes. Your transmission does not
consume fluid. However, the fluid level should be checked if the
transmission is not working properly, i.e., if the transmission slips or
shifts slowly or if you notice some sign of fluid leakage.
Automatic transmission fluid expands when warmed. To obtain an
accurate fluid check, drive the vehicle until it is at normal operating
temperature (approximately 20 miles [30 km]). If your vehicle has been
MAX
2005 Econoline(eco)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
220
ProCarManuals.com

A
Accessory delay ..........................56
Air cleaner filter ...............223–224
Airbag supplemental restraint
system ..........................................82
and child safety seats ..............84
description ................................82
disposal ......................................86
driver airbag ..............................84
indicator light ...........................86
operation ...................................84
passenger airbag .......................84
Ambulance packages ....................8
Antifreeze
(see Engine coolant) ................203
Anti-lock brake system
(see Brakes) ..............................149
Audio system
(see Radio) ....18–19, 22, 25, 28, 32
Automatic transmission
driving an automatic
overdrive .................154, 156, 159
fluid, adding ............................220
fluid, checking ........................220
fluid, refill capacities ..............226
fluid, specification ..................233
Auxiliary power point .................55
Axle
lubricant specifications ..230, 233
refill capacities ........................226
traction lok ..............................151
B
Battery .......................................201
acid, treating emergencies .....201
jumping a disabled battery ....174
maintenance-free ....................201replacement, specifications ...224
servicing ..................................201
BeltMinder ...................................77
Brakes ........................................149
anti-lock ...................................149
anti-lock brake system (ABS)
warning light ...........................149
fluid, checking and adding ....220
fluid, refill capacities ..............226
fluid, specifications .........230, 233
lubricant specifications ..230, 233
parking ....................................150
shift interlock ..........................153
Break-in period .............................6
Bulbs ............................................46
C
Capacities for refilling fluids ....226
Cell phone use ............................55
Child safety restraints ................87
child safety belts ......................87
Child safety seats ........................90
in front seat ..............................91
in rear seat ................................91
tether anchorage hardware .....94
Cleaning your vehicle
engine compartment ..............190
exterior ....................................193
instrument panel ....................192
interior .....................................192
interior trim ............................192
plastic parts ............................191
safety belts ..............................192
washing ....................................189
waxing .....................................189
wheels ......................................190
wiper blades ............................191
2005 Econoline(eco)
Owners Guide (post-2002-fmt)
USA(fus)
Index
240
ProCarManuals.com

L
Lamps
bulb replacement
specifications chart ..................46
daytime running light ...............42
headlamps .................................41
headlamps, flash to pass ..........42
instrument panel, dimming .....43
interior lamps ...........................45
replacing bulbs ...................46–50
Lane change indicator
(see Turn signal) ........................45
Lights, warning and indicator ....12
anti-lock brakes (ABS) ..........149
Load limits .................................126
Loading instructions .................133
Lubricant specifications ...230, 233
Lug nuts ....................................117
Lumbar support, seats ...............67
M
Mirrors
fold away ...................................57
side view mirrors (power) .......56
Motorcraft parts ................213, 224
O
Octane rating ............................212
Oil (see Engine oil) ..................198
P
Parking brake ............................150
Parts (see Motorcraft parts) ....224Power distribution box
(see Fuses) ...............................170
Power door locks ........................61
Power mirrors .............................56
Power point .................................55
Power steering ..........................150
fluid, checking and adding ....219
fluid, refill capacity ................226
fluid, specifications .........230, 233
Power Windows ...........................56
Preparing to drive your
vehicle ........................................151
R
Radio ..............18–19, 22, 25, 28, 32
Relays ................................166, 173
Remote entry system
illuminated entry ......................65
locking/unlocking doors ...........61
Roadside assistance ..................163
S
Safety Belt Maintenance ............81
Safety belts (see Safety
restraints) ........................72–74, 76
Safety defects, reporting ..........188
Safety restraints ....................72–76
belt minder ...............................77
extension assembly ..................80
for adults .............................73–74
for children .........................86–87
lap belt ......................................76
safety belt maintenance ...........81
warning light and chime ..........77
Safety seats for children ............90
2005 Econoline(eco)
Owners Guide (post-2002-fmt)
USA(fus)
Index
243
ProCarManuals.com