2005 DODGE DURANGO power steering

WARNING!
Fluid level should be checked on a level surface and
with the engine off to prevent injury from moving
parts and to insure accurate fluid level reading. Do
not overfill. Use only manufacturers recommended
power steering fluid.
If necessary, add fluid to restore to the proper indicated
level. With a clean cloth, wipe any spilled fluid from all
surfaces. Refer to Recommended Fluids, Lubricants, and
Genuine Parts for correct fluid type.
Front Suspension Ball Joints
The ball joints and seals should be inspected whenever
the vehicle is serviced for other reasons. Damaged seals
should be replaced to prevent leakage or contamination
of the grease.
Drive Shaft Constant Velocity Joints
All four wheel drive models are equipped with four
constant velocity joints. Periodic lubrication of these
joints is not required. However, the joint boot should be
inspected for external leakage or damage periodically. If
external leakage or damage is evident, the joint boot and
grease should be replaced immediately. Continued op-
eration could result in failure of the joint due to water
and dirt contamination of the grease. This would require
complete replacement of the joint assembly. Refer to the
Service Manual for the detailed replacement procedure.
Body Lubrication
Locks and all body pivot points, including such items as
seat tracks, doors,liftgate and hood hinges, should be
lubricated periodically to assure quiet, easy operation
and to protect against rust and wear. Prior to the appli-
cation of any lubricant, the parts concerned should be
wiped clean to remove dust and grit; after lubricating
excess oil and grease should be removed. Particular
MAINTAINING YOUR VEHICLE 321
7

D. Maintain coolant concentration at 50% HOAT ethyl-
ene glycol engine coolant (minimum) and distilled water
for proper corrosion protection of your engine.
E. Make sure that the radiator and coolant bottle over-
flow hoses are not kinked or obstructed.
F. Keep the front of the radiator clean. If your vehicle is
equipped with air conditioning, keep the front of the
condenser clean also.
G. The thermostat should not be changed for summer or
winter operation. If replacement is ever necessary, install
ONLY the correct type thermostat. Other designs may
result in unsatisfactory cooling performance.
Emission Related Components
Fuel System Hoses And Vapor/Vacuum Harnesses
When the vehicle is serviced for scheduled maintenance,
inspect surface of hoses and nylon tubing for evidence of
heat and mechanical damage. Hard and brittle rubber,cracking, checking, tears, cuts, abrasions, and excessive
swelling suggest deterioration of the rubber. Particular
attention should be given to examining hose surfaces
nearest to high heat sources, such as the exhaust mani-
fold.
Insure nylon tubing in these areas has not melted or
collapsed.
Inspect all hose clamps and couplings to make sure they
are secure and no leaks are present.
NOTE:Fluids such as oil, power steering fluid, and
brake fluid are used during assembly plant operations to
ease the assembly of hoses to couplings. Therefore, oil
wetness at the hose-coupling area is not necessarily an
indication of leakage. Actual dripping of hot fluid when
systems are under pressure (during vehicle operation),
should be noted before hose is replaced based on leakage.
MAINTAINING YOUR VEHICLE 329
7

Chassis
Component Fluids, Lubricants and Genuine Parts.
Automatic Transmission MoparATF+4, Automatic Transmission Fluid or equivalent.
Transfer Case MoparATF+4, Automatic Transmission Fluid or equivalent.
Front Axle SAE 75W-90 Multipurpose Type, GL-5 Gear Lubricant or equivalent.
Rear Axle SAE 75W-140 Synthetic Gear Lubricant or equivalent.
Brake Master Cylinder MoparDOT 3 and SAE J1703 should be used or equivalent. If DOT 3
brake fluid is not available, then DOT 4 is acceptable. Use only recom-
mended brake fluids.
Power Steering Reservoir MoparATF+4, Automatic Transmission Fluid or equivalent.
360 MAINTAINING YOUR VEHICLE

Axle Lubrication........................ 335
Ball Joints............................. 321
Battery............................... 318
Charging............................ 296
Emergency Starting..................... 296
Gas Caution.......................... 296
Keyless Transmitter Replacement............ 24
Saving Feature (Protection)............... 121
Belts, Drive............................ 315
Belts, Seat.............................. 29
Body Mechanism Lubrication............... 321
B-Pillar Location........................ 244
Brake Fluid............................ 360
Brake System........................236,330
Anti-Lock........................... 236
Disc Brakes.......................... 330
Fluid Check.......................... 331
Hoses.............................. 332Master Cylinder....................... 331
Parking............................. 234
Warning Light.....................167,169
Brakes............................... 236
Brake/Transmission Interlock............... 221
Break-In Recommendations, New Vehicle........ 64
Bulb Replacement....................... 349
Bulbs, Light............................ 348
Calibration, Compass..................... 140
Capacities, Fluid........................ 357
Caps, Filler
Fuel.............................262,263
Oil (Engine).......................... 313
Power Steering........................ 320
Radiator (Coolant Pressure)............... 324
Car Washes............................ 337
Carbon Monoxide Warning............65,144,266
Cargo Management System................. 156
INDEX 395
10

Points to Remember.................... 328
Radiator Cap......................... 327
Selection of Coolant...............326,357,359
Temperature Gauge..................... 164
Cruise Control (Speed Control).............. 132
Cup Holder............................ 154
Customer Assistance..................... 385
Data Recorder, Event...................... 52
Daytime Running Lights................... 123
Dealer Service.......................... 310
Defroster, Rear Window................... 213
Defroster, Windshield................66,200,205
Delay (Intermittent) Wipers................. 126
Diagnostic System, Onboard................ 307
Dimmer Switch, Headlight................. 165
Dipsticks
Automatic Transmission................. 332
Oil (Engine).......................... 311Power Steering........................ 320
Disarming, Theft System................... 25
Disc Brakes............................ 330
Disposal
Used Coolant......................... 325
Door Ajar Light......................... 169
Door Locks............................. 13
Door Opener, Garage..................... 142
Drive Belts............................ 315
Drive Shaft Universal Joints................ 321
Electric Remote Mirrors.................... 76
Electrical Power Outlets................... 151
Electronic Speed Control................... 132
Emergency, In Case of
Freeing Vehicle When Stuck............... 239
Jacking............................. 291
Overheating.......................... 327
Tow Hooks.......................... 298
INDEX 397
10

Turn Signal.....................125,164,350
Flat Tire Stowage.....................289,295
Flooded Engine Starting................... 219
Floor Console.......................... 153
Fluid, Brake.........................331,360
Fluid Capacities......................... 357
Fluid Level Checks
Automatic Transmission................. 332
Brake............................... 331
Cooling System....................... 324
Engine Oil........................... 311
Power Steering........................ 320
Transfer Case......................... 335
Fog Lights..........................124,356
Folding Rear Seat.....................106,109
Four Wheel Drive....................... 226
Operation........................... 226
Four-Way Hazard Flasher.................. 286
Freeing A Stuck Vehicle................... 239Front Axle............................. 336
Fuel................................. 260
Adding............................. 262
Filter............................... 316
Gauge.............................. 164
Octane Rating......................260,359
Requirements......................260,357
Tank Capacity........................ 357
Fueling............................... 262
Fuses.............................152,341
Garage Door Opener..................... 142
GasCap ...........................263,307
Gas Gauge (Fuel Gauge)................... 164
Gasoline.............................. 260
Gasoline, Reformulated................... 261
Gauges
Coolant Temperature.................... 164
Fuel................................ 164
INDEX 399
10

Hazard Warning Flasher................. 286
Headlights........................... 123
High Beam........................... 126
High Beam/Low Beam Select............. 126
Instrument Cluster..................123,164
Interior..........................121,136
License............................. 354
Lights On Reminder.................... 124
Low Fuel.........................164,165
Malfunction Indicator................... 170
Park............................... 123
Passing............................. 125
Seat Belt Reminder..................... 165
Service.............................. 348
Turn Signal........................125,350
Warning (Instrument Cluster Description)..... 164
Washer Fluid......................... 170
Loading Vehicle......................... 268
Tires ............................... 244Locks................................. 13
Auto Unlock.......................... 16
Automatic Door........................ 15
Child Protection........................ 17
Door................................ 13
Ignition.............................. 12
Keys................................. 9
Power Door........................... 14
Steering Wheel......................... 12
Lower Anchors and Tether for CHildren (LATCH) . 57
Lubricating Oil......................... 336
Lubrication, Body....................... 321
Lug Nuts............................. 294
Luggage Carrier......................... 155
Lumbar Support........................ 103
Maintenance Free Battery.................. 318
Maintenance Procedures................... 310
Maintenance Schedule.................... 363
402 INDEX

Outside Rearview Mirrors.................. 75
Overdrive..........................167,223
Overdrive OFF Switch.................... 223
Overhead Console....................135,136
Overhead Travel Information Center.......... 136
Overheating, Engine...................166,327
Owner’s Manual........................ 390
Panic Alarm............................ 21
Parking Brake.......................... 234
Parking On Hill......................... 234
Passing Light........................... 125
Pedals, Adjustable....................... 130
Pets.................................. 64
Pets, Transporting........................ 64
Phone, Cellular.......................... 78
Phone, Hands-Free....................... 78
Placard, Tire and Loading Information......... 245
Positive Crankcase Valve.................. 330Power
Brakes.............................. 330
Distribution Center..................341,345
Door Locks.........................13,14
Mirrors.............................. 76
Outlet.............................. 151
Steering..........................238,320
Sunroof............................. 149
Windows............................. 27
Power Steering Fluid..................... 360
Pregnant Women and Seat Belts.............. 37
Preparation for Jacking.................... 291
Pretensioners
Seat Belts............................. 35
Programmable Electronic Features.........144,148
Programming Transmitters............22,144,148
Radial Ply Tires......................... 252
Radiator Cap (Coolant Pressure Cap).......... 327
404 INDEX