2005 DODGE CARAVAN spare tire

Jack Location—Non Fold-in-Floor Seating
The jack, jack handle are stowed behind the rear left side
trim panel in the rear cargo area. Pull up on the lever to
release the cover.
Remove the spare wheel, scissors jack and jack handle
from stowage by rotating the wing nut to the left.
Spare Tire Stowage—Non Fold-in-Floor Seating
For vehicles not equipped with fold-in-floor seating the
spare tire is stowed under the rear of the vehicle by
means of a cable winch mechanism. To remove or stow
the spare, use the jack handle to rotate the“spare tire
drive”nut. The nut is located under the plastic cover at
the center rear of the cargo floor area, just inside the
liftgate opening.
Jack Location
360 WHAT TO DO IN EMERGENCIES

Jacking Instructions—Non Fold-in-Floor Seating
1. Loosen (but do not remove) the wheel lug nuts by
turning them to the left one turn while the wheel is still
on the ground.2. Fit the jack handle over the drive nut. Rotate the nut to
the left until the spare is on the ground with enough slack
cable to allow you to pull the tire out from under the
vehicle.
CAUTION!
The winch mechanism is designed for use with the
jack handle only. Use of an air wrench or other
power tools is not recommended and can damage the
winch.
3. When the spare is clear, tilt the retainer at the end of
the cable and pull it through the center of the wheel.
4. There are two jack engagement locations on each side
of the body—refer to the following illustration.
Lowering Spare Tire
WHAT TO DO IN EMERGENCIES 361
6

5. These locations are on the sill flange of the body and
consist of a pair of downstanding tabs. The jack is to be
located, engaging the flange, between the pair of tabs
closest to the wheel to be changed. Place the wrench on
the jack screw and turn to the right until the jack head is
properly engaged in the described location.Do not raise
the vehicle until you are sure the jack is securely
engaged.
6. Raise the vehicle by turning the jack screw to the right,
using the swivel wrench. Raise the vehicle only until the
tire just clears the surface and enough clearance is
obtained to install the spare tire. Minimum tire lift
provides maximum stability.WARNING!
Raising the vehicle higher than necessary can make
the vehicle less stable. It could slip off the jack and
hurt someone near it. Raise the vehicle only enough
to remove the tire.
7. Remove the wheel lug nuts, for vehicles with wheel
covers, remove the cover from the wheel by hand. Do not
pry the wheel cover off. Then pull the wheel off the hub.
8. Install the spare wheel, for vehicles with wheel covers,
align the notch in the wheel cover with the valve stem on
the wheel. Install the cover on the wheel by hand only
and install the wheel lug nuts with the cone shaped end
of the nut toward the wheel. Lightly tighten the lug nuts.
To avoid the risk of forcing the vehicle off the jack, do not
tighten the lug nuts fully until the vehicle has been
lowered.
WHAT TO DO IN EMERGENCIES 363
6

NOTE:Do not install the wheel cover on the compact
spare.
Do not use a hammer or force to install the wheel covers.
9. Lower the vehicle by turning the jack screw to the left.
10. Finish tightening the lug nuts. Push down on the
wrench while tightening for increased leverage. Alternate
lug nuts until each nut has been tightened twice. Correct
wheel nut tightness is 130 N·m (95 ft. lbs). If in doubt
about the correct tightness, have them checked with a
torque wrench by your dealer or at a service station.
11. Lower the jack to its fully closed position.WARNING!
A loose tire or jack, thrown forward in a collision or
hard stop could endanger the occupants of the ve-
hicle. Always stow the jack parts and the spare tire in
the places provided.
12. Secure the flat or spare tire as follows:
•If your vehicle is equipped with cast aluminum
wheels, the center cap of the wheel must be re-
moved prior to flat tire stowage. Store the center cap
inside the glove box or other storage compartment.
•Turn the wheel so that the valve stem is down. Slide
the wheel retainer through the center of the wheel
and position it properly across the wheel opening.
364 WHAT TO DO IN EMERGENCIES

•For convenience in checking the spare tire inflation,
stow with the valve stem toward the rear of the
vehicle.
•Using the jack handle, rotate the drive nut to the
right until the wheel is drawn into place against the
underside of the vehicle.
•Continue to rotate the nut until you hear the mecha-
nism click three times. It cannot be overtightened.
Push against the tire several times to be sure it is
securely in place.
13. Stow the jack and jack handle.
14. Check the tire pressure as soon as possible. Correct
pressure as required.
JUMP-STARTING PROCEDURES IF BATTERY IS
LOW
WARNING!
Take care to avoid the radiator cooling fan whenever
the hood is raised. It can start anytime the ignition
switch is on. You can be hurt by the fan.
WHAT TO DO IN EMERGENCIES 365
6

Caps, Filler
Fuel................................ 334
Oil (Engine).......................... 382
Radiator (Coolant Pressure)............... 396
Car Washes............................ 407
Carbon Monoxide Warning................. 333
Cargo Compartment
Luggage Carrier....................... 182
Cargo (Vehicle Loading)................... 181
Cassette Tape and Player Maintenance......... 260
Cassette Tape Player................206,216,221
Catalytic Converter...................... 385
Caution, Exhaust Gas..............38,83,333,393
CD Changer................215,224,238,240,243
CD Player.........212,216,223,226,229,233,236,243
CD Player Maintenance................... 261
Cellular Phone........................96,261
Center High Mounted Stop Light............ 420
Center Lap Belts......................... 50Chains, Tire............................ 327
Changing A Flat Tire..................... 346
Chart, Tire Sizing........................ 309
Check Engine Light (Malfunction
Indicator Light)......................202,377
Child Restraint.......................... 69
Child Restraint Tether Anchors............... 74
Child Safety Locks........................ 33
Child Seat............................68,76
Clean Air Gasoline....................... 331
Climate Control......................... 262
Clock................................ 204
Compact Disc Changer.................... 240
Compact Disc Maintenance................. 261
Compact Disc Player..................206,212
Compact Spare Tire...................... 320
Compass.............................. 151
Compass Calibration..................... 152
Compass Variance....................... 152
460 INDEX

Pretensioners.......................... 50
Rear Seat............................. 42
Untwisting Procedure.................... 48
Seats................................. 107
Adjustment.......................... 107
Bench............................126,128
Easy Entry........................... 120
Easy-Out Roller....................... 126
Heated.............................. 110
Integrated, Child....................... 68
Lumbar Support....................... 112
Power.............................. 108
Reclining......................... 110,112
Removal.......................121,124,126
Tilting.............................. 120
Security Alarm (Theft Alarm)................ 27
Selection of Coolant...................395,422
Sentry Key............................. 13
Sentry Key Programming................... 15Service Assistance....................448,449
Service Contract......................... 450
Service Engine Soon Light (Malfunction Indicator) . 202
Service Manuals........................ 454
Setting the Clock........................ 204
Shoulder Belts........................... 42
Signals, Turn...................138,197,418,419
Sliding Door............................ 29
Slippery Surfaces, Driving On............... 367
Snow Chains (Tire Chains)................. 327
Snow Tires............................ 329
Spare Tire.....................320,321,349,360
Spark Plugs............................ 384
Speed Control.......................... 147
Speedometer........................... 197
Starting............................... 292
Engine Fails to Start.................293,295
Starting and Operating.................... 292
INDEX 471
10

Compact Spare........................ 320
Flat Changing........................ 355
General Information.................... 316
High Speed.......................... 319
Inflation Pressures..................... 317
Jacking........................346,347,359
Load Capacity.....................312,313
Pressure Monitor System................. 325
Quality Grading....................... 455
Radial.............................. 320
Replacement......................... 323
Rotation............................. 329
Safety...........................308,316
Sizes............................... 309
Snow Tires........................... 329
Spare Tire.........................349,360
Spinning............................ 322
Tread Wear Indicators................... 322Towing............................... 338
Disabled Vehicle....................... 369
Trailering............................ 338
Traction Control...................143,203,306
Traction Control Switch.................143,306
Trailer Towing.......................... 338
Minimum Requirements................. 339
Trailer and Tongue Weight................ 339
Transaxle............................. 297
Automatic........................... 297
Operation........................... 297
Overdrive........................... 300
Selection of Lubricant................403,423
Transmission........................... 402
Automatic........................... 402
Filter............................... 405
Fluid............................403,423
Transmitter Battery Service.................. 26
INDEX 473
10