2005 DODGE CARAVAN check oil

replaced immediately! Eventual deterioration of the hose
can take place resulting in a possibility of a burst failure.
WARNING!
Worn brake hoses can burst and cause brake failure.
You could have an accident. If you see any signs of
cracking, scuffing, or worn spots, have the brake
hoses replaced immediately.
Master Cylinder—ABS Brakes Brake Fluid Level
Check
The fluid level in the master cylinder should be checked
when performing underhood services, or immediately if
the brake system warning light indicates system failure.
Clean the top of the master cylinder area before removing
the cap. Add fluid to bring the level up to the top of the
“FULL”mark on the side of the master cylinder reservoir.Overfilling of fluid is not recommended because it may
cause leaking in the system.
Add enough fluid to bring the level up to the require-
ments described on the brake fluid reservoir. With disc
brakes, fluid level can be expected to fall as the brake
pads wear. However, low fluid level may be caused by a
leak and a checkup may be needed.
Use only manufacturers recommended brake fluid, refer
to Recommended Fluids, Lubricants and Genuine Parts
for correct fluid type.WARNING!
Use of brake fluid that may have a lower initial
boiling point or unidentified as to specification, may
result in sudden brake failure during hard pro-
longed braking. You could have an accident.
MAINTAINING YOUR VEHICLE 401
7

•Taxi, police, or delivery service (commercial ser-
vice).
•Off-road or desert operation.
NOTE:Most vehicles are operated under the conditions
listed for ScheduleB.
Second is Schedule“A”. It is for vehicles that are not
operated under any of the conditions listed under Sched-
uleB.
Use the schedule that best describes your driving condi-
tions. Where time and mileage are listed, follow the
interval that occurs first.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
At Each Stop for Fuel
•Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required.
MAINTENANCE SCHEDULES 427
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Once a Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder and transmission; add as needed.
•Check all lights and all other electrical items for correct
operation.At Each Oil Change
•Change the engine oil filter.
•Inspect the exhaust system.
•Inspect the brake hoses.
•Inspect the CV joints and front suspension compo-
nents.
•Check the automatic transmission fluid level.
•Check the coolant level, hoses, and clamps.
428 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 78, 000 84, 000 90, 000 96, 000 100, 000
(Kilometers) (125 000) (134 000) (144 000) (154 000) (160 000)
[Months] [78] [84] [90] [96]
Change engine oil and engine oil filter. X X X X
Rotate Tires X X X X
Inspect the brake linings. X
Inspect the engine air cleaner filter, replace if neces-
sary. *XX XX
Replace theengine air cleaner filter.X
Replace thespark plugson 2.4 liter engines. X
Inspect the tie rod ends and boot seals. X
Inspect and adjust the power steering pump belt
tension on 2.4 liter engines.X
Inspect the generator belt on 2.4 liter engines, re-
place if necessary.X
Check and replace thePCV valve, if necessary.* X
Inspect the serpentine drive belt on 3.3 liter and 3.8
liter engines, replace if necessary.‡X
SCHEDULE“A”443
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 102, 000 108, 000 114, 000 120, 000
(Kilometers) (163 000) (173 000) (182 000) (192 000)
[Months] [102] [108] [114] [120]
Change engine oil and engine oil filter. X X X X
Rotate Tires X X X X
Inspect the brake linings. X
Inspect the engine air cleaner filter, replace if necessary. * X X X
Replace theengine air cleaner filter.X
Replace thespark plugson 2.4 liter engines. X
Replace theignition cables2.4 liter engines. X
Inspect and adjust the power steering pump belt tension
on 2.4 liter engines.X
Inspect the tie rod ends and boot seals. X
Check thePCV valveand replace, if necessary.* X
Inspect the serpentine drive belt on 3.3 liter and 3.8 liter
engines, replace if necessary.‡XX
Replace theengine timing belton 2.4 liter engines only. X
SCHEDULE“A”445
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Caps, Filler
Fuel................................ 334
Oil (Engine).......................... 382
Radiator (Coolant Pressure)............... 396
Car Washes............................ 407
Carbon Monoxide Warning................. 333
Cargo Compartment
Luggage Carrier....................... 182
Cargo (Vehicle Loading)................... 181
Cassette Tape and Player Maintenance......... 260
Cassette Tape Player................206,216,221
Catalytic Converter...................... 385
Caution, Exhaust Gas..............38,83,333,393
CD Changer................215,224,238,240,243
CD Player.........212,216,223,226,229,233,236,243
CD Player Maintenance................... 261
Cellular Phone........................96,261
Center High Mounted Stop Light............ 420
Center Lap Belts......................... 50Chains, Tire............................ 327
Changing A Flat Tire..................... 346
Chart, Tire Sizing........................ 309
Check Engine Light (Malfunction
Indicator Light)......................202,377
Child Restraint.......................... 69
Child Restraint Tether Anchors............... 74
Child Safety Locks........................ 33
Child Seat............................68,76
Clean Air Gasoline....................... 331
Climate Control......................... 262
Clock................................ 204
Compact Disc Changer.................... 240
Compact Disc Maintenance................. 261
Compact Disc Player..................206,212
Compact Spare Tire...................... 320
Compass.............................. 151
Compass Calibration..................... 152
Compass Variance....................... 152
460 INDEX

Door Locks, Automatic.................... 19
Door Opener, Garage..................... 159
Drive Belts............................ 383
Drive Shaft Universal Joints................ 391
Driving
On Slippery Surfaces.................... 367
DVD Player............................ 243
Electric Remote Mirrors.................... 94
Electrical Power Outlets................... 168
Electronic Speed Control................... 147
Electronic Vehicle Information Center......... 155
Emergency, In Case of
Hazard Warning Flasher................. 344
Jacking........................346,347,359
Jump Starting......................... 365
Overheating.......................... 345
Emission Control System Maintenance......377,426
Engine............................374,375Air Cleaner.......................... 385
Air Cleaner Filter...................... 384
Block Heater......................... 296
Break-In Recommendations................ 82
Checking Oil Level..................... 379
Compartment......................374,375
Coolant (Antifreeze).................... 422
Cooling............................. 394
Exhaust Gas Caution..................38,333
Fails to Start.......................293,295
Fuel Requirements..................330,421
Oil ...........................379,421,422
Oil Change Interval.................... 381
Oil Disposal.......................... 383
Oil Filler Cap......................... 382
Oil Filter Disposal...................... 383
Oil Selection.......................381,421
Oil Synthetic......................... 383
Overheating.......................... 345
462 INDEX

Temperature Gauge..................... 200
Exhaust Gas Caution..............38,83,333,393
Exhaust System......................... 393
Extender, Seat Belt........................ 52
Exterior Folding Mirrors................... 93
Filters
Air Cleaner.......................... 384
Air Conditioning....................284,389
Automatic Transaxle.................... 405
Engine Oil........................383,422
Engine Oil Disposal.................... 383
Flashers
Hazard Warning....................... 344
Turn Signal.....................197,418,419
Flat Tire Stowage........................ 355
Fluid Capacities......................... 421
Fluid Leaks............................. 85Fluid Level Checks
Automatic Transmission................. 404
Brake............................... 401
Power Steering........................ 390
Fog Light Service........................ 419
Fog Lights..........................138,419
Freeing A Stuck Vehicle................... 368
Fuel................................. 330
Adding............................. 334
Additives............................ 332
Clean Air............................ 331
Filler Cap............................ 334
Gasoline............................ 330
Gauge.............................. 196
Hoses.............................. 402
Light............................... 197
Octane Rating......................330,422
Requirements......................330,421
Tank Capacity........................ 421
INDEX 463
10