2005 CHRYSLER SEBRING CONVERTIBLE service schedule

WARNING!
Riding the brakes can lead to brake failure and
possibly an accident. Driving with your foot resting
or riding on the brake pedal can result in abnormally
high brake temperatures, excessive lining wear, and
possible brake damage. You may not have your full
braking capacity in an emergency.
Brake and Power Steering System Hoses
When servicing the vehicle for scheduled maintenance,
inspect surface of hoses and nylon tubing for evidence of
heat and mechanical damage. Hard and brittle rubber,
cracking, checking, tears, cuts, abrasion, and excessive
swelling suggest deterioration of the rubber. Particular
attention should be made to examining those hose sur-
faces nearest to high heat sources, such as the exhaust
manifold.
Inspect all hose clamps and couplings to make sure they
are secure and no leaks are present.
Insure nylon tubing in these areas has not melted or
collapsed.
NOTE:Often, fluids such as oil, power steering fluid,
and brake fluid are used during assembly plant opera-
tions to ease the assembly of hoses to couplings. There-
fore, oil wetness at the hose-coupling area is not neces-
sarily an indication of leakage. Actual dripping of hot
fluid when systems are under pressure (during vehicle
operation) should be noted before hose is replaced based
on leakage.
NOTE:Inspection of brake hoses should be done
whenever the brake system is serviced and every engine
oil change.
WARNING!
Worn brake hoses can burst and cause brake failure.
You could have an accident. If you see any signs of
cracking, scuffing, or worn spots, have the brake
hoses replaced immediately.
MAINTAINING YOUR VEHICLE 225
7

EMISSION CONTROL SYSTEM MAINTENANCE
The“Scheduled”maintenance services, listed inbold
typemust be done at the times or mileages specified to
assure the continued proper functioning of the emission
control system. These, and all other maintenance services
included in this manual, should be done to provide best
vehicle performance and reliability. More frequent main-
tenance may be needed for vehicles in severe operating
conditions such as dusty areas and very short trip
driving.
Inspection and service also should be done any time a
malfunction is suspected.
NOTE:Maintenance, replacement, or repair of the
emission control devices and systems on your vehicle
may be performed by any automotive repair establish-
ment or individual using any automotive part which has
been certified pursuant to U.S. EPA or, in the State of
California, California Air Resources Board regulations.
MAINTENANCE SCHEDULES
There are two maintenance schedules that show the
requiredservice for your vehicle.
First is Schedule“B”. It is for vehicles that are operated
under the conditions that are listed below and at the
beginning of the schedule.
•Day or night temperatures are below 32°F(0°C).
•Stop and go driving.
•Extensive engine idling.
•Driving in dusty conditions.
•Short trips of less than 10 miles (16 km).
•More than 50% of your driving is at sustained high
speeds during hot weather, above 90°F (32°C).
•Trailer towing.
•Taxi, police, or delivery service (commercial ser-
vice).
•Off-road or desert operation.
250 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

SCHEDULE“B”
Follow schedule“B”if you usually operate your vehicle
under one or more of the following conditions. Change
the automatic transmission fluid and filter every 60,000
miles (96 000 km) if the vehicle is usually operated under
one or more of the conditions marked with an.
•Day or night temperatures are below 32°F(0°C).
•Stop and go driving.
•Extensive engine idling.
•Driving in dusty conditions.
•Short trips of less than 10 miles (16.2 km).
•More than 50% of your driving is at sustained high
speeds during hot weather, above 90°F (32°C).
•Trailer towing.
•Taxi, police or delivery service (commercial ser-
vices).
•Off-road or desert operation.
•If equipped for and operating with E-85 (ethanol)
fuel.
NOTE:IfANYof these apply to you then change your
engine oil every 3,000 miles (5 000 km) or 3 months,
whichever comes first and follow schedule“B”of the
Maintenance Schedulessection of this manual.
NOTE:IFANYof these apply to you then flush and
replace the engine coolant every 100,000 miles (160,000
km) or 60 months, whichever comes first, and follow
schedule B of theMaintenance Schedulessection of this
manual.
SCHEDULE“B”253
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 108,000 111,000 114,000 117,000 120,000
(Kilometers) (174 000) (179 000) (183 000) (188 000) (193 000)
Change engine oil and engine oil filter, if not re-
placed at 3 months.XXXXX
Inspect theair cleaner filterand replace if neces-
sary.*XXXX
Replace theair cleaner filter.X
Replace thespark plugson the 2.4 liter engine. X
Replace theignition cableson the 2.4 liter engine. X
Inspect the front and rear brake pads, linings, ro-
tors, rear drums and shoes.XX
Replace the accessory drive belts on 2.7 liter engine. X
Check and replace, if necessary, thePCV valve.*X
Change the automatic transmission fluid and fil-
ter.X
Flush and replace engine coolant at 120 months, if
not done at 100,000 miles.X
Rotate the tires. X X
* This maintenance is recommended by the manufacture
to the owner but is not required to maintain the emis-
sions warranty.‡This maintenance is not required if previously replaced.
Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all receipts.
260 SCHEDULE“B”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 108,000 114,000 120,000
(Kilometers) (174 000) (183 000) (193 000)
[Months] [108] [114] [120]
Change engine oil and engine oil filter. X X X
Inspect theair cleaner filterand replace if required.* X X
Replace theair cleaner filter.X
Inspect the front and rear brake pads, linings, rotors, rear drums
and shoes.X
Replace thespark plugson 2.4 liter engine. X
Check and replace, if necessary, thePCV valve.*‡X
Replace theengine timing belton 2.4 liter engine. X
Replace the accessory drive belts in 2.7 liter engine. X
Replace theignition cableson 2.4 liter engine. X
Flush and replace engine coolant at 120 months, if not done at
100,000 miles.X
Rotate the tires. X X X
* This maintenance is recommended by the manufacture
to the owner but is not required to maintain the emis-
sions warranty.
‡This maintenance is not required if previously replaced.Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
264 SCHEDULE“A”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

WARNING!
You can be badly injured working on or around a
motor vehicle. Do only that service work for which
you have the knowledge and the right equipment. If
you have any doubt about your ability to perform a
service job, take your vehicle to a competent me-
chanic.
SCHEDULE“A”265
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Maintenance Procedures.................. 206
Maintenance Schedule................... 250
Light Duty ScheduleB................ 253
ScheduleA......................... 261
ScheduleB......................... 253
Malfunction Indicator Light.............92,204
Manual, Service........................ 272
Mirrors............................... 58
Electric Remote....................... 60
Outside............................. 60
Rearview............................ 58
Vanity.............................. 61
Modifications/Alterations, Vehicle............ 6
Mopar Parts........................205,272
Multi-Function Control Lever............... 69
Navigation System...................... 121
Occupant Restraints...................... 23
Odometer............................. 93
Tampering........................... 93
Trip ................................ 93
Oil, Engine......................206,246,247Capacity............................ 246
Change Interval...................... 207
Checking........................... 206
Disposal............................ 210
Filter...........................210,247
Filter Disposal....................... 210
Identification Logo.................182,208
Materials Added to.................... 210
Pressure Gauge....................... 94
Quality..........................182,208
Recommendation..................208,246
Synthetic........................... 209
Viscosity.........................209,246
Onboard Diagnostic System............203,204
Opener, Garage Door..................... 77
Operator Manuals (Owner’s Manuals)......... 4
Overdrive............................ 150
Overheating, Engine..................... 186
Owner’s Manual......................4,272
Paint Care............................ 229
Paint Damage......................... 229
Panic Alarm........................... 17
286 INDEX

Rotation, Tires......................... 172
Safety Checks Inside Vehicle............... 44
Safety Checks Outside Vehicle.............. 45
Safety Defects, Reporting................. 272
Safety Information, Tire.................. 156
Safety Tips............................. 44
Schedule, Maintenance................... 250
Seat Belt Maintenance................... 234
Seat Belt Reminder...................... 28
Seat Belts.........................23,24,41
And Pregnant Women.................. 29
Child Restraint....................35,36,41
Extender............................ 29
Front Seat............................ 25
Inspection........................... 44
Operating Instructions.................. 25
Pretensioners......................... 27
Reminder............................ 96
Seats................................. 61
Adjustment.......................... 61
Cleaning............................ 232
Head Restraints....................... 65Lumbar Support....................... 62
Power.............................. 63
Reclining............................ 62
Security Alarm (Theft Alarm)............... 19
Selection of Coolant..................221,247
Sentry Key...........................9,10
Service Assistance...................... 268
Service Contract........................ 270
Service Engine Soon Light
(Malfunction Indicator)................... 92
Service Manuals........................ 272
Setting the Clock....................... 100
Side Window Demisters...............132,137
Signals, Turn........................... 92
Slippery Surfaces, Driving On............. 196
Snow Tires............................ 171
Spare Tire.........................167,168
Spark Plugs........................... 210
Speed Control........................74,91
Speedometer........................... 92
Starting.............................. 144
Cold Weather........................ 145
Engine Fails to Start................... 146
288 INDEX