2005 CHRYSLER CROSSFIRE SRT check engine

Fluid Levels
Check fluid levels for the following systems and correct if
necessary. Should there be a loss of fluid that cannot be
explained by regular use, trace and eliminate the cause.
•Engine cooling system (check corrosion inhibitor/
antifreeze)
•Hydraulic brake system
•Power steering system
•Windshield washer system
FSS SYSTEM
The Flexible Service System (FSS) permits a flexible
service schedule that is directly related to the operating
conditions of the vehicle. See the Understanding Your
Instrument Panel section for details on how to use the
FSS.The oil change interval for your Crossfire is initially set at
7,000 miles (Canada: 11,000 km). Very light duty driving
cycles (most trips more than 10 miles [16 km] at moderate
speeds in moderate temperature conditions) can extend
the service interval beyond 7,000 miles (Canada: 11,000
km). IfANYof the following apply to your driving, the
oil change interval can be reduced significantly:
Day or night temperatures are below 32°F (0°C).
Stop and go driving.
Extensive engine idling.
Driving in dusty conditions.
Short trips of less than 10 miles (16 km).
More than 50% of your driving is at sustained high
speeds during hot weather, above 90°F (32°C).
244 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

REGULAR CHECK-UPS
To maintain the safe operation of your vehicle, it is
recommended that you perform the following tasks on a
regular basis (i.e., weekly or whenever the vehicle is
refueled).
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
At Each Stop for Fuel
•
Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. See the procedure de-
scribed in Checking Your Engine Oil in the Under-
standing Your Instrument Panel section or under
Engine Oil in the Maintaining Your Vehicle section.
Add oil only when the level is at or below the ADD or
MIN mark.
•Check the windshield washer solvent and add if
required.
•Inspect wiper blade condition.
•Check operation of lighting systems.
•Inspect tires for unusual wear, damage, and pressure
(at least every 14 days).
•Mechanical assemblies (e.g., engine, transmission, etc.)
- check for leaks.
Once a Month
•
Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder and power steering and add as
needed.
•Check all lights and all other electrical items for correct
operation.
246 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Additional Periodic Maintenance
The following maintenance items should be performed
during the scheduled maintenance nearest the time
elapsed and/or distance shown. Follow the interval that
occurs first.
Every 2 years:
•Inspect body for paint damage.
•Check chassis and supporting body parts for damage
and corrosion.
At approximately every 50,000 miles (80,000 km) or 4
years:
•Check condition of driveshaft flex discs.
•Retighten locking bolts for steering (observe torque).
At approximately every 60,000 miles (96,000 km) or 4
years:
•Replace fuel filter.
•Replace air cleaner filter element.At approximately 80,000 miles (129,000 km):
•Change the automatic transmission fluid and filter.
Use the recommended automatic transmission fluid.
After this change it is filled for life.
At approximately every 100,000 miles (161,000 km) or 5
years:
•Replace spark plugs.
Every 100,000 miles (161,000 km) or 5 years:
•Replace engine coolant using coolant approved to MB
325.0, such as Valvoline GO5, or an equivalent ex-
tended life coolant.
WARNING!
You can be badly injured working on or around a
motor vehicle. Do only that service work for which
you have the knowledge and the right equipment. If
you have any doubt about your ability to perform a
maintenance service, take your vehicle to a compe-
tent technician.
MAINTENANCE SCHEDULES 247
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

SPECIAL MAINTENANCE REQUIREMENTS
Coolant
Have the corrosion inhibitor/antifreeze concentration in
the coolant checked before the onset of winter (once a
year in countries with high prevailing temperatures).
Have the coolant replaced every five years or 100,000
miles (161,000 km).
Dust Filter for Heating/Ventilation Replacement
The dust filter is replaced during routine maintenance
service. The filter element must be replaced with“B”
Schedule service or every 18,500 miles (30,000 km) to
maintain effectiveness. However, if operating conditions
are dusty, these filters should be replaced more fre-
quently. A cover in the HVAC unit that can be reached
from the passenger foot well provides access to the filter
element.
ENGINE OIL CHANGE AND FILTER
REPLACEMENT
The recommended oil and filter change interval is based
on FSS or 1 year. Please refer to the heading FSS System
in this section for a full description of the use and
interpretation of symbols in the FSS system. Only use
synthetic engine oils, approved to MB 229.3 or MB 229.5,
such as Mobil 1 SAE 0W-40. The FSS may not alert for an
oil change at the proper interval if an unapproved engine
oil is used; engine damage and reduced engine life may
result. Information is available from your authorized
dealer. The oil filter should always be changed when the
oil is changed.
248 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

ABS (Anti-Lock Brake) System............. 102
Adding Engine Coolant (Antifreeze)......... 209
Adding Fuel.......................... 160
Aiming Headlights...................... 231
Air Cleaner, Engine (Engine Air Cleaner Filter) . 199
Air Conditioning....................120,202
Air Conditioning Filter................... 248
Air Conditioning Refrigerant.............. 203
Air Conditioning System................. 202
Air Pressure, Tires...................148,149
Airbag................................ 29
Airbag Deployment...................... 33
Airbag Light........................32,107
Airbag Maintenance...................... 39
Airbag On/Off Switch..................36,41
Alignment and Balance.................. 157
Antenna.............................. 119
Antifreeze (Engine Coolant)............... 235
Anti-Lock Warning Light................. 102
Appearance Care....................... 215
Ashtrays and Lighter..................... 63
Automatic Door Locks.................... 13
Automatic Transmission...............131,214Fluid and Filter Changes................ 214
Fluid Level Check..................... 214
Fluid Type.......................... 214
Autostick............................. 134
Ball Joints............................ 204
Battery............................103,201
Saving Feature (Protection)............... 73
Belts, Drive........................... 199
Belts, Seat............................. 22
Body Mechanism Lubrication.............. 204
Brake Assist System...................... 82
Brake, Parking......................... 138
Brake System.......................139,211
Anti-Lock........................... 139
Hoses.............................. 212
Master Cylinder...................... 213
Break-In Recommendations, New Vehicle . . . 46,147
Bulbs, Light........................... 228
Capacities, Fluid....................... 233
Capacity, Cargo Weight.................. 162
Carbon Monoxide Warning................ 47
266 INDEX

Disposal
Engine Oil.......................... 198
Door Locks, Automatic................... 13
Drive Belts............................ 199
Drive Shaft Universal Joints............... 204
Driving
On Slippery Surfaces................151,176
Electronic Speed Control.................. 86
Electronic Stability Program................ 83
Emergency, In Case of
Hazard Warning Flasher................ 166
Jump Starting........................ 174
Overheating......................... 166
Towing............................. 178
Emergency Trunk Release................. 19
Emission Control System Maintenance....193,241
Engine
Break-In Recommendations............... 46
Checking Oil Level.................... 195
Compartment........................ 191
Oil .............................195,235Oil Change Interval................... 197
Oil Selection......................... 198
Exhaust Gas Caution..................... 47
Exhaust System........................ 207
Exterior Lights......................... 228
Filters
Air Cleaner.......................... 199
Air Conditioning..................... 248
Engine Fuel......................... 199
Engine Oil.......................... 198
Fluid Capacities.....................233,235
Fluid Leaks............................ 48
Four-Way Hazard Flasher................. 166
Freeing A Stuck Vehicle.................. 177
Fuel................................. 158
Adding............................. 160
Additives........................... 159
Filler Cap........................... 160
Filter.............................. 199
Octane Rating........................ 158
Fuses................................ 221
268 INDEX

Daytime Running...................... 74
Exterior............................. 74
Exterior Check........................ 48
Fog ................................ 74
Hazard Warning Flasher................ 166
Headlights........................... 74
Instrument Cluster..................... 73
Interior...........................72,228
License............................. 230
Lights On Reminder.................... 74
Malfunction Indicator.................. 108
Map Reading......................... 73
Park.............................74,229
Rear Tail............................ 230
Seat Belt Reminder.................... 103
Turn Signal.......................229,230
Loading Vehicle........................ 261
Capacities........................... 162
Tires ............................... 261
Lubrication, Body....................... 204
Maintenance Free Battery................. 201
Maintenance Procedures.................. 195Maintenance Schedules.................. 241
Malfunction Indicator Light............108,193
Manual Override, Convertible Top.......... 182
Manual, Service........................ 255
Manual Transmission.................... 131
Marker Lights, Side..................... 229
Master Cylinder........................ 213
Mirrors............................... 66
Electric Powered....................... 68
Electric Remote....................... 67
Exterior Folding....................... 67
Heated.............................. 67
Outside............................. 67
Rearview............................ 66
Vanity.............................. 69
Monitor, Tire Pressure System...........80,151
Mopar Parts........................194,254
Multi-Function Control Lever............... 75
Occupant Restraints...................... 22
Oil, Engine........................... 195
Change Interval...................... 197
Checking........................... 195
270 INDEX

Disposal............................ 198
Filter.............................. 198
Materials Added to.................... 198
Recommendation..................... 198
Oil Filter, Selection...................... 198
Onboard Diagnostic System............192,193
Overheating, Engine..................... 166
Owner’s Manual....................... 255
Paint Care............................ 215
Parking Brake......................... 138
Passing Light........................... 77
Pets.................................. 46
Pets, Transporting....................... 46
Power
Outlet.............................. 65
Steering.........................147,203
Steering, Checking.................... 203
Windows............................ 21
Pregnant Women and Seat Belts............. 28
Program Mode Selector Switch............. 136
Programming Transmitters...............92,93Radial Ply Tires........................ 151
Radio Antenna......................... 119
Radio Operation........................ 119
Radio (Sound Systems)................... 111
Rear Liftgate........................... 22
Recommended Fluids, Lubricants and Genuine
Parts............................... 236
Reformulated Gasoline................... 158
Refrigerant............................ 203
Remote Keyless Entry.................... 14
Replacement Tires...................... 155
Reporting Safety Defects................. 254
Residual Engine Heat Utilization (REST)...... 125
Restraints, Child........................ 39
Restraints, Infant........................ 40
Restraints, Occupant..................... 22
Rotation, Tires......................... 156
Safety Checks Inside Vehicle............... 47
Safety Checks Outside Vehicle.............. 48
Safety Tips............................. 47
Schedule, Maintenance................... 241
INDEX 271
10