2005 CHRYSLER 300 service schedule

EMISSION CONTROL SYSTEM MAINTENANCE
The ªScheduledº maintenance services, listed inbold
typemust be done at the times or mileages specified to
assure the continued proper functioning of the emission
control system. These, and all other maintenance services
included in this manual, should be done to provide best
vehicle performance and reliability. More frequent main-
tenance may be needed for vehicles in severe operating
conditions such as dusty areas and very short trip
driving.
Inspection and service also should be done any time a
malfunction is suspected.
NOTE:Maintenance, replacement, or repair of the
emission control devices and systems on your vehicle
may be performed by any automotive repair establish-
ment or individual using any automotive part which has
been certified pursuant to U.S. EPA or, in the State of
California, California Air Resources Board regulations.
MAINTENANCE SCHEDULES
There are two maintenance schedules that show the
requiredservice for your vehicle.
First is ScheduleªBº. It is for vehicles that are operated
under the conditions that are listed below and at the
beginning of the schedule. Change the automatic trans-
mission fluid and filter every 60,000 miles (96 000 km) if
the vehicle is usually operated under one or more of the
conditions marked with anL.
²Day or night temperatures are below 32É F (0É C).
²Stop and go driving.
²Extensive engine idling.
²Driving in dusty conditions.
²Short trips of less than 10 miles (16 km).
²More than 50% of your driving is at sustained high
speeds during hot weather, above 90É F (32É C).
²Trailer towing.L
336 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

²Taxi, police, or delivery service (commercial ser-
vice).L
²Off-road or desert operation.
NOTE:IfANYof these apply to you then change your
engine oil every 3,000 miles (5 000 km) or 3 months,
whichever comes first and follow schedule ªBº of the
9Maintenance Schedules9section of this manual.
NOTE:Most vehicles are operated under the conditions
listed for Schedule9B9.
Second is ScheduleªAº. It is for vehicles that are not
operated under any of the conditions listed under Sched-
ule9B9.
Use the schedule that best describes your driving condi-
tions. Where time and mileage are listed, follow the
interval that occurs first.
NOTE:Under no circumstances should oil change
intervals exceed 6000 miles (10 000 km) or 6 months
whichever comes first.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
At Each Stop for Fuel
²
Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
²Check the windshield washer solvent and add if
required.
Once a Month
²
Check tire pressure and look for unusual wear or
damage.
²Inspect the battery and clean and tighten the terminals
as required.
²Check the fluid levels of coolant reservoir, brake
master cylinder, and transmission and add as needed.
MAINTENANCE SCHEDULES 337
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

SCHEDULE ªBº
Follow schedule ªBº if you usually operate your vehicle
under one or more of the following conditions. Change
the automatic transmission fluid and filter every 60,000
miles (96 000 km) if the vehicle is usually operated under
one or more of the conditions marked with anL.
²Day or night temperatures are below 32É F (0É C).
²Stop and go driving.
²Extensive engine idling.
²Driving in dusty conditions.
²Short trips of less than 10 miles (16.2 km).
²More than 50% of your driving is at sustained high
speeds during hot weather, above 90É F (32É C).
²Trailer towing.L
²Taxi, police or delivery service (commercial ser-
vices).L
²Off-road or desert operation.
²If equipped for and operating with E-85 (ethanol)
fuel.
NOTE:IfANYof these apply to you then change your
engine oil every 3,000 miles (5 000 km) or 3 months,
whichever comes first and follow schedule ªBº of the
9Maintenance Schedules9section of this manual.
SCHEDULE ªBº 339
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

* This maintenance is recommended by the manufacture
to the owner but is not required to maintain the emis-
sions warranty.
³ This maintenance is not required if previously replaced.Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
346 SCHEDULE ªBº
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 78,000 84,000 90,000 96,000 100,000 102,000
(Kilometers) (125 000) (134 000) (144 000) (154 000) (160 000) (163 000)
[Months] [78] [84] [90] [96] [102]
Flush and replace the engine coolant at 60
months or 102,000 miles.X
Replace the air conditioning filter. X X
Rotate the tires. X X X X X
* This maintenance is recommended by the manufacture
to the owner but is not required to maintain the emis-
sions warranty.
³ This maintenance is not required if previously replaced.
Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
WARNING!
You can be badly injured working on or around a
motor vehicle. Do only that service work for which
you have the knowledge and the right equipment. If
you have any doubt about your ability to perform a
service job, take your vehicle to a competent me-
chanic.
350 SCHEDULE ªAº
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Dimmer Switch, Headlight.............. 103
Engine Temperature Warning............ 141
Fog .............................105,140
Hazard Warning Flasher................ 264
Headlight Switch..................... 103
Headlights.......................103,324
Headlights On With Wipers..........104,107
High Beam Indicator................... 144
Illuminated Entry...................... 15
Instrument Cluster.................... 103
Interior............................. 101
License............................. 331
Lights On Reminder................... 104
Malfunction Indicator.................. 146
Oil Pressure......................... 140
Reading............................ 118
Seat Belt Reminder.................... 145
Service..........................322,323
Service Engine Soon................... 146
Turn Signal.......................103,105
Voltage............................. 146
Load Leveling System................... 132
Loading Vehicle.....................256,257Capacities........................... 257
Tires ............................... 232
Locks
Door............................... 15
Lower Anchors and Tether for CHildren
(LATCH).............................. 54
Lubrication, Body....................... 301
Lumbar Support........................ 91
Maintenance Free Battery................. 297
Maintenance Procedures.................. 290
Maintenance Schedule................... 336
Light Duty Schedule9B9................ 339
Schedule9A9......................... 347
Schedule9B9......................... 339
Malfunction Indicator Light............146,288
Manual, Service........................ 356
Manual Transmission.................... 209
Memory Feature........................ 93
Memory Seat........................... 67
Mini-Trip Computer..................... 149
Mirrors............................... 65
Automatic Dimming.................... 65
368 INDEX

Safety Checks Outside Vehicle.............. 59
Safety Defects, Reporting................. 356
Safety Information, Tire.................. 228
Safety Tips............................. 58
Satellite Radio......................... 187
Satellite Radio Antenna.................. 189
Schedule, Maintenance................... 336
Seat Belt Maintenance................... 314
Seat Belt Reminder...................... 35
Seat Belts.............................. 30
Adjustable Upper Shoulder Anchorage...... 34
And Pregnant Women.................. 36
Child Restraint......................50,55
Extender............................ 36
Front Seat............................ 31
Operating Instructions.................. 31
Reminder........................... 145
Seats................................. 89
Glide-To-Exit......................... 95
Heated.............................. 92
Lumbar Support....................... 91
Power.............................. 89
Rear Folding......................... 97Reclining............................ 90
Security Alarm......................... 24
Selection of Coolant..................... 333
Self-Sealing Tires....................... 243
Sentry Key............................ 12
Service Assistance...................... 352
Service Contract........................ 354
Service Engine Soon Light................ 146
Service Manuals........................ 356
Setting the Clock..............158,160,166,176
Settings, Personal....................... 154
Shift Speeds........................... 209
Shoulder Belt Upper Anchorage............. 34
Side Airbag............................ 43
Signals, Turn.......................... 140
Slippery Surfaces, Driving On............. 276
Snow Chains.......................... 248
Snow Tires............................ 249
Spare Tire............................ 268
Spark Plugs........................... 295
Speed Control......................... 115
Speedometer.......................... 140
Starting.............................. 207
INDEX 371
10