2005 CHEVROLET CAVALIER spare wheel

6. Raise the vehicle by turning the jack handle
clockwise. Raise the vehicle far enough off the
ground so there is enough room for the compact
spare tire to t underneath the wheel well.
7. Remove all of the wheel nuts.
{CAUTION:
Rust or dirt on the wheel, or on the parts to
which it is fastened, can make the wheel nuts
become loose after a time. The wheel could
come off and cause an accident. When you
change a wheel, remove any rust or dirt from
the places where the wheel attaches to the
vehicle. In an emergency, you can use a cloth
or a paper towel to do this; but be sure to use
a scraper or wire brush later, if you need to,
to get all the rust or dirt off.
8. Remove any rust or
dirt from the wheel
bolts, mounting
surfaces and spare
wheel.
5-67

9. Place the compact spare tire on the wheel-mounting
surface.
{CAUTION:
Never use oil or grease on studs or nuts. If
you do, the nuts might come loose. Your wheel
could fall off, causing a serious accident.
10. Reinstall the wheel nuts with the rounded end of
the nuts toward the wheel.11. Tighten each nut by hand until the wheel is held
against the hub.
12. Lower the vehicle by turning the jack handle
counterclockwise. Lower the jack completely.
5-68

{CAUTION:
Incorrect wheel nuts or improperly tightened
wheel nuts can cause the wheel to come loose
and even come off. This could lead to an
accident. Be sure to use the correct wheel
nuts. If you have to replace them, be sure to
get new GM original equipment wheel nuts.
Stop somewhere as soon as you can and have
the nuts tightened with a torque wrench to the
proper torque specication. SeeCapacities
and Specifications on page 5-85for wheel nut
torque specication.
Notice:Improperly tightened wheel nuts can
lead to brake pulsation and rotor damage.
To avoid expensive brake repairs, evenly tighten
the wheel nuts in the proper sequence and to
the proper torque specication. SeeCapacities
and Specifications on page 5-85for the wheel nut
torque specication.13. Tighten the wheel nuts
rmly in a crisscross
sequence, as shown.
Notice:Wheel covers will not t on your compact
spare. If you try to put a wheel cover on the compact
spare, you could damage the cover or the spare.
Do not try to put a wheel cover on your compact spare
tire. It will not t. Store the wheel cover in the trunk
until you have the at tire repaired or replaced.
5-69

Storing a Flat or Spare Tire
and Tools
{CAUTION:
Storing a jack, a tire, or other equipment in
the passenger compartment of the vehicle
could cause injury. In a sudden stop or
collision, loose equipment could strike
someone. Store all these in the proper place.
A. Wrench
B. Jack
C. Flat Road Tire
D. Adapter
E. ExtensionF. Wing Bolt
(Extension Installed)
G. Cover
H. Center Retainer Nut
Store the at tire in the compact spare tire compartment
and secure the adapter, extension (aluminum wheel
only) and wing bolt. Store the jack and wheel wrench
in the foam tray.
5-70

The compact spare tire is for temporary use only.
Replace the compact spare tire with a full-size tire as
soon as you can. SeeCompact Spare Tire on
page 5-70. See the storage instructions label to replace
your compact spare tire into your trunk properly.
Compact Spare Tire
Although the compact spare tire was fully inated
when the vehicle was new, it can lose air after a time.
Check the ination pressure regularly. It should be
60 psi (420 kPa).
After installing the compact spare on the vehicle, stop
as soon as possible and make sure the spare tire
is correctly inated. The compact spare is made to
perform well at speeds up to 65 mph (105 km/h)
for distances up to 3,000 miles (5 000 km), so you
can nish your trip and have the full-size tire repaired
or replaced at your convenience. Of course, it is best
to replace the spare with a full-size tire as soon as
possible. The spare tire will last longer and be in good
shape in case it is needed again.Notice:When the compact spare is installed,
do not take your vehicle through an automatic car
wash with guide rails. The compact spare can
get caught on the rails. That can damage the tire
and wheel, and maybe other parts of your vehicle.
Do not use the compact spare on other vehicles.
And do not mix the compact spare tire or wheel with
other wheels or tires. They will not t. Keep the
spare tire and its wheel together.
Notice:Tire chains will not t your compact spare.
Using them can damage your vehicle and can
damage the chains too. Do not use tire chains on
your compact spare.
5-71

Child Restraints (cont.)
Lower Anchorages and Top Tethers for
Children (LATCH System)..........................1-39
Older Children.............................................1-27
Securing a Child Restraint Designed for the
LATCH System........................................1-41
Securing a Child Restraint in a Rear Seat
Position..................................................1-41
Securing a Child Restraint in the Right Front
Seat Position...........................................1-43
Top Strap...................................................1-37
Top Strap Anchor Location............................1-38
Where to Put the Restraint...........................1-36
Chime Level Adjustment..................................3-71
Cigarette Lighter.............................................3-17
Cleaning
Aluminum or Chrome-Plated Wheels..............5-76
Exterior Lamps/Lenses.................................5-75
Fabric/Carpet..............................................5-72
Finish Care.................................................5-75
Glass Surfaces............................................5-74
Instrument Panel.........................................5-74
Interior Plastic Components...........................5-74
Tires..........................................................5-77
Underbody Maintenance...............................5-78
Vinyl..........................................................5-74
Washing Your Vehicle...................................5-75Cleaning (cont.)
Weatherstrips..............................................5-75
Windshield and Wiper Blades........................5-76
Climate Control System...................................3-18
Outlet Adjustment........................................3-20
Clutch, Hydraulic.............................................5-19
Comfort Guides, Rear Safety Belt.....................1-24
Compact Spare Tire........................................5-71
Content Theft-Deterrent....................................2-14
Control of a Vehicle.......................................... 4-5
Convenience Net............................................2-35
Coolant
Engine Temperature Gage............................3-29
Heater, Engine............................................2-19
Low Warning Light.......................................3-30
Surge Tank Pressure Cap.............................5-23
Cooling System..............................................5-25
Cruise Control Lever.......................................3-10
Cupholder(s)..................................................2-35
Customer Assistance Information
Courtesy Transportation.................................. 7-7
Customer Assistance for Text Telephone (TTY)
Users....................................................... 7-4
Customer Assistance Offices........................... 7-4
Customer Satisfaction Procedure..................... 7-2
GM Mobility Program for Persons with
Disabilities................................................ 7-5
3

Safety Belts (cont.)
Rear Safety Belt Comfort Guides for Children
and Small Adults......................................1-24
Rear Seat Passengers.................................1-20
Right Front Passenger Position......................1-20
Safety Belt Extender....................................1-26
Safety Belt Use During Pregnancy.................1-20
Safety Belts Are for Everyone......................... 1-8
Shoulder Belt Height Adjuster........................1-19
Safety Warnings and Symbols.............................. iii
Seatback Latches............................................. 1-6
Seats
Easy Entry Seat............................................ 1-6
Head Restraints............................................ 1-5
Manual........................................................ 1-2
Rear Seat Operation...................................... 1-7
Reclining Seatbacks...................................... 1-4
Seatback Latches.......................................... 1-6
Securing a Child Restraint
Designed for the LATCH System...................1-41
Rear Seat Position......................................1-41
Right Front Seat Position..............................1-43
Selecting the Right Schedule, Maintenance.......... 6-5
Service........................................................... 5-3
Adding Equipment to the Outside of
Your Vehicle.............................................. 5-5
Doing Your Own Work................................... 5-4Service (cont.)
Engine Soon Light.......................................3-30
Publications Ordering Information...................7-11
Vehicle Soon Light.......................................3-35
Servicing Your Airbag-Equipped Vehicle..............1-55
Setting the Time
Radios with Radio Data Systems (RDS).........3-36
Radios without Radio Data Systems (RDS).....3-36
Sheet Metal Damage.......................................5-77
Shifting Into Park (P).......................................2-26
Shifting Out of Park (P)...................................2-28
Short Trip/City Scheduled Maintenance................ 6-6
Shoulder Belt Height Adjuster...........................1-19
Signals, Turn and Lane-Change.......................... 3-8
Spare Tire
Installing....................................................5-65
Removing...................................................5-63
Storing.......................................................5-70
Specications, Capacities.................................5-85
Speedometer..................................................3-23
Starting Your Engine.......................................2-18
Steering........................................................4-10
Steering, Suspension and Front Drive Axle Boot
and Seal Inspection.....................................6-22
Steering Wheel, Tilt Wheel................................. 3-6
11

Storage Areas
Center Console Storage Area........................2-35
Convenience Net.........................................2-35
Cupholder(s)...............................................2-35
Stuck in Sand, Mud, Ice or Snow......................4-28
Sun Visors.....................................................2-13
Sunroof.........................................................2-35
T
Tachometer....................................................3-23
Taillamps
Turn Signal Lamps......................................5-44
Theft-Deterrent, Radio.....................................3-69
Theft-Deterrent Systems...................................2-14
Content Theft-Deterrent................................2-14
Passlock
®...................................................2-15
Throttle System Inspection...............................6-22
Tilt Wheel........................................................ 3-6
Tires.............................................................5-47
Aluminum or Chrome-Plated Wheels,
Cleaning.................................................5-76
Buying New Tires........................................5-56
Chains.......................................................5-60
Changing a Flat Tire....................................5-62
Cleaning....................................................5-77Tires (cont.)
Compact Spare Tire.....................................5-71
If a Tire Goes Flat.......................................5-61
Ination -- Tire Pressure...............................5-53
Inspection and Rotation................................5-54
Installing the Spare Tire................................5-65
Removing the Flat Tire.................................5-65
Removing the Spare Tire and Tools...............5-63
Storing a Flat or Spare Tire and Tools............5-70
Tire Sidewall Labelling..................................5-48
Tire Terminology and Denitions....................5-50
Uniform Tire Quality Grading.........................5-57
Wheel Alignment and Tire Balance.................5-58
Wheel Replacement.....................................5-58
When It Is Time for New Tires......................5-55
Top Strap......................................................1-37
Top Strap Anchor Location...............................1-38
Towing
Recreational Vehicle.....................................4-35
Towing a Trailer..................................4-37, 4-43
Your Vehicle...............................................4-35
Traction
Enhanced Traction System (ETS).................... 4-8
Enhanced Traction System (ETS)
Active Light.............................................3-29
12