2005 BMW 325CI CONVERTIBLE check engine

4 The performance of certain subsequent
maintenance elements, as required by the
BMW New Vehicle Limited Warranty, will be
specified at intervals computed by the BMW
service interval indicator as follows:
– Oil Service: Engine oil changed with the
engine at operating temperature.
Note: change oil at least once a year.
Your BMW is factory-equipped with a
newly-developed synthetic engine oil. At
the time of the printing of this booklet BMW
High-Performance Synthetic 5W-30 Oil
(Part Number 07 51 0 017 866) and Mobil 1
5W-30 and 5W-40 oils are strongly
recommended and approved by BMW for
the 3 Series models covered in this booklet.
BMW is evaluating various synthetic oils for
inclusion in our list of recommended motor
oils.
For the most current list of synthetic oils,
please contact your BMW center, or call
BMW of North America at 1-800-831-1117.
You can also obtain this information from
our website, www.bmwusa.com/.
It is recommended to check engine oil level
whenever fuel is added to the vehicle.
If you need to add oil between oil changes
and are unable to obtain BMW High Per-
formance Synthetic Oil, Mobil 1 or another
special oil on the list, use a synthetic oil
with an API rating of SJ or higher.
– Inspection I: Major vehicle maintenance
as specified in the following pages under
Inspection I.
– Inspection II: Additional major vehicle
maintenance as specified in the following
pages under Inspection II.
The following maintenance elements must
be performed at the mileage/time stated
(time intervals begin from the vehicle’s
production date):
– Brake Fluid Service: Change brake fluid
every two years.– Oxygen Sensor Service: The oxygen sensor
deteriorates strictly on a mileage basis and
must therefore be replaced every 120,000
miles (3 Series with optional Sequential
Manual Gearbox (SMG) 100,000 miles), to
maximize vehicle fuel economy and
minimize exhaust pollution. In the SULEV
(PZEV) models, the oxygen sensor must
be replaced every 150,000 miles. The
replacement of the oxygen sensor is
required under the terms of the appli-
cable BMW emission system warranties.
– Spark Plug Service: Replace spark plugs
every 100,000 miles. Your BMW is
equipped with platinum-tipped spark plugs.
These allow a longer service life than
conventional spark plugs.
– Automatic Transmission Service: Change
ATF every 100,000 miles.
The engine coolant has a lifetime rating and
does not need to be changed.
For your convenience, you may also wish to
have your BMW center perform any necessary
operations to fulfill any state inspection
requirements in your area concurrent with the
maintenance elements specified above during
other repairs.
Make sure that confirmation of maintenance
work is always entered in this Service and
Warranty Information Booklet. You may need
this for any warranty claims that become
necessary, and later on as evidence that your
car has been given the correct and regular
maintenance that justifies its resale or trade-in
value.
BMW has applied the most modern techno-
logical advances not only to the design and
production of your vehicle, but also to comput-
ing of the optimum maintenance interval for
your type of operations and driving style. Your
BMW center has made a substantial invest-
ment in unique BMW special service tools to
enable his BMW factory trained service
technicians to perform quality repairs on your
BMW in minimal time. He/she looks forward to
serving your every service need and to help
maximize your satisfaction with your BMW, its
longevity, and resale value.

6
3 Series325i, 325Ci, 325iT
+ Conv. SULEV (PZEV)
Change oil and oil filter while engine is at normal • •
operating temperature. We recommend BMW 5W-30
High Performance Synthetic Oil, p/n 07 51 0 017 866.
Reset service interval indicator. • •
Replace microfilter. • •
Check overall thickness of front and rear disc brake pads using • •
special tool. If replacement is necessary: Examine brake
disc surfaces. Clean brake pad contact points in calipers.
Grease wheel centering hubs. Check thickness of parking
brake linings only when replacing rear pads.
Check parking brake actuation. Adjust if necessary. • •
Engine Oil Service
Engine Compartment
Lubricate convertible top sliding linkage covers. •
Body

Inspection I
Only those items of inspection work which apply to your vehicle will be performed. This list is
subject to amendment.
Undercarriage
7
3 Series325i, 325Ci, 325iT
+ Conv. SULEV (PZEV)
Change oil and oil filter while engine is at normal operating • •
temperature. We recommend BMW 5W-30 High Performance
Synthetic Oil, p/n 07 51 0 017 866.
Check transmission for leaks. • •
Check rear axle for leaks. • •
Half-shafts: Check for leaks at flexible boots. • •
Visually check fuel tank, lines and connections for leaks. • •
Check condition, position, and mounting of exhaust system. • •
Examine for leaks.
Check power steering system for leaks. Check power steering • •
fluid level; add fluid if necessary.
Check steering for absence of play, condition of suspension track • •
rods, front axle joints, steering linkage and joint disc.
Check overall thickness of front and rear disc brake pads using • •
special tool. If replacement is necessary: Examine brake disc surfaces.
Clean brake pad contact points in calipers. Grease wheel centering
hubs. Check thickness of parking brake linings only when replacing
rear brake pads.
Check brake system connections and lines for leaks, damage • •
and incorrect positioning.
Check parking brake actuation. Adjust if necessary. • •
Check all tire pressures (including spare). Correct if necessary. • •
Check condition of tires (outer surface [left/right]), tread wear and
pattern; in case of uneven tread wear, readjust wheel alignment
if requested (invoice separately).
Inspect entire body according to terms of rust perforation limited • •
warranty (Must be performed at least every two years).
Engine Compartment
Read out diagnostic system. • •
Check engine cooling system/heater hose connections for leaks. • •
Check coolant level and antifreeze protection level. Add coolant
if required.
Check windshield washer fluid level and antifreeze protection. • •
Fill up and/or correct if required.
Check air conditioner for operation. • •
Replace microfilter. (Note: reduce replacement interval in dusty • •
operating conditions.)
Reset service interval indicator.••

3 Series325i, 325Ci, 325iT
+ Conv. SULEV (PZEV)
Replace air cleaner element. (Note: Reduce replacement interval • •
in dusty operating conditions).
Inspection II
Includes all items listed under Inspection I, and the following checks
and maintenance operations.
Engine Compartment
9
Brake Fluid Service
Replace brake fluid every 2 years (time interval begins from the • •
vehicle’s production date).
Oxygen Sensor Service
Replace Oxygen Sensor every 120,000 miles (non-SMG). •
Replace Oxygen Sensor every 100,000 miles (only SMG). •
Replace Oxygen Sensor every 150,000 miles. •
Spark Plug Service
Replace spark plugs every 100,000 miles. • •
Automatic Transmission Service
Replace ATF every 100,000 miles. • •

• The same nonconformity [a failure to
conform to the written warranty that
substantially impairs the use, value or
safety of the vehicle] results in a condition
that is likely to cause death or serious
bodily injury if the vehicle is driven AND the
nonconformity has been subject to repair
two or more times by BMW or its agents
AND the buyer or lessee has directly
notified BMW of the need for the repair of
the nonconformity; OR
• The same nonconformity has been subject
to repair 4 or more times by BMW or its
agents AND the buyer has notified BMW of
the need for the repair of the nonconformity;
OR
• The vehicle is out of service by reason of
repair of nonconformities by BMW or its
agents for a cumulative total of more than
30 calendar days after delivery of the
vehicle to the buyer.
NOTICE TO BMW AS REQUIRED ABOVE
SHALL BE SENT TO THE FOLLOWING
ADDRESS:
BMW of North America, LLC
Customer Relations Department
P.O. Box 1227
Westwood, New Jersey 07675-1227
1 (800) 831-1117
8. The following remedies may be sought in
BBB AUTO LINE: repairs, reimbursement for
money paid to repair a vehicle or other
expenses incurred as a result of a vehicle
nonconformity, repurchase or replacement of
your vehicle and compensation for damages
and remedies available under BMW’s written
warranty or applicable law.
9. The following remedies may not be sought
in BBB AUTO LINE: punitive or multiple
damages, attorneys’ fees, or consequential
damages other than as provided in California
Civil Code Section 1794(a) and (b).
10. You may reject the decision issued by a
BBB AUTO LINE arbitrator. If you reject the
decision, you will be free to pursue further
legal action. The arbitrator’s decision and any
findings will be admissible in a court action.11. If you accept the arbitrator’s decision,
BMW will be bound by the decision, and will
comply with the decision within a reasonable
time not to exceed 30 days after we receive
notice of your acceptance of the decision.
12. Please call BBB AUTO LINE at 1-800-
955-5100 for further details about the
program.
BMW Import Processing Centers
As a BMW owner, you will experience BMW
quality first hand. Our dedication to excellence
in design, engineering, and service is among
the best in the world. And we invest heavily
every year in our people and facilities to
ensure that our quality standards are consis-
tently applied from the factory to the BMW
center. Part of that investment program is
devoted to our multi-million-dollar
Import Processing Centers staffed by our
highly trained specialists.
At these state-of-the-art facilities, each BMW is
given a thorough inspection after its trans-
atlantic shipment to the United States.
Imperfections in the mechanical and electrical
systems or damage to the sheet metal, paint,
trim or other components of the vehicle which
may occur during transportation from the
factory to the United States are normally
detected and corrected at the Import
Processing Centers in the United States.
Any defect in material or workmanship which
occurs during the warranty period is covered
under the New Vehicle Limited Warranty.
Special Programs
SOMETIMES BMW OF NORTH AMERICA
OFFERS A SPECIAL ADJUSTMENT
PROGRAM TO PAY ALL OR PART OF THE
COST OF CERTAIN REPAIRS BEYOND
THE TERMS OF THE WARRANTY. CHECK
WITH YOUR BMW CENTER TO DETER-
MINE WHETHER ANY ADJUSTMENT
PROGRAM IS APPLICABLE TO YOUR
MOTOR VEHICLE.
25

The California Air Resources Board and BMW
of North America (BMW NA) are pleased to
explain the emission control system warranty
on your 2005 vehicle. In California, new motor
vehicles must be designed, built and
equipped to meet the State’s stringent anti-
smog stan-dards. BMW NA must warrant the
emission control system on your vehicle for the
periods of time listed below provided there has
been no abuse, neglect or improper
maintenance of your vehicle.
Your emission control system may include
parts such as the fuel injection system, the
ignition system, catalytic converter, and engine
computer. Also included may be hoses, belts,
connectors and other emission-related
assemblies.
Where a warrantable condition exists, BMW NA
will repair your vehicle at no cost to you
including diagnosis, parts and labor.
Manufacturer’s Warranty Coverage:
– For 3 years or 50,000 miles or 15 years or
150,000 miles for the SULEV (PZEV),
whichever occurs first:
1. If your vehicle fails a Smog Check inspec-
tion, all necessary repairs and adjustments
will be made by BMW NA to ensure that
your vehicle passes the inspection. This is
your emission control system PERFOR-
MANCE WARRANTY.
2. If any emission-related part on your vehicle
is defective, the part will be repaired or
replaced by BMW NA. This is your short-
term emission control system DEFECTS
WARRANTY.
– For 7 years or 70,000 miles whichever
occurs first:
If an emission-related part, specially noted on
page 41 as having coverage for 7 years or70,000 miles is defective, the part will be
repaired or replaced by BMW NA. This is your
long-term emission control system DEFECTS
WARRANTY.
Owner’s Warranty Responsibilities:
– As the vehicle owner, you are responsible
for the performance of the required mainte-
nance listed in your Owner’s Manual. BMW
NA recommends that you retain all receipts
covering maintenance on your vehicle, but
BMW NA cannot deny warranty solely for
the lack of receipts or for your failure to
ensure the performance of all scheduled
maintenance.
– You are responsible for presenting your
vehicle to an authorized BMW center as
soon as a problem exists. The warranty
repairs should be completed in a reason-
able amount of time, not to exceed 30 days.
– As the vehicle owner, you should also be
aware that BMW NA may deny your
warranty coverage if your vehicle or part has
failed due to abuse, neglect, improper
maintenance or unapproved modifications.
If you have any questions regarding your
warranty rights and responsibilities, you should
contact:
BMW of North America
Customer Relations Department
PO. Box 1227
Westwood, N.J. 07675-1227
Telephone: 1-800-831-1117
Website: www.bmwusa.com
or the
California Air Resources Board
9528 Telstar Avenue
El Monte, CA 91731
*The California Emissions Control System
Limited Warranty applies to all 2005 U.S.
specification BMW 3 Series vehicles (except
M3) sold, leased, and/or registered in
California, Maine, Massachusetts, New York
or Vermont.
California Emission Control
Warranty Statement*
Your Warranty Rights and
Obligations
37