2005 Alfa Romeo GT power steering

VEHICLE MAINTENANCE
254fig. 3 - JTD 16Vversion1Engine oil - 2Battery - 3Brake fluid -4
Windscreen/rearscreen/headlamp
washer fluid - 5Engine coolant fluid -
6Power steering fluid
A0A0396b A0A0683b
fig. 2 - 3.2 V6version
1Engine oil - 2Battery - 3Brake fluid -4
Windscreen/rearscreen/headlamp
washer fluid - 5Engine coolant fluid -
6Power steering fluid

Oil consumption is very
low; if topping up again is
needed shortly after-
wards, have the system checked
for possible leaks by Alfa Romeo
Authorised Services.
VEHICLE MAINTENANCE
258
When loosening the
reservoir cap do not
allow the fluid to come
into contact with painted parts. If
it does, wash it off immediately
with water. Do not allow the power
steering fluid to touch hot
parts of the engine: it is
inflammable.
fig. 10
A0A0217b
fig. 9
A0A0400b
BRAKE AND HYDRAULIC
CLUTCH FLUID
(fig. 10)
Slacken the cap (A) and check that the
fluid contained in the reservoir reaches the
maximum mark.
POWER STEERING FLUID
(fig. 9)
Check that the level of the oil in the
reservoir is at maximum.
This operation should be carried out with
the vehicle on a level surface and the
engine switched off and cold.
Check that the level reaches the MAX
mark on the reservoir or coincides with the
upper notch (maximum level) on the dip-
stick (A) integral with the reservoir cap.
If the oil level in the reservoir is below
the specified one, top up only with one of
the products listed in the “Fluid and lubri-
cant Specification” table in the “Technical
Specifications” chapter proceeding as fol-
lows:– Start the engine and wait for the oil
level in the reservoir to stabilise.
– With the engine running, turn the
steering wheel lock to lock a few times.
– Top up to the MAXlevel notch, then
refit the cap.

TECHNICAL SPECIFICATIONS
275
Service brakes:– front
– rear
Parking brake
BRAKES
Front
Rear
Type
Turning radius
(between pavements) m1.8 T. SPARK - 2.0 JTS - 3.2
V6 - JTD16V
rack and pinion with hydraulic power steering
11.5
SUSPENSIONS
STEERING SYSTEM
1.8 T. SPARK - 2.0 JTS - 3.2 V6- JTD16V
Disk
Disk
Controlled by hand lever, acting on the rear brakes
1.8 T. SPARK - 2.0 JTS - 3.2
V6 - JTD16V
quadrilateral system with stabiliser bar
Mc Pherson type

TECHNICAL SPECIFICATIONS
282
REFILLING
2.0JTS
Selespeed
63
7
7.2
–
4.4
2.0
0.6
1.2
0.52
2.5
4.2
3.2V6
63
7
7.2
–
5.9
2.0
–
1.2
0.52
2.5
4.2
1.8 T. SPARK
63
7
7.2
4.4
–
2.0
–
1.2
0.52
2.5
4.2
2.0JTS
63
7
7.2
–
4.4
2.0
–
1.2
0.52
2.5
4.2
Fuel tank: litres– including a reserve of litres
Engine cooling
system litres
Oil sump and filter litres
litres
Mechanical transmission/
differential litres
Selespeed transmission litres
Hydraulic power steering litres
Hydraulic brake circuit with
ABS device litres
Windscreen
washer reservoir: litres
– with headlamp washer litresSpecified fuels
and original lubricants
Unleaded Premium petrol with no
less than 95 R.O.N
Mixture of distilled water
andPARAFLU UP at 50%
SELENIA 20 K Alfa Romeo
SELENIA RACING
TUTELA CAR TECHNYX
TUTELA CAR CS SPEED
TUTELA GI/A
TUTELA TOP 4
for Alfa Romeo
Mixture of water and fluid
TUTELA
PROFESSIONAL SC 35

TECHNICAL SPECIFICATIONS
283
JTD16V
63
7
7.2
4.5
2.0
1.2
0.52
2.5
4.2
Fuel tank: litres– including a reserve of litres
Engine cooling
system litres
Oil sump and filter litres
Mechanical transmission/
differential litres
Hydraulic power steering litres
Hydraulic brake circuit with
ABS device litres
Windscreen
washer reservoir: litres
– with headlamp washer litresSpecified fuels
and original lubricants
Diesel fuel for motor vehicles
(Specification EN590)
Mixture of distilled water and
PARAFLU UP at 50%
SELENIA WR
TUTELA CAR TECHNYX
TUTELA GI/A
TUTELA TOP 4
for Alfa Romeo
Mixture of water and fluid
TUTELA PROFESSIONAL SC 35

TECHNICAL SPECIFICATIONS
285
UseGenuine fluids
and lubricants
TUTELA CAR
TECHNYX
TUTELA GI/A
TUTELA CAR CS SPEED
TUTELA STAR 500
TUTELA TOP 4
for Alfa Romeo
PARAFLU UP
TUTELA
PROFESSIONAL SC 35Applications
Mechanical gearbox
and differential
Power steering
Selespeed gearbox
electric control electro-
hydraulic actuator
CV joints on wheel side
Hydraulic brake and
clutch controls
Cooling circuits
Proportion:
50% water
and 50% Paraflu UP
To be used diluted or
undiluted Fluid and lubricant specifications
for correct car operation
Synthetic-based oil, grade SAE 75W-85,
that passes API GL-4 Plus specifications
Lubricant for hydrostatic transmissions that passes
"ATF DEXRON II" specifications
Special lubricant with "ATF DEXRON III" type additive
Lithium-soap-based grease with molybdenum bisulphate, NLGI 2 consistency
Synthetic fluid, F.M.V.S.S. n. 116, DOT 4, ISO 4925, SAE J-1704,
CUNA NC 956-01
Protective with antifreeze action, red colour, based
on inhibited monoethylen glycol and organic formula,
that passes CUNA NC 956-16, ASTM D 3306 specifications
Mixture of alcohol, water and surfactants CUNA NC 956-11
IMPORTANTDo not top-up or mix with products having different properties
Lubricants and greases
for transmissions
Brake fluid
Protective agent for radiators
Windscreen and
rear window washer fluid

INDEX
294
Oddment recesses ...................... 138
Outside temperature ..................... 58
Paintwork
- colour label ............................ 272
Parking ...................................... 203
Parking sensor ............................ 123
Pockets on doors ......................... 142
Pollen filter ..................... 108-123-261
Power steering oil ....................... 258
Power windows .......................... 24
Pretensioners .............................. 28
Puddle lights .............................. 140
- changing bulbs ....................... 232
Radio transmitters
and cell phones ......................... 144
Radio with CD player ................... 156
Rain sensor ................................ 48
Raising the car
- with an arm lift ...................... 245
- with a workshop lift ................ 245
- with the jack .......................... 215
Rear ceiling light ......................... 140- changing bulbs ....................... 233
Rear fog guards
- changing bulbs ....................... 230
- switching on .......................... 125
Rear oddment pockets ................. 142
Rearview mirror .......................... 23
Reducing running costs
and environment pollution ......... 203
Refuelling
- specifications ......................... 282
Remote control
- additional remote controls ........ 11
- door opening-closing ............... 7
- tailgate opening ..................... 8
Rev counter ................................ 55
Reversing light
- changing bulbs ....................... 230
Roof rack (provision) ................... 150
Scheduled maintenance
programme .............................. 248
Seat belts .................................. 26
- carrying children safety ............ 31
- front belt height adjustment ..... 27
- general instructions ................. 29- load limiters ........................... 29
- maintenance .......................... 31
- pretensioners ......................... 28
- rear centre lap belt .................. 27
- use of belts ............................ 26
Seats, front ................................ 16
- adjustments ..................... 16-17
- centre armrest ........................ 17
- headrest ................................ 18
- heating ................................. 18
- rear pockets ........................... 18
- tilting the back rest ................. 17
Seats, rear ................................. 19
- boot extension ....................... 19
- centre armrest ........................ 22
- headrest. ............................... 21
Selespeed gearbox ...................... 128
Sidelights
- changing front bulbs ......... 225-228
- changing rear bulbs ................. 230
- switching on .......................... 45
Snow chains ............................... 208
Spray jets
- windscreen/rearscreen ............ 267