2004 YAMAHA TT600RE wiring

SPECCABLE ROUTING
2-29
(1) Rectifier
(2) Wire harness bands
(3) Protection
(4) Left turn wire
harness(5) Right turn wire
harness
(6) Tail light wire
harness
(7) Air breather pipe
(carburetor)(8) Wire extension
(9) Starter power
cables
(10) Engine cables and
side stand switch[A] Screw protection 3
after setting wiring
properly.













ProCarManuals.com

ELECIGNITION SYSTEM
7-13
DIAGNOSTICS IF THE IGNITION SYSTEM WERE TO STOP WORKING (NO OR INTERMITTENT SPARK)
Procedure
Check:
1. Fuse
2. Battery
3. Spark plug
4. Amplitude of ignition spark
5. Spark plug cap resistance
6. Ignition winding resistance 7. Main switch
8. Engine stop switch
9. Sidestand switch
10. Neutral switch
11. Clutch switch
12. Pick-up coil resistance
13. Wiring connections (whole connection sys- tem)
NOTE:
Before making the inspections mentioned, remove the following parts:
1. Seat
2. Rear cowling 3. Fuel tank
4. Cowling (headlight)
•To check functioning defects use the following special tools.
Dinamic spark tester: P/N. 90890-06754
Pocket tester:P/N. 90890-03112
1. Fuse
•Check the fuse for continuity.
Refer to “CHECKING THE FUSES” in
Chapter 3.
•Is the fuse OK?
YES
2. Battery
•Check the condition of the battery.
Refer to “CHECKING AND CHARGING
THE BATTERY” in Chapter 3.
Min. open-circuit voltage:
2.8 V or more at 20°C (68°F)
•Is the battery OK?
NO
Replace the fuse.
NO
•Clean the battery terminals.
•Recharge or replace the battery.
YES
*
ProCarManuals.com

ELECIGNITION SYSTEM
7-19
*
12. Pick-up coil resistance.
•Disconnect the generator connector
(Green/White and Blue/Yellow).
•Connect the pocket tester ( Ωx 100) to
pick-up coil cables.
Tester terminal (+) ➔
Blue/Yellow cable (1)
Tester terminal (–) ➔
Green/White cable (2)
•Check that the pick-up coil resistance is as
specified.
Pick-up coil resistance: 230 Ω ±
±
20% at 20°C (68°F)
(Green/White - Blue/Yellow)
COMPLY WITH
SPECIFICATIONS
CORRECT
OUT OF SPECIFICATIONS
The pick-up coil is defective. Replace.
UNCERTAIN CONNECTIONS Correct.13. Wiring connections.
Check the connections of the entire ignition
system. Refer to “ELECTRICAL CIRCUIT
DIAGRAM” section.
The CDI unit is defective. Replace.
ProCarManuals.com

ELECCHARGING SYSTEM
7-39
CORRECT
IN COMPLIANCE
WITH SPECIFICATIONS
OUT OF SPECIFICATIONS
Stator winding is defective. Replace.
UNCERTAIN CONNECTIONS Correct.
Stator coils (2)
Tester terminal (+) ➔White cable (1)
Tester terminal (-) ➔White cable (3)
•Check that the winding resistance of the
stator complies with specifications.
Stator coil resistance: White (1) – White (2)
0.65 Ω± 20% at 20°C (68°F)
White (1) – White (3) 0.65 Ω± 20% at 20°C (68°F)


$

5. Wiring connections.
•Check the connections of the entire char-
ging system.
Refer to “ELECTRICAL CIRCUIT DIA-
GRAM” section.
The rectifier/regulator is defective. Replace.
ProCarManuals.com

TT600RE WIRING DIAGRAM
467C4B5CAMP403D494A4856 172320-2
GWLY
BB
B
BBLWRB
R
B
B
B
RLBOrRBLYGW
Or
B
LW
MAIN HARNESSB
B
B
Y Y
LBG
LGRBLYGWLWLBOrRB
LW
GY
GY
RBBr
Br
187
GB
12V10W
BL12V5WB
Y G
12V60/55WBGYA
A
12V10W
A
GB
BrBBrB
B
GBB
GBB
GBB
BrB
12V10WB
B
BrL
GB
12V10WB
B
187
BY
B
R
B
BrL
WWB
OFF
BrL
W
B
W
BB
B
B
BLB
BBrB
G
B
BrB
Br
OFF
B
EXT. CORD
Br
GY
BL
G Y
GYB
B
L
GB
BrB
LR
LR SbB
RW
-
LR
L
BrL
GBSbB
BrB
YBrBrB
YBrGB
B
Ch
DgBrY
BrB
HIGH
TURN
NEU.ILL.
B
BrL
BrL
LB
BY
LY
LB
LYGW
B
RBOr
205
B
RBLBrL
Br
PARKOFFON
ON
ON
Sb
L
GB
GY G
Y
RBLYBY
LYBY
RUN
LW
B
B
LY
BY
LBrRR
LWRB
GB
R
B
GW
BrBrW
WB
Br
LY
WB
Sb
B
GWLY
(BLUE)B
B
LYB
OFF
BrRB
LWRB
Y
P
G
GB BBrWBrL
BrB
W
WW
GYBr
GY
Y
P
G
GB BBrWBrL
BrB
Y
N
RL
LOWHIGH
BrW BrWBr
PPBr
LY
B
GWLY
Or
RBBr
LW
BY
BY
START
OFF
R
B
GWLY
W
W
W
W
W
W
WRW
W
W
Sb
B
Sb
B
BrBB
-
-
B
LR
WRW
B
-
A
L
L
GY
LB
Br
WB
RB
MAIN HARNESS
AHEAD LIGHT
B
B
BrB

17
16
11
12
13
14
15
91029
8
5
3
12
64
28
20
21
22
19
2325
24
30
31
27
267
32
18
ELECTRICAL SYSTEM
DIAGRAM1 AC generator/Pickup coil
2 Rectifier/Regulator
3 Battery
4 Starter relay
5 Starting motor
6 Fuse
7 Main switch
8 Right handlebar switch
9 Engine stop switch
0 Starter switch
q Diode
w Clutch switch
e Sidestand switch
r Neutral switch
t Diode
y Ignitor unit
u Ignition coil
i Left handlebar switch
o Horn switch
p Diode
a Pass switch
s Dimmer switch
d Flasher switch
f Horn
g Flasher relay
h Headlight
j Flasher light
k Relay assy
l Front brake switch
; Rear brake switch
z Tail/stop light
x Meter
COLOR CODE
B ...........Black
Br ..........Brown
Ch .........Chocolate
Dg .........Dark green
G...........Green Gy .........Gray
L............Blue
Lg..........Light green
O...........Orange
P ...........Pink R...........Red
Sb .........Sky blue
W..........White
Y ...........Yellow
B/L ........Black/Blue B/W.......Black/White
B/Y........Black/Yellow
Br/B.......Brown/Black
Br/L .......Brown/Blue
Br/W......Brown/White Br/Y.......Brown/Yellow
L/B ........Blue/Black
L/R ........Blue/Red
L/W .......Blue/White
L/Y ........Blue/Yellow R/B........Red/Black
R/G .......Red/Green
R/W.......Red/White
R/Y........Red/Yellow
ProCarManuals.com